PEUGEOT 504 (1968–1989) — Technical Guide, Fault Codes & Maintenance
Built 1968–1989 · all production years covered on this single page
2.3 D (69 PS) • Diesel
1989
© Wikimedia Commons CC BY-SA
Alle Daten auf dieser Seite zu Peugeot 504 (1968–1989) sind aus über 6,6 Millionen realen Werkstattvorgängen, NHTSA-Registern und technischen OEM-Quellen zusammengeführt und abgeglichen — und werden laufend aktualisiert. Keine erfundenen Schätzungen.
Angetrieben von einem 2.3 D (69 Hp)-Motor. Nutzen Sie die Abschnitte unten für verifizierte Betriebsstoffe, Batterie, OEM-Reifen, den Wartungsplan, die empfohlenen Ersatzteile und die am häufigsten gemeldeten OBD2-Fehlercodes für dieses Fahrzeug.
Häufige Probleme
Häufige Reparaturen
Betriebsstoffe und Schmierstoffe
Batterie
Fehlercodes (OBD2)
Kontrollleuchten
Empfohlene Ersatzteile
Zubehör und Werkzeuge
Reifen
Rückrufe und Bulletins
Werkstätten in der Nähe
HÄUFIGE PROBLEME
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Verwandte Codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Verwandte Codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Verwandte Codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Verwandte Codes: P0562
P0011LOW
Check with an OBD2 scanner.
Verwandte Codes: P0011
DURCHSCHNITTLICHE RICHTKOSTEN
Die Preise können je nach Region und Werkstatt variieren.
Komplette Wartung
€ 120 – € 200
Komplette Bremsen
€ 180 – € 300
Zündkerzenwechsel
€ 80 – € 140
Elektronische Diagnose
€ 40 – € 70
WERKSTATT-STUNDENSÄTZE NACH LAND
Durchschnittliche Stundensätze unabhängiger Werkstätten, zur Schätzung der Reparaturkosten in Ihrem Land.
🇩🇪Deutschland€95/h
🇪🇸Spanien€55/h
🇫🇷Frankreich€75/h
🇮🇹Italien€45/h
🇬🇧Vereinigtes Königreich£80/h
🇺🇸USA$120/h
Referenzsatz
€95/h
Quelle: Eurostat 2024
💧 BETRIEBSSTOFFE UND SCHMIERSTOFFE
📋 RÜCKRUFE UND BULLETINS (23)
NHTSA 80V110000
Equipment › Appliance › Air Conditioner
Date: 27/08/1980
THE AIR CONDITIONING UNITS ON THE INVOLVED VEHICLES MAY HAVE BEEN FILLED WITH AN UNECESSARILY LONG LENGTH OF WIRE FROM THE BLOWER SPEED CONTROL RESISTORS TO THE EVAPORATOR BLOWER MOTOR. DUE TO THE LENGTH OF THE WIRE, CHAFING OR PINCHING MAY OCCUR AT SOME POINT, CAUSING A SHORT CI…
NHTSA 80V110000
Equipment › Appliance › Air Conditioner
Date: 27/08/1980
THE AIR CONDITIONING UNITS ON THE INVOLVED VEHICLES MAY HAVE BEEN FILLED WITH AN UNECESSARILY LONG LENGTH OF WIRE FROM THE BLOWER SPEED CONTROL RESISTORS TO THE EVAPORATOR BLOWER MOTOR. DUE TO THE LENGTH OF THE WIRE, CHAFING OR PINCHING MAY OCCUR AT SOME POINT, CAUSING A SHORT CI…
NHTSA 73V223000
Seat Belts › Front
Date: 19/11/1973
NHTSA 73V223000
Seat Belts › Front
Date: 19/11/1973
NHTSA 73V223000
Seat Belts › Front
Date: 19/11/1973
NHTSA 78V178000
Service Brakes, Hydraulic › Power Assist › Vacuum
Date: 16/08/1978
WATER COULD ACCUMULATE BETWEEN THE MOUNTING SURFACE OF THE BRAKE POWER BOOSTER UNIT AND THE FRONT SURFACE OF THE PEDAL SUPPORT BRACKET TO WHICH IT IS ATTACHED. AFTER A PERIOD OF TIME, THE WATER COULD CAUSE CORROSION, WHICH WOULD HINDER THE FREE MOVEMENT OF THE POWER BOOSTER PISTO…
NHTSA 78V178000
Service Brakes, Hydraulic › Power Assist › Vacuum
Date: 16/08/1978
WATER COULD ACCUMULATE BETWEEN THE MOUNTING SURFACE OF THE BRAKE POWER BOOSTER UNIT AND THE FRONT SURFACE OF THE PEDAL SUPPORT BRACKET TO WHICH IT IS ATTACHED. AFTER A PERIOD OF TIME, THE WATER COULD CAUSE CORROSION, WHICH WOULD HINDER THE FREE MOVEMENT OF THE POWER BOOSTER PISTO…
NHTSA 75V209000
Seats
Date: 15/12/1975
NHTSA 73V028000
Service Brakes, Hydraulic › Foundation Components › Master Cylinder
Date: 09/01/1973
NHTSA 73V028000
Service Brakes, Hydraulic › Foundation Components › Master Cylinder
Date: 09/01/1973
NHTSA 73V028000
Service Brakes, Hydraulic › Foundation Components › Master Cylinder
Date: 09/01/1973
NHTSA 72V104000
Seat Belts › Front › Webbing
Date: 08/05/1972
NHTSA 73V199000
Visibility › Windshield
Date: 05/10/1973
NHTSA 73V199000
Visibility › Windshield
Date: 05/10/1973
NHTSA 73V199000
Visibility › Windshield
Date: 05/10/1973
NHTSA 73V199000
Visibility › Windshield
Date: 05/10/1973
NHTSA 74V068000
Visibility › Rearview Mirrors/Devices › Interior
Date: 03/05/1974
NHTSA 74V068000
Visibility › Rearview Mirrors/Devices › Interior
Date: 03/05/1974
NHTSA 74V068000
Visibility › Rearview Mirrors/Devices › Interior
Date: 03/05/1974
NHTSA 74V068000
Visibility › Rearview Mirrors/Devices › Interior
Date: 03/05/1974
NHTSA 74V068000
Visibility › Rearview Mirrors/Devices › Interior
Date: 03/05/1974
NHTSA 74V068000
Visibility › Rearview Mirrors/Devices › Interior
Date: 03/05/1974
NHTSA 74V164000
Service Brakes, Hydraulic › Foundation Components › Hoses, Lines/Piping, And Fittings
Date: 01/10/1974
HÄUFIGE ZU PRÜFENDE OBD2-CODES
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
Alle für dieses Fahrzeug dokumentierten Fehlercodes
Die am besten dokumentierten Diagnosecodes für dieses Modell, nach System und Schweregrad. Tippen Sie auf einen Code für die vollständige Anleitung.
P0455
powertrain
NIEDRIG⏱ 0.62h im SchnittP0442
powertrain
NIEDRIG⏱ 0.62h im SchnittP0440
powertrain
NIEDRIG⏱ 0.78h im SchnittP0420
powertrain
MEDIUM⏱ 1.24h im SchnittP0300
powertrain
HOCH⏱ 1.22h im SchnittP0172
powertrain
MEDIUM⏱ 1.13h im SchnittP0171
powertrain
MEDIUM⏱ 0.95h im SchnittP0730
transmission
MEDIUM⏱ 1.25h im SchnittP0700
transmission
HOCH⏱ 1.25h im SchnittP0401
powertrain
MEDIUM⏱ 1.25h im SchnittP0011
powertrain
MEDIUM⏱ 5.4h im SchnittU0100
network
HOCHP0562
electrical
MEDIUM⏱ 0.58h im SchnittP0128
powertrain
MEDIUM⏱ 0.88h im Schnitt
KONTROLLLEUCHTEN — UNIVERSELLER LEITFADEN
53 Kontrollleuchten nach Dringlichkeit sortiert. Erscheint sie in Ihrem Fahrzeug? Prüfen Sie die Dringlichkeitsstufe.
Alle Kontrollleuchten anzeigen
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
Häufige Fragen
Which OBD2 fault codes are commonly documented for the Peugeot 504 (1968–1989)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Peugeot 504 (1968–1989) be serviced?
Routine maintenance for the Peugeot 504 (1968–1989) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
This spec sheet is updated with data verified from OEM sources and shop databases. If you spot an inaccuracy or have additional data on the Peugeot 504 (1968–1989), let us know — every correction improves quality for all users.