TroubleAtlas Score
VOLKSWAGEN CABRIO (1990–2002) Manual — Codes, Tyres & Parts
Built 1990–2002 · all production years covered on this single page
2.0L I4 • Benzin
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Volkswagen Cabrio (1990–2002) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost5.6
Parts & repairability4.1
Maintenance & durabilityn/a
Documentation & support7.0
Independent · Verified · Never for sale
Alle Daten auf dieser Seite zu Volkswagen Cabrio (1990–2002) sind aus über 6,6 Millionen realen Werkstattvorgängen, NHTSA-Registern und technischen OEM-Quellen zusammengeführt und abgeglichen — und werden laufend aktualisiert. Keine erfundenen Schätzungen.
Der Volkswagen Cabrio (1990–2002) verwendet Castrol Edge 5W-30 Motoröl. Seine Batterie hat die Baugröße H6 (BCI), mit 600A Ampere Kaltstartstrom. Angetrieben von einem 2.0L I4-Motor. Seine OEM-Reifengröße ist 215/55 R16. Nutzen Sie die Abschnitte unten für verifizierte Betriebsstoffe, Batterie, OEM-Reifen, den Wartungsplan, die empfohlenen Ersatzteile und die am häufigsten gemeldeten OBD2-Fehlercodes für dieses Fahrzeug.
Häufige Probleme
Häufige Reparaturen
Betriebsstoffe und Schmierstoffe
Batterie
Fehlercodes (OBD2)
Kontrollleuchten
Empfohlene Ersatzteile
Zubehör und Werkzeuge
Reifen
Rückrufe und Bulletins
Beschwerden
Werkstätten in der Nähe
HÄUFIGE PROBLEME
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Verwandte Codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Verwandte Codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Verwandte Codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Verwandte Codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Verwandte Codes: P2100
HÄUFIGE REPARATUREN
Vordere Bremsbeläge
Schwierigkeit: Mittel
1.1h
€77 – €99
Hintere Bremsbeläge
Schwierigkeit: Mittel
1.2h
€84 – €108
Motorölwechsel
Schwierigkeit: Einfach
0.4h
€28 – €36
ABS Module
Schwierigkeit: Mittel
2.0h
€140 – €180
DURCHSCHNITTLICHE RICHTKOSTEN
Die Preise können je nach Region und Werkstatt variieren.
Komplette Wartung
€ 120 – € 200
Komplette Bremsen
€ 180 – € 300
Zündkerzenwechsel
€ 80 – € 140
Elektronische Diagnose
€ 40 – € 70
OFFIZIELLE ARBEITSZEITEN (OLP)
Standard-Arbeitsstunden aus einer Datenbank mit über 6,6 Millionen realen Werkstattvorgängen, mit einer Richtschätzung der Arbeitskosten für Ihr Land.
Bremsen8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| ABS Module | 2.7h | € 121–€ 202 |
| ABS Pump | 3.4h | € 153–€ 255 |
| ABS Tone Ring | 2.0h | € 90–€ 150 |
| ABS Wheel Speed Sensor - Front | 1.1h | € 49–€ 82 |
| ABS Wheel Speed Sensor - Rear | 1.1h | € 49–€ 82 |
| Brake Bleed - All Four | 1.4h | € 62–€ 105 |
| Brake Booster | 3.4h | € 153–€ 255 |
| Brake Booster Check Valve | 0.4h | € 18–€ 30 |
Kühlung8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Coolant Bypass Pipe | 2.0h | € 90–€ 150 |
| Coolant Flush | 1.4h | € 62–€ 105 |
| Coolant Reservoir | 0.7h | € 31–€ 52 |
| Coolant Temperature Sensor | 0.7h | € 31–€ 52 |
| Cooling Fan Assembly | 1.4h | € 62–€ 105 |
| Cooling Fan Motor | 2.0h | € 90–€ 150 |
| Cooling Fan Relay | 0.4h | € 18–€ 30 |
| Engine Oil Cooler | 2.7h | € 121–€ 202 |
Elektrik8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Airbag - Driver | 1.4h | € 62–€ 105 |
| Airbag - Passenger | 2.0h | € 90–€ 150 |
| Airbag - Side | 2.7h | € 121–€ 202 |
| Airbag Module/Computer | 1.4h | € 62–€ 105 |
| Alternator | 2.0h | € 90–€ 150 |
| Alternator Belt | 0.7h | € 31–€ 52 |
| Amplifier | 2.0h | € 90–€ 150 |
| Antenna | 0.7h | € 31–€ 52 |
Motor8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Camshaft Position Sensor | 1.4h | € 62–€ 105 |
| Camshaft R&R | 10.8h | € 486–€ 810 |
| Connecting Rod Bearings | 20.2h | € 909–€ 1515 |
| Crankshaft Position Sensor | 1.4h | € 62–€ 105 |
| Crankshaft R&R | 27.0h | € 1215–€ 2025 |
| Cylinder Head R&R | 8.1h | € 364–€ 607 |
| Cylinder Head Resurface | 10.8h | € 486–€ 810 |
| Engine Mount - Front | 2.0h | € 90–€ 150 |
Abgasanlage8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Air Injection Check Valve | 1.1h | € 49–€ 82 |
| Catalytic Converter - California | 2.0h | € 90–€ 150 |
| Catalytic Converter - Direct Fit | 2.0h | € 90–€ 150 |
| Catalytic Converter - Universal | 2.7h | € 121–€ 202 |
| Downpipe | 2.7h | € 121–€ 202 |
| EGR Cooler | 4.1h | € 184–€ 307 |
| EGR Tube | 2.0h | € 90–€ 150 |
| EGR Valve | 1.4h | € 62–€ 105 |
Kraftstoffsystem8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Charcoal Canister | 1.4h | € 62–€ 105 |
| EVAP Purge Valve | 1.1h | € 49–€ 82 |
| EVAP Vent Valve | 1.1h | € 49–€ 82 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 2.0h | € 90–€ 150 |
| Fuel Filter | 0.7h | € 31–€ 52 |
| Fuel Filter - In-Tank | 2.7h | € 121–€ 202 |
| Fuel Injector - Single | 1.4h | € 62–€ 105 |
Klimatechnik8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| AC Accumulator | 2.0h | € 90–€ 150 |
| AC Clutch Coil | 2.0h | € 90–€ 150 |
| AC Compressor | 3.4h | € 153–€ 255 |
| AC Compressor Clutch | 2.7h | € 121–€ 202 |
| AC Compressor Oil Add | 0.7h | € 31–€ 52 |
| AC Condenser | 3.4h | € 153–€ 255 |
| AC Evaporator | 8.1h | € 364–€ 607 |
| AC Expansion Valve (TXV) | 5.4h | € 243–€ 405 |
Lenkung8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Center Link/Drag Link | 2.0h | € 90–€ 150 |
| Electric Power Steering Module | 2.0h | € 90–€ 150 |
| Electric Power Steering Motor | 3.4h | € 153–€ 255 |
| Idler Arm | 1.4h | € 62–€ 105 |
| Pitman Arm | 1.6h | € 72–€ 120 |
| Power Steering Fluid Flush | 0.7h | € 31–€ 52 |
| Power Steering Gear Box | 4.7h | € 211–€ 352 |
| Power Steering Hose - High Pressure | 1.4h | € 62–€ 105 |
Fahrwerk8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Air Line | 1.4h | € 62–€ 105 |
| Air Spring/Air Bag | 2.0h | € 90–€ 150 |
| Air Suspension Compressor | 2.0h | € 90–€ 150 |
| Air Suspension Height Sensor | 1.4h | € 62–€ 105 |
| Air Suspension Valve Block | 2.7h | € 121–€ 202 |
| Ball Joint - Lower | 2.4h | € 108–€ 180 |
| Ball Joint - Upper | 2.0h | € 90–€ 150 |
| Ball Joints - Upper and Lower | 4.1h | € 184–€ 307 |
Getriebe8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Kickdown Cable | 1.1h | € 49–€ 82 |
| Neutral Safety Switch | 1.4h | € 62–€ 105 |
| Overdrive Solenoid | 2.7h | € 121–€ 202 |
| Shift Cable | 2.0h | € 90–€ 150 |
| Shift Linkage | 1.4h | € 62–€ 105 |
| Transmission Control Module | 1.4h | € 62–€ 105 |
| Transmission Cooler Lines | 1.4h | € 62–€ 105 |
| Transmission Filter | 1.4h | € 62–€ 105 |
WERKSTATT-STUNDENSÄTZE NACH LAND
Durchschnittliche Stundensätze unabhängiger Werkstätten, zur Schätzung der Reparaturkosten in Ihrem Land.
🇩🇪Deutschland€95/h
🇪🇸Spanien€55/h
🇫🇷Frankreich€75/h
🇮🇹Italien€45/h
🇬🇧Vereinigtes Königreich£80/h
🇺🇸USA$120/h
Referenzsatz
€95/h
Quelle: Eurostat 2024
💧 BETRIEBSSTOFFE UND SCHMIERSTOFFE
📋 RÜCKRUFE UND BULLETINS (5)
NHTSA 02V026000
Fuel System, Gasoline › Storage › Tank Assembly › Filler Pipe And Cap
Date: 25/01/2002
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
NHTSA 92V058000
Fuel System, Gasoline › Delivery › Hoses, Lines/Piping, And Fittings
Date: 14/04/1992
THE FUEL HOSE ATTACHED TO THE FUEL DISTRIBUTION RAIL ON THE ENGINE MAY SHRINK BEYOND THE CLAMP FORCE OF THE FUEL HOSE CLAMPS, ALLOWING FUEL TO LEAK.
NHTSA 02V244000
Equipment › Other › Owners/Service/Other Manual
Date: 12/09/2002
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." CHILD SEAT ANCHORAGES INSTALLED IN THE VEHICLE'S REAR SEATS MUST BE IDENTIFIED BY MARKINGS, AND THEIR LOCATION AND USE BE DESCRIBED …
NHTSA 91V162000
Vehicle Speed Control
Date: 11/09/1991
THE CENTER OF THE WATER SEPARATOR PANEL LOCATED IN THE ENGINE COMPARTMENT BETWEEN ENGINE AND FIREWALL COULD BEND IN THE EVENT SOMEONE LEANS ON IT DURING ENGINE MAINTENANCE, REPAIRS OR CHECKING OF FLUID LEVELS. A BENT PANEL COULD INTERFERE WITH THE FREE MOVEMENT OF THE ACCELERATOR…
NHTSA 92V064000
Suspension › Front › Control Arm
Date: 01/05/1992
THE TRACK CONTROL ARMS USED TO SUPPORT THE FRONT WHEELS WERE IMPROPERLY WELDED IN THE AREA OF THE FLEXIBLE BUSHING MOUNTING HOLE. THIS CAUSES A GRADUAL OPENING OF THE MOUNTING HOLE AND LOOSENING OF THE BUSHING.
HÄUFIGE ZU PRÜFENDE OBD2-CODES
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
Alle für dieses Fahrzeug dokumentierten Fehlercodes
Die am besten dokumentierten Diagnosecodes für dieses Modell, nach System und Schweregrad. Tippen Sie auf einen Code für die vollständige Anleitung.
P1425
powertrain
NIEDRIGP1420
powertrain
MITTELP1177
powertrain
MITTELP1176
powertrain
MITTELP1141
powertrain
HOCHP1136
powertrain
MITTELP1225
powertrain
HOCHP1214
powertrain
HOCHP1213
powertrain
HOCHP1388
powertrain
HOCHP1564
powertrain
MITTELP1544
powertrain
HOCHP1543
powertrain
HOCHP1296
powertrain
MITTELP1137
powertrain
MITTELP1102
powertrain
MITTELP1297
powertrain
HOCHP1105
powertrain
MITTELP1410
powertrain
NIEDRIGP1340
powertrain
MITTEL
KONTROLLLEUCHTEN — UNIVERSELLER LEITFADEN
88 Kontrollleuchten nach Dringlichkeit sortiert. Erscheint sie in Ihrem Fahrzeug? Prüfen Sie die Dringlichkeitsstufe.
Alle Kontrollleuchten anzeigen
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
Doors OpenChassis
Hood Open DualChassis
Trunk Open DualChassis
Ignition MalfunctionEngine
WheelEngine
Lights Ignition Steering MalfunctionChassis
Dsg Transmission Too HotTransmission
Electronic Parking Brake EngagedBrakes
Brake System MalfunctionBrakes
Brake WearBrakes
Engine CoolantEngine
Engine Oil Pressure LowEngine
12V Alternator MalfunctionElectrical
Cruise Control MalfunctionADAS
Brake PedalBrakes
Front Assist Collision WarningADAS
Differential Lock MalfunctionEngine
AdblueFuel
Error In Hybrid SystemElectrical
Central Warning LightLighting
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
AdBlue Level Low (VW) (Volkswagen)Emissions
EPC — Engine Control (VW) (Volkswagen)Engine
Glow Plug Fault (VW) (Volkswagen)Engine
DSG Fault (Volkswagen)Transmission
TpmsTyres
Open Rear LidEngine
Ignition Switch Starter ButtonEngine
Electronic ImmobilizerEngine
Fuel Tank Almost EmptyFuel
Front Fog Lights Switched OnLighting
Parking Lights Switched OnBrakes
Driving Lights Burned OutLighting
Adaptive Front Lighting System MalfunctionLighting
Headlight Range Adjustment MalfunctionLighting
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
DPF Regeneration (VW) (Volkswagen)Emissions
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
GEMELDETE BESCHWERDEN & PROBLEME (NHTSA)
194 Beschwerden von Haltern bei der US-amerikanischen National Highway Traffic Safety Administration (NHTSA) für Volkswagen Cabrio über die Modelljahre 1990–2002. Es sind echte, verifizierte Meldungen von Fahrzeughaltern.
22 crash reports 13 fires 18 injuries
Beschwerden nach Modelljahr (die häufigsten zuerst)
Modelljahr 200138
Modelljahr 200230
Modelljahr 199929
Modelljahr 199821
Modelljahr 200016
Modelljahr 199515
Modelljahr 199714
Modelljahr 19929
Am häufigsten gemeldete Bauteile (alle Jahre)
Electrical System39
Engine And Engine Cooling32
Air Bags22
Service Brakes22
Power Train21
Visibility20
Beispiele für Meldungen
THE SPEEDOMETER AND TACHOMETER IN THE DASHBOARD FAIL INTERMITTANTLY. *NM (MY 2000)
FRONTAL COLLISION IMPACT 12:00 POSITION, SPEED 55MPH, DRIVERS SIDE AIR BAG DID NOT DEPLOY. TT (MY 1993)
HELLO, I CONTACTED YOU ABOUT 2 YRS AGO WITHOUT F/U DUE TO RECOVERY FROM INJURIES. NOW I HAVE MY CASE ON THE DOCKET TO SUE VW FOR FAULTY DISC/HUB ASSEMBLY THAT SEPARATED DUE TO CORROSION. I HAVE THE PARTS AND PHOTOS TO SUBMIT. I INJURE… (MY 1999)
DRIVER'S AIRBAG DID NOT DEPLOY WITH AN IMPACT OF 30-35 MILES PER HOUR AND $6,000 DAMAGE TO THE FRONT END. IT WAS A REAR-END COLLISION. THE PASSENGER AIRBAG DEPLOYED. WE ARE CONCERNED THAT THE DRIVER'S SIDE DID NOT.*AK (MY 2002)
Quelle: NHTSA-Beschwerdedatenbank (U.S. data.gov). Die Daten decken die Produktionsjahre 1990–2002 ab.
Häufige Fragen
What tyres does the Volkswagen Cabrio (1990–2002) use?
The original OEM tyre size for the Volkswagen Cabrio (1990–2002) is 215/55 R16. Compatible alternative sizes: ["205/45R16", "185/60R14", "245/45R19", "195/50R15"]. See the Tyres section on this page to compare offers from the main suppliers.
What is the right battery for the Volkswagen Cabrio (1990–2002)?
The battery specified for the Volkswagen Cabrio (1990–2002) is group H6 (BCI), with a cold cranking rating of 600A. See the Battery section on this page for the main cross-references between brands.
What engine oil should I use on the Volkswagen Cabrio (1990–2002)?
The engine oil specification for the Volkswagen Cabrio (1990–2002) is Castrol Edge 5W-30. Always use the viscosity grade approved by the manufacturer: a different oil can reduce engine protection and void the warranty. Check the change interval in the Maintenance section.
Which OBD2 fault codes are commonly documented for the Volkswagen Cabrio (1990–2002)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Volkswagen Cabrio (1990–2002) be serviced?
Routine maintenance for the Volkswagen Cabrio (1990–2002) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
This spec sheet is updated with data verified from OEM sources and shop databases. If you spot an inaccuracy or have additional data on the Volkswagen Cabrio (1990–2002), let us know — every correction improves quality for all users.