TroubleAtlas Score
CHEVROLET CORSICA (1990–1996) Manual — Codes, Tyres & Parts
Built 1990–1996 · all production years covered on this single page
3.1L V6 • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Chevrolet Corsica (1990–1996) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost9.1
Parts & repairability3.6
Maintenance & durabilityn/a
Documentation & support3.7
Independent · Verified · Never for sale
Every figure on this Chevrolet Corsica (1990–1996) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Chevrolet Corsica (1990–1996) uses ACDelco dexos1 5W-30 engine oil. Its battery is group 75 (BCI), rated at 525A cold-cranking amps. It is powered by a 3.1L V6 engine. Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Medium
1.2h
€84 – €108
Rear brake pads
Difficulty: Medium
1.2h
€84 – €108
Engine oil change
Difficulty: Easy
0.5h
€35 – €45
ABS Module
Difficulty: Medium
2.0h
€140 – €180
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.0h | € 90–€ 150 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Rear | 1.5h | € 67–€ 112 |
| Brake Bleed - All Four | 1.5h | € 67–€ 112 |
| Brake Booster | 3.0h | € 135–€ 225 |
| Brake Booster Check Valve | 1.0h | € 45–€ 75 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.5h | € 67–€ 112 |
| Coolant Flush | 0.8h | € 36–€ 60 |
| Coolant Reservoir | 1.5h | € 67–€ 112 |
| Coolant Temperature Sensor | 1.0h | € 45–€ 75 |
| Cooling Fan Assembly | 1.5h | € 67–€ 112 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 1.0h | € 45–€ 75 |
| Engine Oil Cooler | 1.5h | € 67–€ 112 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.5h | € 67–€ 112 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 1.5h | € 67–€ 112 |
| Airbag Module/Computer | 1.5h | € 67–€ 112 |
| Alternator | 2.0h | € 90–€ 150 |
| Alternator Belt | 1.5h | € 67–€ 112 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Camshaft Position Sensor | 1.5h | € 67–€ 112 |
| Camshaft R&R | 4.5h | € 202–€ 337 |
| Connecting Rod Bearings | 1.5h | € 67–€ 112 |
| Crankshaft Position Sensor | 1.5h | € 67–€ 112 |
| Crankshaft R&R | 1.5h | € 67–€ 112 |
| Cylinder Head R&R | 4.5h | € 202–€ 337 |
| Cylinder Head Resurface | 4.5h | € 202–€ 337 |
| Engine Mount - Front | 3.0h | € 135–€ 225 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 1.5h | € 67–€ 112 |
| Catalytic Converter - California | 2.0h | € 90–€ 150 |
| Catalytic Converter - Direct Fit | 2.0h | € 90–€ 150 |
| Catalytic Converter - Universal | 2.0h | € 90–€ 150 |
| Downpipe | 2.0h | € 90–€ 150 |
| EGR Cooler | 1.5h | € 67–€ 112 |
| EGR Tube | 1.5h | € 67–€ 112 |
| EGR Valve | 1.5h | € 67–€ 112 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.5h | € 67–€ 112 |
| EVAP Purge Valve | 1.5h | € 67–€ 112 |
| EVAP Vent Valve | 1.5h | € 67–€ 112 |
| Fuel Cap | 0.3h | € 13–€ 22 |
| Fuel Filler Neck | 3.0h | € 135–€ 225 |
| Fuel Filter | 1.0h | € 45–€ 75 |
| Fuel Filter - In-Tank | 1.0h | € 45–€ 75 |
| Fuel Injector - Single | 3.0h | € 135–€ 225 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 2.0h | € 90–€ 150 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.0h | € 90–€ 150 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 2.0h | € 90–€ 150 |
| AC Condenser | 2.0h | € 90–€ 150 |
| AC Evaporator | 2.0h | € 90–€ 150 |
| AC Expansion Valve (TXV) | 2.0h | € 90–€ 150 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 1.5h | € 67–€ 112 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.5h | € 67–€ 112 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 2.0h | € 90–€ 150 |
| Power Steering Hose - High Pressure | 1.5h | € 67–€ 112 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.5h | € 67–€ 112 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.5h | € 67–€ 112 |
| Air Suspension Valve Block | 1.5h | € 67–€ 112 |
| Ball Joint - Lower | 2.0h | € 90–€ 150 |
| Ball Joint - Upper | 2.0h | € 90–€ 150 |
| Ball Joints - Upper and Lower | 2.0h | € 90–€ 150 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Clutch Cable | 1.5h | € 67–€ 112 |
| Clutch Disc | 1.5h | € 67–€ 112 |
| Clutch Kit | 4.5h | € 202–€ 337 |
| Clutch Master Cylinder | 2.0h | € 90–€ 150 |
| Clutch Slave Cylinder | 2.0h | € 90–€ 150 |
| Flywheel Resurface | 4.5h | € 202–€ 337 |
| Kickdown Cable | 1.5h | € 67–€ 112 |
| Neutral Safety Switch | 1.5h | € 67–€ 112 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (6)
NHTSA 91V206000
Seat Belts
Date: 26/11/1991
THE FRONT SHOULDER BELT RETRACTORS MAY HAVE REDUCED SENSITIVITY OF THE LOCK-UP FEATURE AND WOULD NOT FUNCTION IN A SUDDEN DECELERATION OR CRASH.
NHTSA 92V185000
Exterior Lighting › Brake Lights › Switch
Date: 24/12/1992
THE SERVICE BRAKE STOP LAMP SWITCH BECOMES INOPERATIVE.
NHTSA 93V157000
Suspension › Front
Date: 24/09/1993
THE SUSPENSION SUPPORT ASSEMBLIES DO NOT MEET GENERAL MOTORS CORPORATION'S SPECIFICATION FOR WELD INTEGRITY AND THE AFFECTED WELD CAN FAIL CAUSING THE FRONT OF THE CONTROL ARM TO SEPARATE FROM THE SUSPENSION SUPPORT ASSEMBLY.
NHTSA 07E021000
Fuel System, Other › Storage › Tank Assembly › Pressure Relief Devices
Date: 12/03/2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
NHTSA 91V083000
Steering › Steering Wheel/Handle Bar
Date: 10/06/1991
NUT ATTACHING STEERING WHEEL MAY NOT HAVE BEEN PROPERLY TIGHTENED DURING INSTALLATION.
NHTSA 90V065000
Seat Belts › Rear/Other
Date: 05/04/1990
OWNER'S MANUALS WERE PRINTED WITH REAR CENTER SEAT BELT INFORMATION OMITTED.
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1884
powertrain
LOWP1875
powertrain
MODERATEP1870
powertrain
HIGHP1860
powertrain
MODERATEP1812
powertrain
CRITICALP1810
powertrain
HIGHP1632
powertrain
HIGHP1629
powertrain
HIGHP1626
powertrain
HIGHP1599
powertrain
MODERATEP1554
powertrain
MODERATEP1517
powertrain
HIGHP1515
powertrain
HIGHP1514
powertrain
HIGHP1483
powertrain
HIGHP1404
powertrain
MODERATEP1380
powertrain
MODERATEP1370
powertrain
MODERATEP1258
powertrain
CRITICALP1190
powertrain
MODERATE
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
733 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Chevrolet Corsica across model years 1990–1996. These are real, verified reports submitted by vehicle owners.
94 crash reports 35 fires 88 injuries 5 deaths
Complaints by model year (most reported first)
Model year 1992129
Model year 1994124
Model year 1991111
Model year 1996110
Model year 1995103
Model year 1993101
Model year 199055
Most reported components (all years)
Service Brakes155
Hydraulic150
Electrical System108
Engine And Engine Cooling84
Exterior Lighting81
Air Bags68
Sample reports
WHILE MAKING A LEFT OR RIGHT HAND TURN AROUND A CURB THE BAR ACROSS THE STEERING WHEEL, BULGE IN BACK OF THE STEERING WHEEL BROKE, MAKING THE DIMMER SWITCH DIFFICULT TO ENGANGE. PLEASE PROVIDE ANY FURTHER DETAILS. *AK (MY 1994)
THE ROTORS AND DRUMS MALFUNCTION EVERY 10,000 MILES, NEED TO BE REPLACED . *AK (MY 1993)
CRUISE CONTROL FAILS TO DISENGAGE AND INSTEAD INCREASES WHEN BUTTON IS DEPRESSED. *SKD (MY 1995)
TL* THE CONTACT OWNS A 1996 CHEVROLET CORSICA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 30 MPH, THERE WAS A FUEL ODOR COMING FROM THE INSIDE AND OUTSIDE OF THE VEHICLE. THE FAILURE OCCURRED ON A DAILY BASIS. THE VEHICLE WAS… (MY 1996)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 1990–1996.
Frequently Asked Questions
Does the Chevrolet Corsica have any safety recalls?
Yes — 6 official NHTSA recall campaign(s) affect this model, mainly: SEAT BELTS:REAR/OTHER, SEAT BELTS, STEERING: STEERING WHEEL/HANDLE BAR. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Chevrolet Corsica?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Chevrolet Corsica?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Chevrolet Corsica?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are electrical problems common on the Chevrolet Corsica?
Yes — 122 of 597 real owner reports filed with NHTSA mention the electrical. One owner reported: “WIRING COVER MELTED/ DEALER SAID I TOOK IT OFF TO AVOID REPLACING IT. THEY WANTED 2,400.00 DOLLARS TO REPLACE IT. IT MELTED I DID NOT REMOVE IT.…” See the owner-reported complaints section below for more.
Are steering problems common on the Chevrolet Corsica?
Yes — 141 of 597 real owner reports filed with NHTSA mention the steering. One owner reported: “SMOKE FROM STEERING COLUMN FIRST NOTED ON 5/95 - REPAIRED AND NOW IT IS HAPPENING AGAIN (SECOND TIME). ON 1/6/99 NOTICE SMOKE AFTER CAR WAS STARTED. CONTACTED DEALERSHIP THAT REPAIRED VEHICLE THE FIRS…” See the owner-reported complaints section below for more.
Are brakes problems common on the Chevrolet Corsica?
Yes — 142 of 597 real owner reports filed with NHTSA mention the brakes. One owner reported: “AFTER THE WINDSHIELD WIPER SWITCH HAS BEEN TURNED TO THE OFF POSITION THE WIPER'S CONTINUE TO SWIPE FOR ABOUT 14-22 TIMES BEFORE STOPPING, THE SWITCH WAS REPLACED BUT THE PROBLEM STILL OCCURED. NLM…” See the owner-reported complaints section below for more.
What tyres does the Chevrolet Corsica (1990–1996) use?
The original OEM tyre size for the Chevrolet Corsica (1990–1996) is 215/55 R16. Compatible alternative sizes: ["245/45R19", "195/70R14"]. See the Tyres section on this page to compare offers from the main suppliers.
What is the right battery for the Chevrolet Corsica (1990–1996)?
The battery specified for the Chevrolet Corsica (1990–1996) is group 75 (BCI), with a cold cranking rating of 600A. See the Battery section on this page for the main cross-references between brands.
What engine oil should I use on the Chevrolet Corsica (1990–1996)?
The engine oil specification for the Chevrolet Corsica (1990–1996) is ACDelco dexos1 5W-30. Always use the viscosity grade approved by the manufacturer: a different oil can reduce engine protection and void the warranty. Check the change interval in the Maintenance section.
Which OBD2 fault codes are commonly documented for the Chevrolet Corsica (1990–1996)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Chevrolet Corsica (1990–1996) be serviced?
Routine maintenance for the Chevrolet Corsica (1990–1996) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Have a specific fault code on your Chevrolet Corsica (1990–1996)? Search the code in the OBD2 section of this page or use the full TroubleAtlas DTC database. Need tyres? Compare prices and compatible sizes in the TroubleAtlas comparator.