CHEVROLET EQUINOX-EV (2024)
TroubleAtlas Score
CHEVROLET EQUINOX-EV (2024) — Technical Guide, Fault Codes & Maintenance
Built 2024 · all production years covered on this single page
Electric Single Motor • Electric
🚗 Chevrolet EQUINOX-EV 2024
TroubleAtlas Score
An independent value score for the Chevrolet Equinox-Ev (2024) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost7.0
Parts & repairability3.1
Maintenance & durabilityn/a
Documentation & supportn/a
Independent · Verified · Never for sale
Every figure on this Chevrolet Equinox-Ev (2024) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
Its battery is group H6 (BCI), rated at 680A cold-cranking amps. It is a fully electric vehicle (Electric Single Motor). Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Easy
0.8h
€56 – €72
Rear brake pads
Difficulty: Easy
0.9h
€63 – €81
ABS Module
Difficulty: Medium
2.0h
€140 – €180
ABS Pump
Difficulty: Hard
2.5h
€175 – €225
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.5h | € 112–€ 187 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 0.8h | € 36–€ 60 |
| ABS Wheel Speed Sensor - Rear | 0.8h | € 36–€ 60 |
| Brake Bleed - All Four | 1.0h | € 45–€ 75 |
| Brake Booster | 2.5h | € 112–€ 187 |
| Brake Booster Check Valve | 0.3h | € 13–€ 22 |
Cooling6 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Cooling Fan Assembly | 1.0h | € 45–€ 75 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 0.3h | € 13–€ 22 |
| Heater Control Valve | 3.0h | € 135–€ 225 |
| Heater Core | 3.0h | € 135–€ 225 |
| Heater Hoses | 3.0h | € 135–€ 225 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.0h | € 45–€ 75 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 2.0h | € 90–€ 150 |
| Airbag Module/Computer | 1.0h | € 45–€ 75 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
| Backup Camera | 1.0h | € 45–€ 75 |
| Battery | 0.3h | € 13–€ 22 |
Engine1 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Transmission Mount | 1.0h | € 45–€ 75 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.5h | € 67–€ 112 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.5h | € 112–€ 187 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 0.5h | € 22–€ 37 |
| AC Condenser | 2.5h | € 112–€ 187 |
| AC Evaporator | 6.0h | € 270–€ 450 |
| AC Expansion Valve (TXV) | 4.0h | € 180–€ 300 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 2.5h | € 112–€ 187 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.2h | € 54–€ 90 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 3.5h | € 157–€ 262 |
| Power Steering Hose - High Pressure | 1.0h | € 45–€ 75 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.0h | € 45–€ 75 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.0h | € 45–€ 75 |
| Air Suspension Valve Block | 2.0h | € 90–€ 150 |
| Ball Joint - Lower | 1.8h | € 81–€ 135 |
| Ball Joint - Upper | 1.5h | € 67–€ 112 |
| Ball Joints - Upper and Lower | 3.0h | € 135–€ 225 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Neutral Safety Switch | 6.0h | € 270–€ 450 |
| Overdrive Solenoid | 6.0h | € 270–€ 450 |
| Shift Cable | 1.5h | € 67–€ 112 |
| Shift Linkage | 1.0h | € 45–€ 75 |
| Shift Solenoid - Single | 3.6h | € 162–€ 270 |
| Shift Solenoids - All | 7.8h | € 351–€ 585 |
| Transmission Control Module | 6.0h | € 270–€ 450 |
| Transmission Cooler Lines | 1.0h | € 45–€ 75 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (0)
No official recall verified for this vehicle in the NHTSA database.
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
Coolant Thermostat Below Regulating Temperature
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1682
powertrain
HIGHP1638
powertrain
MODERATEP1635
powertrain
HIGHP1625
powertrain
HIGHP1621
powertrain
HIGHP1639
powertrain
HIGHP1637
powertrain
MODERATEP1634
powertrain
HIGHP1633
powertrain
HIGHP1600
powertrain
MODERATEC0445
chassis
HIGHC0441
chassis
CRITICALC0440
chassis
CRITICALC0425
chassis
MODERATEB0009
body
CRITICAL⏱ 1.13h avgU0253
network
CRITICALC0431
chassis
MODERATEU0197
network
LOWU0176
network
HIGHC0435
chassis
LOW
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
106 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Chevrolet Equinox-Ev across model years 2024. These are real, verified reports submitted by vehicle owners.
1 crash report
Complaints by model year (most reported first)
Model year 2024106
Most reported components (all years)
Visibility/Wiper58
Forward Collision Avoidance24
Unknown Or Other14
Service Brakes10
Electrical System7
Back Over Prevention6
Sample reports
The angle and possibly the material of the windshield catches a glare/reflection of the dash that heavily affects visibility for the driver. When there is a bright light shining on the dash it is almost impossible to see past the glare.… (MY 2024)
I was driving South on interstate 55 near Arnold Missouri in adaptive cruise control mode at approximately 65 mph when the car braked suddenly and came to a complete stop on the interstate. Car would not go forward after stopping. Turn… (MY 2024)
I bought a new Chevy Equinox EV on 12/13/24. The day I bought the car, I found that while driving home on interstates and other roads listed by GM as mapped for Supercruise, the system will work for a few minutes, then cut out. There is… (MY 2024)
This was new vehicle in the dealer parking lot with 215 miles on it. I took it for a test drive with the sales person in the city next to me on the passenger seat.I was on the interstate with adaptive cruise control on. When the electric… (MY 2024)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 2024.
Frequently Asked Questions
What does fault code P0071 mean on the Chevrolet Equinox-ev?
Ambient Air Temperature Sensor Range/Performance This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0070 mean on the Chevrolet Equinox-ev?
Ambient Air Temperature Sensor Circuit This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Chevrolet Equinox-ev?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are steering problems common on the Chevrolet Equinox-ev?
Yes — 5 of 105 real owner reports filed with NHTSA mention the steering. One owner reported: “The vehicle seemingly at random, will engage automatic emergency braking. These events are hard braking events, locking up wheels and engaging ABS for brief moments at 75mph. There is no sensitivity…” See the owner-reported complaints section below for more.
Are brakes problems common on the Chevrolet Equinox-ev?
Yes — 19 of 105 real owner reports filed with NHTSA mention the brakes. One owner reported: “I was driving South on interstate 55 near Arnold Missouri in adaptive cruise control mode at approximately 65 mph when the car braked suddenly and came to a complete stop on the interstate. Car would…” See the owner-reported complaints section below for more.
Are electrical problems common on the Chevrolet Equinox-ev?
Yes — 62 of 105 real owner reports filed with NHTSA mention the electrical. One owner reported: “The contact owns a 2024 Chevrolet Equinox. The contact stated that while driving and attempting to reverse, the brakes unexpectedly engaged. There was no warning light illuminated. The contact receive…” See the owner-reported complaints section below for more.
What tyres does the Chevrolet Equinox-Ev (2024) use?
The original OEM tyre size for the Chevrolet Equinox-Ev (2024) is 215/55 R16. Compatible alternative sizes: ["245/50R20", "245/45R19", "245/55R19", "255/45R21", "275/40R21"]. See the Tyres section on this page to compare offers from the main suppliers.
What is the right battery for the Chevrolet Equinox-Ev (2024)?
The battery specified for the Chevrolet Equinox-Ev (2024) is group H6 (BCI), with a cold cranking rating of 680A. See the Battery section on this page for the main cross-references between brands.
Which OBD2 fault codes are commonly documented for the Chevrolet Equinox-Ev (2024)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Chevrolet Equinox-Ev (2024) be serviced?
Routine maintenance for the Chevrolet Equinox-Ev (2024) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Bookmark this page to consult it at the workshop or when buying parts. TroubleAtlas updates its technical data continuously — check back for new information on the Chevrolet Equinox-Ev (2024).