TroubleAtlas Score
DODGE HORNET (2023–2025) Manual — Codes, Tyres & Parts
Built 2023–2025 · all production years covered on this single page
2.0L I4 Turbo • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Dodge Hornet (2023–2025) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost3.0
Parts & repairability8.1
Maintenance & durabilityn/a
Documentation & support3.9
Independent · Verified · Never for sale
Every figure on this Dodge Hornet (2023–2025) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Dodge Hornet (2023–2025) uses Mopar 0W-20 Full Synthetic engine oil. It is powered by a 2.0L I4 Turbo engine. Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Related codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Related codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Related codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Related codes: P0562
P0011LOW
Check with an OBD2 scanner.
Related codes: P0011
COMMON REPAIRS
Front brake pads
Difficulty: Medium
1.2h
€84 – €108
Rear brake pads
Difficulty: Medium
1.9h
€133 – €171
Engine oil change
Difficulty: Hard
3.1h
€217 – €279
ABS Module
Difficulty: Medium
1.5h
€105 – €135
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 1.5h | € 67–€ 112 |
| ABS Pump | 0.6h | € 27–€ 45 |
| ABS Tone Ring | 0.8h | € 36–€ 60 |
| ABS Wheel Speed Sensor - Front | 1.1h | € 49–€ 82 |
| ABS Wheel Speed Sensor - Rear | 2.3h | € 103–€ 172 |
| Brake Bleed - All Four | 2.3h | € 103–€ 172 |
| Brake Booster | 1.2h | € 54–€ 90 |
| Brake Booster Check Valve | 0.6h | € 27–€ 45 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.5h | € 67–€ 112 |
| Coolant Flush | 0.9h | € 40–€ 67 |
| Coolant Reservoir | 0.6h | € 27–€ 45 |
| Coolant Temperature Sensor | 1.7h | € 76–€ 127 |
| Cooling Fan Assembly | 2.0h | € 90–€ 150 |
| Cooling Fan Clutch | 1.1h | € 49–€ 82 |
| Cooling Fan Motor | 0.6h | € 27–€ 45 |
| Cooling Fan Relay | 1.0h | € 45–€ 75 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 3.2h | € 144–€ 240 |
| Airbag - Passenger | 2.2h | € 99–€ 165 |
| Airbag - Side | 3.1h | € 139–€ 232 |
| Airbag Module/Computer | 0.9h | € 40–€ 67 |
| Alternator | 3.1h | € 139–€ 232 |
| Alternator Belt | 0.7h | € 31–€ 52 |
| Amplifier | 3.1h | € 139–€ 232 |
| Antenna | 3.1h | € 139–€ 232 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Boost Pressure Sensor | 9.4h | € 423–€ 705 |
| Camshaft Position Sensor | 9.6h | € 432–€ 720 |
| Camshaft R&R | 5.1h | € 229–€ 382 |
| Connecting Rod Bearings | 10.2h | € 458–€ 765 |
| Crankshaft Position Sensor | 10.7h | € 481–€ 802 |
| Crankshaft R&R | 10.1h | € 454–€ 757 |
| Cylinder Head R&R | 9.3h | € 418–€ 697 |
| Cylinder Head Resurface | 3.6h | € 162–€ 270 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 2.3h | € 103–€ 172 |
| Catalytic Converter - California | 1.6h | € 72–€ 120 |
| Catalytic Converter - Direct Fit | 0.7h | € 31–€ 52 |
| Catalytic Converter - Universal | 2.0h | € 90–€ 150 |
| Downpipe | 0.7h | € 31–€ 52 |
| EGR Cooler | 1.1h | € 49–€ 82 |
| EGR Tube | 1.8h | € 81–€ 135 |
| EGR Valve | 2.5h | € 112–€ 187 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 3.2h | € 144–€ 240 |
| EVAP Purge Valve | 1.7h | € 76–€ 127 |
| EVAP Vent Valve | 3.1h | € 139–€ 232 |
| Fuel Cap | 1.7h | € 76–€ 127 |
| Fuel Filler Neck | 0.5h | € 22–€ 37 |
| Fuel Filter | 3.3h | € 148–€ 247 |
| Fuel Filter - In-Tank | 1.7h | € 76–€ 127 |
| Fuel Injector - Single | 1.8h | € 81–€ 135 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.9h | € 85–€ 142 |
| AC Clutch Coil | 1.2h | € 54–€ 90 |
| AC Compressor | 2.6h | € 117–€ 195 |
| AC Compressor Clutch | 2.2h | € 99–€ 165 |
| AC Compressor Oil Add | 2.0h | € 90–€ 150 |
| AC Condenser | 5.6h | € 251–€ 420 |
| AC Evaporator | 3.1h | € 139–€ 232 |
| AC Expansion Valve (TXV) | 1.9h | € 85–€ 142 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 2.5h | € 112–€ 187 |
| Electric Power Steering Module | 3.7h | € 166–€ 277 |
| Electric Power Steering Motor | 1.7h | € 76–€ 127 |
| Idler Arm | 3.8h | € 171–€ 285 |
| Pitman Arm | 4.0h | € 180–€ 300 |
| Power Steering Fluid Flush | 4.6h | € 206–€ 345 |
| Power Steering Gear Box | 3.6h | € 162–€ 270 |
| Power Steering Hose - High Pressure | 1.8h | € 81–€ 135 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 2.3h | € 103–€ 172 |
| Air Spring/Air Bag | 1.4h | € 62–€ 105 |
| Air Suspension Compressor | 1.4h | € 62–€ 105 |
| Air Suspension Height Sensor | 2.7h | € 121–€ 202 |
| Air Suspension Valve Block | 4.6h | € 206–€ 345 |
| Ball Joint - Lower | 1.2h | € 54–€ 90 |
| Ball Joint - Upper | 2.8h | € 125–€ 210 |
| Ball Joints - Upper and Lower | 3.5h | € 157–€ 262 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Clutch Disc | 8.5h | € 382–€ 637 |
| Kickdown Cable | 6.0h | € 270–€ 450 |
| Neutral Safety Switch | 6.1h | € 274–€ 457 |
| Overdrive Solenoid | 12.7h | € 571–€ 952 |
| Pilot Bearing | 9.1h | € 409–€ 682 |
| Shift Cable | 11.0h | € 495–€ 825 |
| Shift Linkage | 13.5h | € 607–€ 1012 |
| Shift Solenoid - Single | 7.9h | € 355–€ 592 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (6)
NHTSA 24V209000
Equipment › Other › Labels
Date: 19/03/2024
Chrysler (FCA US, LLC) is recalling certain 2024 Dodge Hornet and Alfa Romeo Tonale vehicles. The manufacturer label is missing the tire rim and tire size information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 1…
NHTSA 23V696000
Back Over Prevention › Warnings › External/Pedestrian Alert
Date: 17/10/2023
Chrysler (FCA US, LLC) is recalling certain 2023-2024 Dodge Hornet and Alfa Romeo Tonale Plug-In Hybrid vehicles. The pedestrian alert siren may be missing or disconnected and fail to alert pedestrians when the vehicle is in reverse. As such, these vehicles fail to comply with …
NHTSA 25V246000
Back Over Prevention › Sensing System › Camera
Date: 13/05/2025
Chrysler (FCA US, LLC) is recalling certain 2023-2025 Alfa Romeo Tonale and Dodge Hornet vehicles. The display module may not show the rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111…
NHTSA 24V752000
Service Brakes, Hydraulic › Pedals And Linkages
Date: 09/10/2024
Chrysler (FCA US, LLC) is recalling certain 2024-2025 Dodge Hornet and Alfa Romeo Tonale vehicles. The brake pedal may collapse and cause a loss of brake function.
NHTSA 23V623000
Electrical System › Propulsion System › Cables › Fastener/Connector
Date: 07/09/2023
Chrysler (FCA US, LLC) is recalling certain 2023-2024 Alfa Romeo Tonale and 2023-2024 Dodge Hornet plug-in hybrid electric vehicles. The 12-volt battery positive cable and/or high voltage connector cable may not be tightened properly, which can overheat the electrical connection…
NHTSA 24V175000
Equipment › Other › Labels
Date: 05/03/2024
Chrysler (FCA US, LLC) is recalling certain 2023-2024 Dodge Hornet and Alfa Romeo Tonale vehicles. The maximum vehicle capacity weight value on the tire placard label is incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Stan…
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P0455
powertrain
LOW⏱ 0.62h avgP0442
powertrain
LOW⏱ 0.62h avgP0440
powertrain
LOW⏱ 0.78h avgP0420
powertrain
MEDIUM⏱ 1.24h avgP0300
powertrain
HIGH⏱ 1.22h avgP0172
powertrain
MEDIUM⏱ 1.13h avgP0171
powertrain
MEDIUM⏱ 0.95h avgP0730
transmission
MEDIUM⏱ 1.25h avgP0700
transmission
HIGH⏱ 1.25h avgP0401
powertrain
MEDIUM⏱ 1.25h avgP0011
powertrain
MEDIUM⏱ 5.4h avgU0100
network
HIGHP0562
electrical
MEDIUM⏱ 0.58h avgP0128
powertrain
MEDIUM⏱ 0.88h avg
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
83 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Dodge Hornet across model years 2023–2025. These are real, verified reports submitted by vehicle owners.
4 crash reports 4 fires
Complaints by model year (most reported first)
Model year 202456
Model year 202325
Model year 20252
Most reported components (all years)
Electrical System29
Forward Collision Avoidance15
Service Brakes13
Back Over Prevention10
Unknown Or Other9
Engine9
Sample reports
I was in the middle of an Intersection. And the completely shut off!! The dash light came on but would not start back up. (MY 2024)
we had to have our dash harness replaced due to an electrical short, the USB would not power on, they replaced the usb and it immediately fried due to the short. This is not a one off incident apparently. There are a few posts on the own… (MY 2024)
Complete electrical issues, starting with no start up, after jumping power steering went out. Was in shop for 2 months and had an electrical fire internally, while not running. (MY 2024)
Heavy vibration/ shaking felt in steering, floorboard, seats and all. I purchased this car February 14, 2025 and reported this within 24 hours of be driving the car home. I was told it most likely was due to the car sitting on the lot… (MY 2024)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 2023–2025.
Frequently Asked Questions
Does the Dodge Hornet have any safety recalls?
Yes — 6 official NHTSA recall campaign(s) affect this model, mainly: ELECTRICAL SYSTEM:PROPULSION SYSTEM: CABLES:FASTENER/CONNECTOR, BACK OVER PREVENTION:WARNINGS:EXTERNAL/PEDESTRIAN ALERT, EQUIPMENT:OTHER:LABELS. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Dodge Hornet?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Dodge Hornet?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Dodge Hornet?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are engine problems common on the Dodge Hornet?
Yes — 12 of 83 real owner reports filed with NHTSA mention the engine. One owner reported: “I have been taking my car into the shop to get the lights checked. They’ve come to conclusion that the front crash sensors disable themselves and they have no fix for it. Chrysler engineers came back…” See the owner-reported complaints section below for more.
Are steering problems common on the Dodge Hornet?
Yes — 15 of 83 real owner reports filed with NHTSA mention the steering. One owner reported: “While driving in left lane of one way road at 46 mph with adaptive cruise and lane sense active, the cruise control switched off and lane assist veered left off the road, locking the steering wheel to…” See the owner-reported complaints section below for more.
Are electrical problems common on the Dodge Hornet?
Yes — 31 of 83 real owner reports filed with NHTSA mention the electrical. One owner reported: “Discontinued vehicle model still under active bumper to bumper warranty (thru 10/26); has faulty rear defroster/heated side mirrors that the 'remedy' handed down to me was to 'drive more' in an effort…” See the owner-reported complaints section below for more.
What tyres does the Dodge Hornet (2023–2025) use?
The original OEM tyre size for the Dodge Hornet (2023–2025) is 215/55 R16. Compatible alternative sizes: ["235/40R20", "235/50R18", "215/60R17", "245/45R19", "235/45R19"]. See the Tyres section on this page to compare offers from the main suppliers.
What engine oil should I use on the Dodge Hornet (2023–2025)?
The engine oil specification for the Dodge Hornet (2023–2025) is Mopar 0W-20 Full Synthetic. Always use the viscosity grade approved by the manufacturer: a different oil can reduce engine protection and void the warranty. Check the change interval in the Maintenance section.
Which OBD2 fault codes are commonly documented for the Dodge Hornet (2023–2025)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Dodge Hornet (2023–2025) be serviced?
Routine maintenance for the Dodge Hornet (2023–2025) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Considering buying a Dodge Hornet (2023–2025)? Use this guide to check expected maintenance costs, the most reported fault codes and parts availability on the market. Real data, zero commercial estimates.