TroubleAtlas Score
FORD MAVERICK (2022–2024) Manual — Codes, Tyres & Parts
Built 2022–2024 · all production years covered on this single page
2.0L I4 EcoBoost • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Ford Maverick (2022–2024) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost4.5
Parts & repairability5.3
Maintenance & durability7.9
Documentation & support5.0
Independent · Verified · Never for sale
Every figure on this Ford Maverick (2022–2024) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Ford Maverick (2022–2024) uses Motorcraft 0W-20 Full Synthetic engine oil. Its battery is group 96R (BCI), rated at 760A cold-cranking amps. It is powered by a 2.0L I4 EcoBoost engine. Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Scheduled maintenance
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Easy
0.8h
€56 – €72
Rear brake pads
Difficulty: Easy
0.9h
€63 – €81
Engine oil change
Difficulty: Easy
0.3h
€21 – €27
ABS Module
Difficulty: Medium
2.0h
€140 – €180
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.5h | € 112–€ 187 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 0.8h | € 36–€ 60 |
| ABS Wheel Speed Sensor - Rear | 0.8h | € 36–€ 60 |
| Brake Bleed - All Four | 1.0h | € 45–€ 75 |
| Brake Booster | 2.5h | € 112–€ 187 |
| Brake Booster Check Valve | 0.3h | € 13–€ 22 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.5h | € 67–€ 112 |
| Coolant Flush | 1.0h | € 45–€ 75 |
| Coolant Reservoir | 0.5h | € 22–€ 37 |
| Coolant Temperature Sensor | 0.5h | € 22–€ 37 |
| Cooling Fan Assembly | 1.0h | € 45–€ 75 |
| Cooling Fan Clutch | 1.0h | € 45–€ 75 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 0.3h | € 13–€ 22 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.0h | € 45–€ 75 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 2.0h | € 90–€ 150 |
| Airbag Module/Computer | 1.0h | € 45–€ 75 |
| Alternator | 1.5h | € 67–€ 112 |
| Alternator Belt | 0.5h | € 22–€ 37 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Boost Pressure Sensor | 0.5h | € 22–€ 37 |
| Camshaft Position Sensor | 1.0h | € 45–€ 75 |
| Camshaft R&R | 8.0h | € 360–€ 600 |
| Connecting Rod Bearings | 15.0h | € 675–€ 1125 |
| Crankshaft Position Sensor | 1.0h | € 45–€ 75 |
| Crankshaft R&R | 20.0h | € 900–€ 1500 |
| Cylinder Head R&R | 6.0h | € 270–€ 450 |
| Cylinder Head Resurface | 8.0h | € 360–€ 600 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 0.8h | € 36–€ 60 |
| Catalytic Converter - California | 1.5h | € 67–€ 112 |
| Catalytic Converter - Direct Fit | 1.5h | € 67–€ 112 |
| Catalytic Converter - Universal | 2.0h | € 90–€ 150 |
| Downpipe | 2.0h | € 90–€ 150 |
| EGR Cooler | 3.0h | € 135–€ 225 |
| EGR Tube | 1.5h | € 67–€ 112 |
| EGR Valve | 1.0h | € 45–€ 75 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.0h | € 45–€ 75 |
| EVAP Purge Valve | 0.8h | € 36–€ 60 |
| EVAP Vent Valve | 0.8h | € 36–€ 60 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 1.5h | € 67–€ 112 |
| Fuel Filter | 0.5h | € 22–€ 37 |
| Fuel Filter - In-Tank | 2.0h | € 90–€ 150 |
| Fuel Injector - Single | 1.0h | € 45–€ 75 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.5h | € 67–€ 112 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.5h | € 112–€ 187 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 0.5h | € 22–€ 37 |
| AC Condenser | 2.5h | € 112–€ 187 |
| AC Evaporator | 6.0h | € 270–€ 450 |
| AC Expansion Valve (TXV) | 4.0h | € 180–€ 300 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 2.5h | € 112–€ 187 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.2h | € 54–€ 90 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 3.5h | € 157–€ 262 |
| Power Steering Hose - High Pressure | 1.0h | € 45–€ 75 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.0h | € 45–€ 75 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.0h | € 45–€ 75 |
| Air Suspension Valve Block | 2.0h | € 90–€ 150 |
| Ball Joint - Lower | 1.8h | € 81–€ 135 |
| Ball Joint - Upper | 1.5h | € 67–€ 112 |
| Ball Joints - Upper and Lower | 3.0h | € 135–€ 225 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Kickdown Cable | 0.8h | € 36–€ 60 |
| Neutral Safety Switch | 1.0h | € 45–€ 75 |
| Overdrive Solenoid | 2.0h | € 90–€ 150 |
| Shift Cable | 1.5h | € 67–€ 112 |
| Shift Linkage | 1.0h | € 45–€ 75 |
| Shift Solenoid - Single | 4.1h | € 184–€ 307 |
| Shift Solenoids - All | 9.0h | € 405–€ 675 |
| Torque Converter | 6.9h | € 310–€ 517 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
🔧 SCHEDULED MAINTENANCE
Accessory Drive Belt—
Engine Oil And Filter16,000 km / 12 months
Tire Rotation16,000 km / 12 months
Brake System Inspection16,000 km / 12 months
Multi-Point Inspection16,000 km / 12 months
Rotate Tires16,000 km / 12 months
Exhaust System16,000 km / 12 months
Steering And Suspension16,000 km / 12 months
📋 RECALLS & TSB (33)
NHTSA 22V730000
Exterior Lighting › Brake Lights
Date: 30/09/2022
Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles. Under certain circumstances, the Antilock Brake System (ABS) module may cause the brake lights to illuminate without the driver applying the brakes. As such, these vehicles fail to comply with the requiremen…
NHTSA 25V123000
Electrical System › Instrument Cluster/Panel
Date: 28/02/2025
Ford Motor Company (Ford) is recalling certain 2022-2023 Maverick Hybrid vehicles previously repaired incorrectly under recall number 24V-140. The instrument panel cluster may not properly illuminate warning lights or gauges. As such, these vehicles fail to comply with the requ…
NHTSA 25V124000
Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip › Control Unit/Module
Date: 28/02/2025
Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles previously repaired incorrectly under recall number 24V-730. Under certain circumstances, the Antilock Brake System (ABS) module may cause the brake lights to illuminate without the driver applying the brakes.…
NHTSA 25V127000
Power Train › Automatic Transmission › Control Module (Tcm/Pcm/Tecm)
Date: 28/02/2025
Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles previously repaired incorrectly under recall number 24V-590. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
NHTSA 25V132000
Electrical System › Integrated Trailer Brake Control
Date: 28/02/2025
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. Due to a software error, a towed trailer equipped with an electric o…
NHTSA 25V133000
Power Train › Automatic Transmission › Control Module (Tcm/Pcm/Tecm)
Date: 28/02/2025
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2022 Escape, and 2021-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 24V-330. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral un…
NHTSA 25V442000
Back Over Prevention › Software
Date: 27/06/2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2…
NHTSA 23V380000
Engine
Date: 26/05/2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate nea…
NHTSA 24V293000
Exterior Lighting › Tail Lights
Date: 26/04/2024
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. The Body Control Module (BCM) may inadvertently deactivate one or both rear tail lights.
NHTSA 22V193000
Electrical System › Integrated Trailer Brake Control
Date: 25/03/2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
NHTSA 24V140000
Electrical System › Instrument Cluster/Panel
Date: 23/02/2024
Ford Motor Company (Ford) is recalling certain 2022-2023 Maverick Hybrid vehicles. The Instrument Panel Cluster may not properly illuminate warning lights or gauges. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 10…
NHTSA 24V223000
Tires
Date: 22/03/2024
Ford Motor Company (Ford) is recalling certain 2023 Maverick and Bronco Sport vehicles. The tires may have been manufactured incorrectly, which may result in a loss of vehicle handling and control.
NHTSA 26V104000
Electrical System › Integrated Trailer Brake Control
Date: 20/02/2026
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer mo…
NHTSA 24V778000
Child Seat › Vehicle Tether Anchor
Date: 18/10/2024
Ford Motor Company (Ford) is recalling certain 2024 Maverick vehicles. The second-row child seat tether anchors may not properly secure a child seat, due to incomplete thread engagement. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safet…
NHTSA 25V019000
Electrical System › 12V/24V/48V Battery
Date: 17/01/2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.
NHTSA 21V979000
Seat Belts › Rear/Other › Anchorage
Date: 16/12/2021
Ford Motor Company (Ford) is recalling certain 2021-2022 Mustang Mach-E and 2022 Maverick vehicles. The rear seat belt buckles may not be properly attached to the rear floor assembly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety S…
NHTSA 21V976000
Fuel System, Gasoline › Storage
Date: 16/12/2021
Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles. The fuel tank may have been damaged by drill holes during the installation of the spray-in bed-liner. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard num…
NHTSA 23V848000
Exterior Lighting › Turn Signal › Bulbs
Date: 15/12/2023
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driver that a turn signal is not working correctly. As such, th…
NHTSA 25V158000
Power Train › Automatic Transmission › Control Module (Tcm/Pcm/Tecm)
Date: 14/03/2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
NHTSA 25V094000
Exterior Lighting › Turn Signal
Date: 14/02/2025
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 23V-848. In the event that one of the rear turn signals stops working, the vehicle will not adjust the turn signal flash rate frequency to warn the driv…
NHTSA 25V095000
Exterior Lighting › Tail Lights
Date: 14/02/2025
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick vehicles previously repaired incorrectly under recall number 24V-293. The body control module (BCM) may inadvertently deactivate one or both rear tail lights.
NHTSA 24V684000
Back Over Prevention › Software
Date: 13/09/2024
Ford Motor Company (Ford) is recalling certain 2022-2024 Ford Maverick vehicles equipped with Connected Touch Radios (CTR). The rearview camera image may freeze when the vehicle is in reverse.
NHTSA 24V267000
Electrical System › Body Control Module/Bcm
Date: 12/04/2024
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
NHTSA 24V266000
Equipment › Other › Labels
Date: 12/04/2024
Ford Motor Company (Ford) is recalling certain 2024 Maverick vehicles. The tire and loading information label may state the incorrect vehicle capacity, tire pressure, and spare tire size. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safe…
NHTSA 25V685000
Equipment › Electrical › Engine Block Heater
Date: 10/10/2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolan…
NHTSA 24V330000
Power Train › Automatic Transmission › Control Module (Tcm/Pcm/Tecm)
Date: 10/05/2024
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
NHTSA 23V160000
Exterior Lighting › Tail Lights
Date: 10/03/2023
Ford Motor Company (Ford) is recalling certain 2023 Maverick vehicles. A missing electrical circuit may cause the trailer taillights to not illuminate as intended when utilizing the vehicle trailer tow electrical connector. As such, these vehicles fail to comply with the requir…
NHTSA 24V590000
Electrical System › Body Control Module/Bcm
Date: 09/08/2024
Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles previously repaired under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.
NHTSA 24V594000
Visibility › Windshield Wiper/Washer › Motor
Date: 09/08/2024
Ford Motor Company (Ford) is recalling certain 2023-2024 Maverick, Ford Bronco Sport, and Mustang Mach-E vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.
NHTSA 22V594000
Air Bags › Side/Window › Curtain
Date: 08/08/2022
Ford Motor Company (Ford) is recalling certain 2022 Maverick vehicles. The side-curtain air bags may not deploy properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 226, "Ejection Mitigation."
NHTSA 24V185000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 08/03/2024
Ford Motor Company (Ford) is recalling certain 2024 Maverick vehicles. The fuel tanks may have an open pinch joint between the two molds, which can allow fuel to leak.
NHTSA 22V484000
Engine And Engine Cooling
Date: 07/07/2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate …
NHTSA 25V345000
Engine
Date: 06/06/2025
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be relea…
COMMON OBD2 CODES TO CHECK
P0420
Catalyst System Efficiency Below Threshold Bank 1
Powertrain
P0171
System Too Lean Bank 1
Powertrain
P0300
Random/Multiple Cylinder Misfire Detected
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
Coolant Thermostat Below Regulating Temperature
Powertrain
P0455
EVAP System Leak Detected (Gross Leak)
Powertrain
P0700
Transmission Control System (MIL Request)
Powertrain
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1651
powertrain
LOWP1650
powertrain
LOWP1641
powertrain
HIGHP1579
powertrain
HIGHP1537
powertrain
LOWP1455
powertrain
MODERATEP1451
powertrain
LOWP1409
powertrain
MODERATEP1383
powertrain
MODERATEP1285
powertrain
HIGHP1270
powertrain
LOWP1237
powertrain
HIGHP1235
powertrain
HIGHP1152
powertrain
MODERATEP1117
powertrain
LOWP1116
powertrain
LOWP1103
powertrain
MODERATEP1783
powertrain
CRITICALP1746
powertrain
HIGHP1742
powertrain
HIGH
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
57 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
Low Oil Pressure (Ford)Engine
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
AdvanceTrac Off (Ford)Chassis
SYNC System Fault (Ford)Electrical
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
MyKey Speed Limit (Ford)Electrical
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
467 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Ford Maverick across model years 2022–2024. These are real, verified reports submitted by vehicle owners.
22 crash reports 3 fires 12 injuries 1 death
Complaints by model year (most reported first)
Model year 2023263
Model year 2022139
Model year 202465
Most reported components (all years)
Power Train132
Electrical System116
Engine83
Unknown Or Other64
Service Brakes45
Back Over Prevention28
Sample reports
CV axles both going bad at 50,000 miles (MY 2023)
The brakes on my 2023 Ford Maverick (Hybrid) are very grabby at low speeds, usually just before coming to a stop. They are also very noisy especially after a hard rain. I have experienced one incident where the brakes did not want to sto… (MY 2023)
Front CV axles began failing at around 20,000 miles. The truck shakes when accelerating at all speeds but especially at 40-50mph or under load. (MY 2024)
While driving down US-69, while attempting to pass a vehicle at about 80 mph, the vehicle shut off and proceeded to stop accelerating, as well as started to slow itself down. The instrument cluster flashed quickly before shutting off, an… (MY 2023)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 2022–2024.
Frequently Asked Questions
Does the Ford Maverick have any safety recalls?
Yes — 33 official NHTSA recall campaign(s) affect this model, mainly: SEAT BELTS:REAR/OTHER:ANCHORAGE, FUEL SYSTEM, GASOLINE:STORAGE. Check the recalls section for your exact year/VIN.
What does fault code P0003 mean on the Ford Maverick?
Fuel Volume Regulator Control Circuit Low This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0002 mean on the Ford Maverick?
Fuel Volume Regulator Control Circuit Range/Performance This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0001 mean on the Ford Maverick?
Fuel Volume Regulator Control Circuit/Open This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are brakes problems common on the Ford Maverick?
Yes — 78 of 458 real owner reports filed with NHTSA mention the brakes. One owner reported: “The contact owns a 2022 Ford Maverick. The contact stated that while driving at an undisclosed speed, the trailer brakes became inoperable. There was no warning light illuminated. The contact was info…” See the owner-reported complaints section below for more.
Are engine problems common on the Ford Maverick?
Yes — 104 of 458 real owner reports filed with NHTSA mention the engine. One owner reported: “When we brought it in for first oil change at the dealership ; when we got it back it had a broken axle which they tried to say we just needed new tires , after contacting service manager and he and I…” See the owner-reported complaints section below for more.
Are electrical problems common on the Ford Maverick?
Yes — 177 of 458 real owner reports filed with NHTSA mention the electrical. One owner reported: “Vehicle started experiencing loss of power while driving on the highway. After having it towed to the local Ford dealership, we were informed that our transmission was shot and needed to be replaced. …” See the owner-reported complaints section below for more.
What tyres does the Ford Maverick (2022–2024) use?
The original OEM tyre size for the Ford Maverick (2022–2024) is 215/55 R16. Compatible alternative sizes: ["225/65R17", "235/55R19", "235/65R17", "245/50R19", "245/45R19"]. See the Tyres section on this page to compare offers from the main suppliers.
What is the right battery for the Ford Maverick (2022–2024)?
The battery specified for the Ford Maverick (2022–2024) is group 96R (BCI), with a cold cranking rating of 760A. See the Battery section on this page for the main cross-references between brands.
What engine oil should I use on the Ford Maverick (2022–2024)?
The engine oil specification for the Ford Maverick (2022–2024) is Motorcraft 0W-20 Full Synthetic. Always use the viscosity grade approved by the manufacturer: a different oil can reduce engine protection and void the warranty. Check the change interval in the Maintenance section.
Which OBD2 fault codes are commonly documented for the Ford Maverick (2022–2024)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Ford Maverick (2022–2024) be serviced?
Routine maintenance for the Ford Maverick (2022–2024) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Found what you were looking for? Explore other Ford models in our database, compare tyre offers in your size, or search a specific fault code in the TroubleAtlas OBD2 database.