TroubleAtlas Score
FORD MUSTANG-MACH-E (2021–2024): Technical Data, DTC & Service Schedule
Built 2021–2024 · all production years covered on this single page
Extended Range Dual Motor AWD • Electric
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Ford Mustang-Mach-E (2021–2024) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost3.7
Parts & repairability3.3
Maintenance & durability5.9
Documentation & supportn/a
Independent · Verified · Never for sale
Every figure on this Ford Mustang-Mach-E (2021–2024) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
Its battery is group H6 (BCI), rated at 680A cold-cranking amps. It is a fully electric vehicle (Extended Range Dual Motor AWD). Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Scheduled maintenance
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Easy
0.8h
€56 – €72
Rear brake pads
Difficulty: Easy
0.9h
€63 – €81
ABS Module
Difficulty: Medium
2.0h
€140 – €180
ABS Pump
Difficulty: Hard
2.5h
€175 – €225
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.5h | € 112–€ 187 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 0.8h | € 36–€ 60 |
| ABS Wheel Speed Sensor - Rear | 0.8h | € 36–€ 60 |
| Brake Bleed - All Four | 1.0h | € 45–€ 75 |
| Brake Caliper - Front | 1.0h | € 45–€ 75 |
| Brake Caliper - Rear | 1.0h | € 45–€ 75 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Cooling Fan Assembly | 1.0h | € 45–€ 75 |
| Cooling Fan Clutch | 3.0h | € 135–€ 225 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 0.3h | € 13–€ 22 |
| Engine Oil Cooler | 3.0h | € 135–€ 225 |
| Heater Control Valve | 3.0h | € 135–€ 225 |
| Heater Core | 3.0h | € 135–€ 225 |
| Heater Hoses | 3.0h | € 135–€ 225 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.0h | € 45–€ 75 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 2.0h | € 90–€ 150 |
| Airbag Module/Computer | 1.0h | € 45–€ 75 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
| Backup Camera | 1.0h | € 45–€ 75 |
| Battery | 0.3h | € 13–€ 22 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Camshaft Position Sensor | 8.0h | € 360–€ 600 |
| Connecting Rod Bearings | 8.0h | € 360–€ 600 |
| Crankshaft Position Sensor | 8.0h | € 360–€ 600 |
| Engine R&R | 12.0h | € 540–€ 900 |
| Freeze Plug - Single | 8.0h | € 360–€ 600 |
| Freeze Plugs - All | 10.4h | € 468–€ 780 |
| Front Main Seal | 8.0h | € 360–€ 600 |
| Harmonic Balancer | 8.0h | € 360–€ 600 |
Fuel system3 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 2.5h | € 112–€ 187 |
| EVAP Purge Valve | 2.5h | € 112–€ 187 |
| EVAP Vent Valve | 2.5h | € 112–€ 187 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.5h | € 67–€ 112 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.5h | € 112–€ 187 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 0.5h | € 22–€ 37 |
| AC Condenser | 2.5h | € 112–€ 187 |
| AC Evaporator | 6.0h | € 270–€ 450 |
| AC Expansion Valve (TXV) | 4.0h | € 180–€ 300 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 2.5h | € 112–€ 187 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.2h | € 54–€ 90 |
| Rack and Pinion Boots | 2.0h | € 90–€ 150 |
| Steering Angle Sensor | 1.0h | € 45–€ 75 |
| Steering Column | 3.0h | € 135–€ 225 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.0h | € 45–€ 75 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.0h | € 45–€ 75 |
| Air Suspension Valve Block | 2.0h | € 90–€ 150 |
| Ball Joint - Lower | 1.8h | € 81–€ 135 |
| Ball Joint - Upper | 1.5h | € 67–€ 112 |
| Ball Joints - Upper and Lower | 3.0h | € 135–€ 225 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Clutch Disc | 6.0h | € 270–€ 450 |
| Clutch Hydraulic Line | 6.0h | € 270–€ 450 |
| Dual Mass Flywheel | 6.0h | € 270–€ 450 |
| Kickdown Cable | 6.0h | € 270–€ 450 |
| Manual Trans Fluid Change | 6.0h | € 270–€ 450 |
| Neutral Safety Switch | 6.0h | € 270–€ 450 |
| Overdrive Solenoid | 6.0h | € 270–€ 450 |
| Pilot Bearing | 6.0h | € 270–€ 450 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
🔧 SCHEDULED MAINTENANCE
Brake Fluid Replacement36 months
Battery Coolant120 months
Brake Fluid36 months
Windshield Washer Fluid—
Wiper Blades12 months
Electric Drive Motor Coolant120 months
12-Volt Battery12 months
Wheel Alignment—
📋 RECALLS & TSB (0)
No official recall verified for this vehicle in the NHTSA database.
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
Coolant Thermostat Below Regulating Temperature
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1783
powertrain
CRITICALP1746
powertrain
HIGHP1742
powertrain
HIGHP1741
powertrain
HIGHP1740
powertrain
MODERATEP1728
powertrain
HIGHP1703
powertrain
MODERATEP1568
powertrain
LOWP1269
powertrain
HIGHP1001
powertrain
LOWP1259
powertrain
HIGHP1744
powertrain
HIGHP1260
powertrain
HIGHP1000
powertrain
LOWP1700
powertrain
HIGHP1565
powertrain
LOWP1500
powertrain
MODERATEP1747
powertrain
HIGHP1639
powertrain
HIGHP1637
powertrain
HIGH
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
57 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
Low Oil Pressure (Ford)Engine
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
AdvanceTrac Off (Ford)Chassis
SYNC System Fault (Ford)Electrical
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
MyKey Speed Limit (Ford)Electrical
Frequently Asked Questions
What tyres does the Ford Mustang-Mach-E (2021–2024) use?
The original OEM tyre size for the Ford Mustang-Mach-E (2021–2024) is 215/55 R16. Compatible alternative sizes: ["245/50R19", "245/45R20", "245/45R19", "225/60R18", "225/55R19"]. See the Tyres section on this page to compare offers from the main suppliers.
What is the right battery for the Ford Mustang-Mach-E (2021–2024)?
The battery specified for the Ford Mustang-Mach-E (2021–2024) is group H6 (BCI), with a cold cranking rating of 760A. See the Battery section on this page for the main cross-references between brands.
Which OBD2 fault codes are commonly documented for the Ford Mustang-Mach-E (2021–2024)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Ford Mustang-Mach-E (2021–2024) be serviced?
Routine maintenance for the Ford Mustang-Mach-E (2021–2024) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Considering buying a Ford Mustang-Mach-E (2021–2024)? Use this guide to check expected maintenance costs, the most reported fault codes and parts availability on the market. Real data, zero commercial estimates.