TroubleAtlas Score
HYUNDAI XG300 (2001–2005): Full Technical Specs & OBD2 Diagnostics
Built 2001–2005 · all production years covered on this single page
3.0L V6 • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Hyundai Xg300 (2001–2005) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost8.2
Parts & repairability4.4
Maintenance & durabilityn/a
Documentation & support6.0
Independent · Verified · Never for sale
Every figure on this Hyundai Xg300 (2001–2005) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Hyundai Xg300 (2001–2005) is powered by a 3.0L V6 engine. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Easy
0.8h
€56 – €72
Rear brake pads
Difficulty: Easy
0.9h
€63 – €81
Engine oil change
Difficulty: Easy
0.3h
€21 – €27
ABS Module
Difficulty: Medium
2.0h
€140 – €180
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.5h | € 112–€ 187 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 0.8h | € 36–€ 60 |
| ABS Wheel Speed Sensor - Rear | 0.8h | € 36–€ 60 |
| Brake Bleed - All Four | 1.0h | € 45–€ 75 |
| Brake Booster | 2.5h | € 112–€ 187 |
| Brake Booster Check Valve | 0.3h | € 13–€ 22 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.5h | € 67–€ 112 |
| Coolant Flush | 1.0h | € 45–€ 75 |
| Coolant Reservoir | 0.5h | € 22–€ 37 |
| Coolant Temperature Sensor | 0.5h | € 22–€ 37 |
| Cooling Fan Assembly | 1.0h | € 45–€ 75 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 0.3h | € 13–€ 22 |
| Engine Oil Cooler | 2.0h | € 90–€ 150 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.0h | € 45–€ 75 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 2.0h | € 90–€ 150 |
| Airbag Module/Computer | 1.0h | € 45–€ 75 |
| Alternator | 1.5h | € 67–€ 112 |
| Alternator Belt | 0.5h | € 22–€ 37 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Camshaft Position Sensor | 1.0h | € 45–€ 75 |
| Camshaft R&R | 8.0h | € 360–€ 600 |
| Connecting Rod Bearings | 15.0h | € 675–€ 1125 |
| Crankshaft Position Sensor | 1.0h | € 45–€ 75 |
| Crankshaft R&R | 20.0h | € 900–€ 1500 |
| Cylinder Head R&R | 6.0h | € 270–€ 450 |
| Cylinder Head Resurface | 8.0h | € 360–€ 600 |
| Engine Mount - Front | 1.5h | € 67–€ 112 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 0.8h | € 36–€ 60 |
| Catalytic Converter - California | 1.5h | € 67–€ 112 |
| Catalytic Converter - Direct Fit | 1.5h | € 67–€ 112 |
| Catalytic Converter - Universal | 2.0h | € 90–€ 150 |
| Downpipe | 2.0h | € 90–€ 150 |
| EGR Cooler | 3.0h | € 135–€ 225 |
| EGR Tube | 1.5h | € 67–€ 112 |
| EGR Valve | 1.0h | € 45–€ 75 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.0h | € 45–€ 75 |
| EVAP Purge Valve | 0.8h | € 36–€ 60 |
| EVAP Vent Valve | 0.8h | € 36–€ 60 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 1.5h | € 67–€ 112 |
| Fuel Filter | 0.5h | € 22–€ 37 |
| Fuel Filter - In-Tank | 2.0h | € 90–€ 150 |
| Fuel Injector - Single | 1.0h | € 45–€ 75 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.5h | € 67–€ 112 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.5h | € 112–€ 187 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 0.5h | € 22–€ 37 |
| AC Condenser | 2.5h | € 112–€ 187 |
| AC Evaporator | 6.0h | € 270–€ 450 |
| AC Expansion Valve (TXV) | 4.0h | € 180–€ 300 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 2.5h | € 112–€ 187 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.2h | € 54–€ 90 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 3.5h | € 157–€ 262 |
| Power Steering Hose - High Pressure | 1.0h | € 45–€ 75 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.0h | € 45–€ 75 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.0h | € 45–€ 75 |
| Air Suspension Valve Block | 2.0h | € 90–€ 150 |
| Ball Joint - Lower | 1.8h | € 81–€ 135 |
| Ball Joint - Upper | 1.5h | € 67–€ 112 |
| Ball Joints - Upper and Lower | 3.0h | € 135–€ 225 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Kickdown Cable | 0.8h | € 36–€ 60 |
| Neutral Safety Switch | 1.0h | € 45–€ 75 |
| Overdrive Solenoid | 2.0h | € 90–€ 150 |
| Shift Cable | 1.5h | € 67–€ 112 |
| Shift Linkage | 1.0h | € 45–€ 75 |
| Transmission Control Module | 1.0h | € 45–€ 75 |
| Transmission Cooler Lines | 1.0h | € 45–€ 75 |
| Transmission Filter | 1.0h | € 45–€ 75 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
📋 RECALLS & TSB (4)
NHTSA 01V362000
Power Train
Date: 29/11/2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IMPROPERLY MANUFACTURED POWERTRAIN CONTROL MODULES (PCM) WERE INSTALLED IN SOME VEHICLES. THE IMPROPERLY MANUFACTURED PCMS CONTAINED A CONDENSER THAT WAS NOT CORRECTLY INSTALLED ONTO THE PCM PRINTED CIRCUIT BOARD. THE INCORRECT INSTALL…
NHTSA 01V307000
Equipment › Other › Labels
Date: 26/09/2001
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 110. THESE VEHICLES DO NOT HAVE THE CORRECT TIRE PRESSURE PLACARD ATTACHED.
NHTSA 09V124000
Suspension
Date: 16/04/2009
HYUNDAI IS RECALLING 188,282 MY 2001-2004 SONATA AND MY 2001-2004 XG300 AND XG350 VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW…
NHTSA 02V105000
Air Bags › Side/Window
Date: 09/04/2002
ON CERTAIN PASSENGER VEHICLES, AN INTERMITTENT CONDITION THAT LEADS TO THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG WARNING LIGHT ILLUMINATION COULD RESULT FROM MOTION OF THE SIDE IMPACT AIR BAG WIRING HARNESS AND SIDE IMPACT AIR BAG WIRING HARNESS CONNECTOR WHICH MOUNT TO THE…
COMMON OBD2 CODES TO CHECK
P0420
Catalyst System Efficiency Below Threshold Bank 1
Powertrain
P0171
System Too Lean Bank 1
Powertrain
P0300
Random/Multiple Cylinder Misfire Detected
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
Coolant Thermostat Below Regulating Temperature
Powertrain
P0455
EVAP System Leak Detected (Gross Leak)
Powertrain
P0700
Transmission Control System (MIL Request)
Powertrain
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1123
powertrain
MODERATEP1693
powertrain
MODERATEP1611
powertrain
LOWP1586
powertrain
MODERATEP1307
powertrain
LOWP1295
powertrain
HIGHP1147
powertrain
HIGHP1118
powertrain
HIGHP1166
powertrain
MODERATEP1505
powertrain
MODERATEP1124
powertrain
MODERATEP1608
powertrain
CRITICALP1151
powertrain
HIGHP1440
powertrain
LOWP1110
powertrain
HIGHP1506
powertrain
MODERATEP1523
powertrain
LOWP1155
powertrain
HIGHP1134
powertrain
MODERATEP1111
powertrain
LOW
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
57 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
TPMS Warning (Hyundai)Tyres
e-4WD Fault (Hyundai)Chassis
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
Lane Keeping Assist Off (Hyundai)ADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
BlueLink Connected (Hyundai)Electrical
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
73 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Hyundai Xg300 across model years 2001–2005. These are real, verified reports submitted by vehicle owners.
6 crash reports 1 fire 9 injuries
Complaints by model year (most reported first)
Model year 200163
Model year 20038
Model year 20021
Model year 20041
Most reported components (all years)
Engine And Engine Cooling15
Electrical System12
Power Train12
Service Brakes9
Air Bags8
Vehicle Speed Control8
Sample reports
THE SUSPENSION AND BRAKES WILL LOCK UP AND WHEN IT IS WET I HAVE SLID INTO BANKS OF DIRT AND HIT MY OTHER VEHICLE AND IT DOES NOT MATTER HOW FAST I GO. I HAVE HAD MY BRAKES CHECKED AND HAVE HAD TO GET A WHEEL ALIGNMENT EVERY MONTH FOR… (MY 2001)
2001 HYUNDAI XG300 HAD BAD BRAKES. *CC THE FRONT AND REAR ROTORS NEEDED TO BE REPLACED DUE TO CORROSION. THE CONSUMER FEELS THAT THE CORROSION WAS CAUSED BY POOR MATERIALS. *NM (MY 2001)
WE OWN A HYUNDAI 2001 XG300 WHICH HAS SEVERE CORROSION AND RUST ON THE SUB FRAME. SINCE NOVEMBER, WE HAD DIFFERENT WORK PERFORMED ON THE CAR. ALL THE MECHANIC HAVE SAID THAT THE CORROSION AND RUST IS SEVERE AND IS EFFECTING THE SUSPENSIO… (MY 2001)
WHILE DRIVING AT HIGHWAY SPEED THE TRANSMISSION LIGHT ILLUMINATED AND THERE WAS A SUDDEN DECREASE IN ACCELERATION. THE VEHICLES RPM'S DROPPED TO 14. CONSUMER STATES' THIS WAS VERY DANGEROUS. PLEASE PROVIDE ANY FURTHER INFORMATION. TS (MY 2001)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 2001–2005.
Frequently Asked Questions
Does the Hyundai Xg300 have any safety recalls?
Yes — 4 official NHTSA recall campaign(s) affect this model, mainly: SUSPENSION, AIR BAGS:SIDE/WINDOW, POWER TRAIN. Check the recalls section for your exact year/VIN.
What does fault code P0003 mean on the Hyundai Xg300?
Fuel Volume Regulator Control Circuit Low This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0002 mean on the Hyundai Xg300?
Fuel Volume Regulator Control Circuit Range/Performance This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0001 mean on the Hyundai Xg300?
Fuel Volume Regulator Control Circuit/Open This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are brakes problems common on the Hyundai Xg300?
Yes — 12 of 69 real owner reports filed with NHTSA mention the brakes. One owner reported: “THE SUSPENSION AND BRAKES WILL LOCK UP AND WHEN IT IS WET I HAVE SLID INTO BANKS OF DIRT AND HIT MY OTHER VEHICLE AND IT DOES NOT MATTER HOW FAST I GO. I HAVE HAD MY BRAKES CHECKED AND HAVE HAD TO G…” See the owner-reported complaints section below for more.
Are electrical problems common on the Hyundai Xg300?
Yes — 19 of 69 real owner reports filed with NHTSA mention the electrical. One owner reported: “TL* THE CONTACT OWNS A 2001 HYUNDAI XG300. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND DRIVEN CAUTIOUSLY ON THE SHOULD…” See the owner-reported complaints section below for more.
Are engine problems common on the Hyundai Xg300?
Yes — 24 of 69 real owner reports filed with NHTSA mention the engine. One owner reported: “TL* THE CONTACT OWNS A 2001 HYUNDAI XG300. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND DRIVEN CAUTIOUSLY ON THE SHOULD…” See the owner-reported complaints section below for more.
Which OBD2 fault codes are commonly documented for the Hyundai Xg300 (2001–2005)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Hyundai Xg300 (2001–2005) be serviced?
Routine maintenance for the Hyundai Xg300 (2001–2005) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Have a specific fault code on your Hyundai Xg300 (2001–2005)? Search the code in the OBD2 section of this page or use the full TroubleAtlas DTC database. Need tyres? Compare prices and compatible sizes in the TroubleAtlas comparator.