TroubleAtlas Score
TOYOTA SIENNA (1998–2024) Manual — Codes, Tyres & Parts
Built 1998–2024 · all production years covered on this single page
2.5L I4 Hybrid • Hybrid
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Toyota Sienna (1998–2024) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost6.3
Parts & repairability4.5
Maintenance & durability6.6
Documentation & support8.6
Independent · Verified · Never for sale
Every figure on this Toyota Sienna (1998–2024) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
Its battery is group 35 (BCI), rated at 650A cold-cranking amps. It is a hybrid (2.5L I4 Hybrid). Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Scheduled maintenance
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Easy
0.8h
€56 – €72
Rear brake pads
Difficulty: Easy
0.9h
€63 – €81
Engine oil change
Difficulty: Easy
0.3h
€21 – €27
ABS Module
Difficulty: Medium
2.0h
€140 – €180
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.5h | € 112–€ 187 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 0.8h | € 36–€ 60 |
| ABS Wheel Speed Sensor - Rear | 0.8h | € 36–€ 60 |
| Brake Bleed - All Four | 1.0h | € 45–€ 75 |
| Brake Booster | 2.5h | € 112–€ 187 |
| Brake Booster Check Valve | 0.3h | € 13–€ 22 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.5h | € 67–€ 112 |
| Coolant Flush | 1.0h | € 45–€ 75 |
| Coolant Reservoir | 0.5h | € 22–€ 37 |
| Coolant Temperature Sensor | 0.5h | € 22–€ 37 |
| Cooling Fan Assembly | 1.0h | € 45–€ 75 |
| Cooling Fan Clutch | 1.0h | € 45–€ 75 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 0.3h | € 13–€ 22 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.0h | € 45–€ 75 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 2.0h | € 90–€ 150 |
| Airbag Module/Computer | 1.0h | € 45–€ 75 |
| Alternator | 1.5h | € 67–€ 112 |
| Alternator Belt | 0.5h | € 22–€ 37 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Camshaft Position Sensor | 1.0h | € 45–€ 75 |
| Camshaft R&R | 8.0h | € 360–€ 600 |
| Connecting Rod Bearings | 15.0h | € 675–€ 1125 |
| Crankshaft Position Sensor | 1.0h | € 45–€ 75 |
| Crankshaft R&R | 20.0h | € 900–€ 1500 |
| Cylinder Head R&R | 6.0h | € 270–€ 450 |
| Cylinder Head Resurface | 8.0h | € 360–€ 600 |
| Engine Mount - Front | 1.5h | € 67–€ 112 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 0.8h | € 36–€ 60 |
| Catalytic Converter - California | 1.5h | € 67–€ 112 |
| Catalytic Converter - Direct Fit | 1.5h | € 67–€ 112 |
| Catalytic Converter - Universal | 2.0h | € 90–€ 150 |
| Downpipe | 2.0h | € 90–€ 150 |
| EGR Cooler | 3.0h | € 135–€ 225 |
| EGR Tube | 1.5h | € 67–€ 112 |
| EGR Valve | 1.0h | € 45–€ 75 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.0h | € 45–€ 75 |
| EVAP Purge Valve | 0.8h | € 36–€ 60 |
| EVAP Vent Valve | 0.8h | € 36–€ 60 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 1.5h | € 67–€ 112 |
| Fuel Filter | 0.5h | € 22–€ 37 |
| Fuel Filter - In-Tank | 2.0h | € 90–€ 150 |
| Fuel Injector - Single | 1.0h | € 45–€ 75 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.5h | € 67–€ 112 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.5h | € 112–€ 187 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 0.5h | € 22–€ 37 |
| AC Condenser | 2.5h | € 112–€ 187 |
| AC Evaporator | 6.0h | € 270–€ 450 |
| AC Expansion Valve (TXV) | 4.0h | € 180–€ 300 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 2.5h | € 112–€ 187 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.2h | € 54–€ 90 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 3.5h | € 157–€ 262 |
| Power Steering Hose - High Pressure | 1.0h | € 45–€ 75 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.0h | € 45–€ 75 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.0h | € 45–€ 75 |
| Air Suspension Valve Block | 2.0h | € 90–€ 150 |
| Ball Joint - Lower | 1.8h | € 81–€ 135 |
| Ball Joint - Upper | 1.5h | € 67–€ 112 |
| Ball Joints - Upper and Lower | 3.0h | € 135–€ 225 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Kickdown Cable | 0.8h | € 36–€ 60 |
| Neutral Safety Switch | 1.0h | € 45–€ 75 |
| Overdrive Solenoid | 2.0h | € 90–€ 150 |
| Shift Cable | 1.5h | € 67–€ 112 |
| Shift Linkage | 1.0h | € 45–€ 75 |
| Shift Solenoid - Single | 3.6h | € 162–€ 270 |
| Shift Solenoids - All | 7.8h | € 351–€ 585 |
| Torque Converter | 6.0h | € 270–€ 450 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
🔧 SCHEDULED MAINTENANCE
Brake Fluid Replacement36 months
Engine Oil And Filter16,000 km / 12 months
Tire Rotation16,000 km / 12 months
Brake System Inspection16,000 km / 12 months
Drive Belt Inspection16,000 km / 12 months
Steering And Suspension Inspection16,000 km / 12 months
Exhaust System Inspection16,000 km / 12 months
Fuel System Inspection16,000 km / 12 months
📋 RECALLS & TSB (54)
NHTSA 11V560000
Equipment › Other › Labels
Date: 30/11/2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 THROUGH 2012 SIENNA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 110, "TIRE SELECTIONS AND RIMS." THESE VEHICLES DO NOT MEET THE REQUIREMENT FOR DISPLAYING THE CORRECT VEHICLE CAP…
NHTSA 16V858000
Structure › Body › Door
Date: 29/11/2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2011-2016 Toyota Sienna minivans manufactured January 4, 2010, to August 12, 2016. If the power sliding door is unable to be opened when commanded, such as if the door is frozen shut, the door may …
NHTSA 19V503000
Equipment › Other › Labels
Date: 28/06/2019
Southeast Toyota Distributors, LLC (SET) is recalling certain 2017-2019 Toyota Camry, Corolla, Rav4, Sienna, and Yaris iA vehicles equipped with factory-installed floor mats. The load carrying capacity modification label may be incorrect. As such, these vehicles fail to comply …
NHTSA 19V244000
Equipment › Other › Labels
Date: 27/03/2019
Gulf States Toyota (GST) is recalling certain 2019 C-HR, 4Runner, Avalon, Avalon Hybrid, Camry, Camry Hybrid, Highlander, Land Cruiser, Prius, RAV4, Sequoia, Tacoma, Sienna, Tundra and Yaris vehicles. The text on the load capacity label may become illegible. As such, these vehi…
NHTSA 14V757000
Air Bags › Side/Window
Date: 26/11/2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Sienna vehicles manufactured September 2, 2014, to November 25, 2014. In the event of a crash that necessitates the deployment of the curtain shield airbag (CSA), the second row overhead assis…
NHTSA 13V429000
Power Train › Automatic Transmission
Date: 26/09/2013
Toyota is recalling certain model year 2004-2005 Sienna vehicles manufactured January 10, 2003, through August 10, 2005; and model year 2007-2009 Sienna vehicles manufactured February 20, 2007, through December 12, 2008. In the affected vehicles, due to a problem within the shif…
NHTSA 19V553000
Service Brakes, Hydraulic › Foundation Components › Hoses, Lines/Piping, And Fittings
Date: 25/07/2019
Vantage Mobility International, LLC (Vantage) is recalling certain 2012-2018 AMS Genesis wheelchair vans, built on a Toyota Sienna vehicles. The rubber brake hoses that attach to the rear wheel assembly may be too short, causing them to rub against the rear axle trailing arm.
NHTSA 09V234000
Equipment › Other › Labels
Date: 25/06/2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2009 SIENNA AND 2009 LEXUS GX PASSENGER VEHICLES. THE VEHICLE CAPACITY WEIGHT ON THE TIRE AND LOADING INFORMATION LABEL AND THE GVWR ON THE CERTIFICATION LABEL IS INSUFFICIENT FOR CERTAIN VEHICLES. SOME VEHICLES WERE ACCESSORI…
NHTSA 16V340000
Air Bags › Frontal › Passenger Side › Inflator Module
Date: 23/05/2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2011 Scion xB and Lexus IS F, 2009-2011 Toyota Corolla and Corolla Matrix, 2006-2011 Toyota Yaris, Lexus IS250 and Lexus IS350, 2010-2011 Toyota 4Runner, Lexus IS250C, Lexus IS350C and Lexus GX…
NHTSA 19V318000
Air Bags › Frontal › Passenger Side › Inflator Module
Date: 23/04/2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019 Sienna vehicles. The passenger front door may have incorrect welds inside, possibly affecting the air bag sensor readings for the passenger side front seat and curtain shield air bags.
NHTSA 12V120000
Equipment › Electrical
Date: 23/03/2012
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2012 4RUNNER AND SIENNA VEHICLES, EQUIPPED WITH NON-ORIGINAL EQUIPMENT REMOTE ENGINE STARTERS. A MALFUNCTION IN THE AUDIOVOX ELECTRONICS BRAND REMOTE ENGINE STARTER MODULE CAN PREVENT NORMAL COMMUNICATION OF THE VEHICLES CONTRO…
NHTSA 11V566000
Structure › Body › Roof And Pillars
Date: 22/11/2011
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010-2011 COROLLA VEHICLES EQUIPPED WITH A NON-TOYOTA, BLUE TOOTH HANDS FREE DEVICE OR NAVIGATION UNIT AND CERTAIN MODEL YEAR 2011 TOYOTA SIENNA VEHICLES EQUIPPED WITH A NON-TOYOTA, OVERHEAD ENTERTAINMENT SYSTEM AND/OR BLUETOOTH H…
NHTSA 14V273000
Tires › Temporary/Emergency Spare Tire
Date: 22/05/2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New …
NHTSA 15V240000
Structure › Body › Roof And Pillars
Date: 22/04/2015
Gulf States Toyota, Inc. (GST) is recalling certain model year 2015 Toyota Sienna vehicles manufactured January 23, 2015, to April 13, 2015, and equipped with non-Toyota-brand overhead entertainment accessories installed by GST. During reassembly of the interior after the overhe…
NHTSA 18V130000
Wheels
Date: 22/02/2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018 Toyota Sienna vehicles built with a specific lot of 10-spoke alloy wheels from one production facility. These wheels may not have been properly cooled during manufacturing. As a result, the wheels may c…
NHTSA 15V236000
Structure › Body › Roof And Pillars
Date: 21/04/2015
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2015 Sienna vehicles manufactured September 1, 2014, to April 13, 2015 and equipped with overhead entertainment accessories installed by SET. During reassembly of the interior after the overhead entertainme…
NHTSA 17V831000
Equipment › Other › Labels
Date: 20/12/2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2017-2018 Toyota 4Runner and Tundra, 2018 Toyota Highlander, RAV4 and Lexus GX460 and 2017 Toyota Sienna and Tacoma vehicles. These vehicles may have incorrect load carrying capacity modification labels. As …
NHTSA 05V327000
Seat Belts
Date: 20/07/2005
ON CERTAIN MINI VANS, IN THE MIDDLE ROW SEATING POSITION, THE SHOULDER PORTION OF THE SEAT BELT MAY BIND IN THE BEZEL TRIM PIECE. THE AFFECTED SEAT BELT BEZEL IS LOCATED ON THE SHOULDER PORTION OF THE SEAT IN THE RIGHT SIDE SEAT OF THE SEVEN PASSENGER MODELS AND THE CENTER SEAT…
NHTSA 10V160000
Structure
Date: 20/04/2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, …
NHTSA 14V743000
Seats › Front Assembly › Seat Heater/Cooler
Date: 19/11/2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and…
NHTSA 98V278000
Electrical System › Ignition › Anti-Theft › Control Module
Date: 19/10/1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES, MINI VANS AND PASSENGER VEHICLES EQUIPPED WITH A THEFT DETERRENT SYSTEMS (TDS) SUPPLIED BY AUDIOVOX CORPORATION AND DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLI…
NHTSA 98E035000
Electrical System › Ignition › Anti-Theft › Control Module
Date: 19/10/1998
EQUIPMENT DESCRIPTION: AFTERMARKET THEFT DETERRENT SYSTEMS USED ON 1998-1998 TOYOTA RAV4, AVALON, AND SIENNA MODEL VEHICLES DISTRIBUTED BY SOUTHEAST TOYOTA DISTRIBUTORS, INC. IN THE STATES OF ALABAMA, FLORIDA, GEORGIA, NORTH AND SOUTH CAROLINA. THE ALARM WIRING HARNESS PLUGS …
NHTSA 14V576000
Fuel System, Gasoline › Delivery › Hoses, Lines/Piping, And Fittings
Date: 19/09/2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2014 Toyota Avalon, Camry, Sienna, and Highlander and model year 2015 Lexus RX350 vehicles. Fuel may leak from the one of the fuel delivery pipes in the engine compartment.
NHTSA 17V657000
Power Train › Automatic Transmission
Date: 18/10/2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2005-2007 and 2009-2010 Toyota Sienna vehicles. In the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'Park' position without depressing the brake …
NHTSA 25V876000
Equipment Adaptive/Mobility › Wheelchair Restraints/Securement › Latch/Anchor ›
Date: 17/12/2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max …
NHTSA 25V877000
Equipment Adaptive/Mobility › Wheelchair Restraints/Securement › Latch/Anchor ›
Date: 17/12/2025
Vantage Mobility, LLC (VM) is recalling certain 2021-2026 Honda Odyssey, 2021-2025 Chrysler Pacifica, and Toyota Sienna vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. The retractors may not lock, preventing the wheelchair from being properly secured.
NHTSA 21V889000
Seat Belts › Rear/Other › Anchorage
Date: 17/11/2021
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022 Sienna vehicles equipped with seating for eight passengers. An incorrect seat belt webbing guide may have been installed on the outboard second-row seat belt assemblies.
NHTSA 19V741000
Air Bags › Frontal › Passenger Side › Inflator Module
Date: 17/10/2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350,…
NHTSA 10V270000
Seats
Date: 17/06/2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SW…
NHTSA 19V532000
Steering
Date: 16/07/2019
Braun Corporation (Braun) is recalling certain modified 2017-2020 Toyota Sienna vehicles. The steering shaft extensions may have been improperly manufactured, possibly causing the extensions to fracture.
NHTSA 13V014000
Air Bags › Frontal › Sensor/Control Module-Inactive
Date: 16/01/2013
Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model ye…
NHTSA 09V023000
Vehicle Speed Control › Accelerator Pedal
Date: 16/01/2009
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 26,501 EARLY 2004 MY SIENNA VEHICLES. IN THE EVENT THE RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER IS MISSING, THE COVER CAN INTERFERE WITH THE OPERATION OF THE ACCELERATOR PEDAL IF THE ACCELERATION PEDAL IS D…
NHTSA 09V223000
Equipment › Other › Labels
Date: 15/06/2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STAND…
NHTSA 10V620000
Service Brakes, Hydraulic › Pedals And Linkages
Date: 13/12/2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 SIENNA VEHICLES. THE BRAKE STOP LAMP SWITCH IS MOUNTED ON A SMALL BRACKET WELDED ON THE LEFT SIDE OF THE SERVICE BRAKE PEDAL SUPPORT ASSEMBLY. DUE TO ITS PROXIMITY TO THE PARKING BRAKE PEDAL, IN LIMITED CIRCUMSTANCES THE STOP LAMP SWI…
NHTSA 22V239000
Electronic Stability Control (Esc) › Control Module › Software
Date: 13/04/2022
Toyota Engineering & Manufacturing (Toyota) is recalling certain 2022 Lexus LX 600, Lexus NX 350h, Lexus NX 450h+, Toytoa RAV4 Hybrid, 2021-2022 Lexus LS 500h, Toyota Mirai, RAV4 PRIME, Sienna, Venza, and 2020-2022 Toyota Highlander Hybrid vehicles. The Skid Control ECU software…
NHTSA 20V012000
Fuel System, Gasoline › Delivery › Fuel Pump
Date: 13/01/2020
Toyota Motor Engineering & Manufacturing (Toyota) recalled certain 2018-2019 4Runner, Highlander, Camry, Land Cruiser, Sequoia, Sienna, Tacoma and Tundra, and Lexus RC 300, RC 350, GS 350, GX 460, IS 300, LC 500, LS 500, LX 570, RX 350L, and 2019 Toyota Avalon and Corolla, and ce…
NHTSA 03V291000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 12/08/2003
ON CERTAIN SPORT UTILITY VEHICLES, A PART OF THE FUEL TANK MAY BECOME DAMAGED WHEN CRASHED IN THE INSURANCE INSTITUTE FOR HIGHWAY SAFETY'S (IIHS) 40 MPH FRONTAL OFFSET CRASH TEST CONDITIONS, DUE TO THE SEVERE IMPACT FORCES GENERATED.
NHTSA 11V539000
Engine And Engine Cooling
Date: 09/11/2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUI…
NHTSA 13V123000
Equipment › Other › Labels
Date: 09/04/2013
Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota L…
NHTSA 19V005000
Air Bags › Frontal › Passenger Side › Inflator Module
Date: 09/01/2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2014-2016 Toyota 4Runner, 2014-2015 Scion xB, Lexus IS350C, IS250C, 2014 Toyota Sienna, Lexus IS-F, and 2014-2017 Lexus GX460 vehicles sold, or ever registered in the states of Alabama, California, Florida, Ge…
NHTSA 18V024000
Air Bags › Frontal › Passenger Side › Inflator Module
Date: 09/01/2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013 Scion xB, Toyota Corolla, Corolla Matrix, Sienna, 4Runner, Lexus IS250, IS350, IS250C, IS350C, IS-F, and GX460 vehicles sold, ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, …
NHTSA 17V006000
Air Bags › Frontal › Passenger Side › Inflator Module
Date: 09/01/2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2012 Toyota 4Runner, Corolla, Corolla Matrix, Sienna, Yaris, Scion xB, Lexus ES350, GX460, IS-F, IS250, IS350, IS250C, IS350C, and Lexus LFA vehicles originally sold, or ever registered, in Alabama, California…
NHTSA 14V414000
Power Train › Automatic Transmission › Gear Position Indication (Prndl)
Date: 08/07/2014
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2014 Sienna vehicles manufactured June 17, 2014, through June 24, 2014. The affected vehicles have a transmission shift control cable whose protective cable sleeve may have been damaged during asse…
NHTSA 16V197000
Seat Belts › Front
Date: 07/04/2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016 Toyota Sienna vehicles manufactured February 15, 2016, to February 19, 2016. In the affected vehicles, incorrect front seat belt height adjusters may have been installed. During a crash, this…
NHTSA 01V072000
Structure › Frame And Members
Date: 05/03/2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FRONT SUB FRAME ASSEMBLY HAS NOT BEEN ADEQUATELY WELDED.
NHTSA 20V682000
Fuel System, Gasoline › Delivery › Fuel Pump
Date: 04/11/2020
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, …
NHTSA 19V410000
Service Brakes, Hydraulic › Foundation Components › Hoses, Lines/Piping, And Fittings
Date: 04/06/2019
Braun Corporation (Braun) is recalling certain 2014-2019 Toyota Sienna mobility van conversions. The brake lines may have incorrect tube nut fittings installed, which may cause a pressure drop within the braking system.
NHTSA 08V244000
Structure › Body › Hatchback/Liftgate
Date: 03/06/2008
TOYOTA IS CONDUCTING A SAFETY IMPROVEMENT CAMPAIGN INVOLVING 196,222 MY 2004-2006 TOYOTA SIENNA VEHICLES EQUIPPED WITH POWER REAR LIFTGATE STRUTS. THE GAS STRUTS USED TO HELP LIFT AND SUPPORT THE REAR POWER LIFTGATE COULD WEAR OUT SOONER THAN EXPECTED. AS THE GAS STRUTS DETERIO…
NHTSA 18V211000
Service Brakes, Hydraulic › Power Assist › Vacuum
Date: 03/04/2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018 Toyota Camry and Highlander vehicles, 2017 Toyota Sienna and Tacoma vehicles and 2017 Lexus RX350 vehicles. During the manufacturing process, the oil galley in the rotor for the brake booster vacuum pump…
NHTSA 10V036000
Equipment › Other › Labels
Date: 03/02/2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATI…
NHTSA 10V035000
Equipment › Other › Labels
Date: 03/02/2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISIT…
NHTSA 16V396000
Seats › Front Assembly › Seat Heater/Cooler
Date: 02/06/2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 V…
NHTSA 17V295000
Tires › Temporary/Emergency Spare Tire
Date: 02/05/2017
Gulf States Toyota, Inc. (Gulf States) is recalling certain 2017 4Runner , 86, Avalon, Camry, Camry Hybrid, Corolla, Corolla iM, Highlander, Highlander Hybrid, Prius, Prius C, RAV4, RAV4 Hybrid, Sienna and Yaris vehicles. The spare tire air pressure was not adjusted to the prop…
NHTSA 11V306000
Power Train › Driveline › Driveshaft
Date: 01/06/2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 VENZA AND SIENNA PASSENGER CARS MANUFACTURED FROM MARCH 7, THROUGH MARCH 10, 2011. THERE IS A POSSIBILITY THAT THE FRONT, RIGHT, DRIVE SHAFT MAY BREAK DUE TO INSUFFICIENT HEAT TREATMENT.
COMMON OBD2 CODES TO CHECK
P0420
Catalyst System Efficiency Below Threshold Bank 1
Powertrain
P0171
System Too Lean Bank 1
Powertrain
P0300
Random/Multiple Cylinder Misfire Detected
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
Coolant Thermostat Below Regulating Temperature
Powertrain
P0455
EVAP System Leak Detected (Gross Leak)
Powertrain
P0700
Transmission Control System (MIL Request)
Powertrain
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1661
powertrain
MODERATEP1658
powertrain
HIGHP1656
powertrain
MODERATEP1652
powertrain
MODERATEP1604
powertrain
HIGHP1510
powertrain
HIGHP1330
powertrain
HIGHP1315
powertrain
HIGHP1310
powertrain
HIGHP1305
powertrain
HIGHP1200
powertrain
HIGHP1765
powertrain
HIGHP1630
powertrain
HIGHP3475
powertrain
MODERATEP3473
powertrain
MODERATEP3253
powertrain
MODERATEP3476
powertrain
HIGHP3474
powertrain
MODERATEP3424
powertrain
LOWP3423
powertrain
HIGH
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
60 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
Master Warning (Toyota)Electrical
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
Pre-Collision System Off (Toyota)ADAS
Lane Departure Alert Off (Toyota)ADAS
Slip Indicator (Toyota)Chassis
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
READY Light (Toyota)Electrical
EV Mode Indicator (Toyota)Electrical
B-Ready (EV Brake) (Toyota)Brakes
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
8501 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Toyota Sienna across model years 1998–2024. These are real, verified reports submitted by vehicle owners.
420 crash reports 77 fires 658 injuries 10 deaths
Complaints by model year (most reported first)
Model year 20042062
Model year 20051130
Model year 20061016
Model year 2011609
Model year 2008428
Model year 2000364
Model year 2007362
Model year 1998293
Most reported components (all years)
Structure2658
Air Bags853
Latches/Locks/Linkages759
Electrical System663
Unknown Or Other580
Service Brakes538
Sample reports
2012 TOYOTA SIENNA DEVELOPED A "CLUNK" IN STEERING SYSTEM WHILE TURNING FROM A STOPPED POSITION. THE CLUNK CAN BE FELT THROUGH BOTH THE STEERING WHEEL AND FLOOR. THIS IS CAUSED BY A WELL-KNOWN SAFETY PROBLEM TOYOTA HAS HAD WITH SEVERAL… (MY 2012)
RACK AND PINION FAILURE. DEAR SIR/MADAM: I BROUGHT MY 2006 SIENNA (PURCHASED NEW) TO THE DEALERSHIP DUE TO WHAT I SUSPECTED WAS A BAD WHEEL BEARING ON THE FRONT PASSENGER SIDE. THE TECHNICIAN CONFIRMED THE BEARING PROBLEM, BUT ALSO INF… (MY 2006)
THE 2007 SIENNA VAN IN QUESTION IS ONE OF MANY PLAGUED BY AN ARRAY OF DOOR LATCH PROBLEMS OF MANY DIFFERENT VARIETIES THAT WERE NOT COVERED UNDER A VERY POORLY EXECUTED SO CALLED 'RECALL' ON THIS VAN. THE WHOLE DESIGN WAS POOR FROM THE S… (MY 2007)
THE CRUISE-CONTROL STALK LIGHT FLICKERS AT NIGHT CAUSING DISTRACTION (MY 2015)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 1998–2024.
Frequently Asked Questions
Does the Toyota Sienna have any safety recalls?
Yes — 54 official NHTSA recall campaign(s) affect this model, mainly: STRUCTURE, ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE, STRUCTURE:FRAME AND MEMBERS. Check the recalls section for your exact year/VIN.
What does fault code P0003 mean on the Toyota Sienna?
Fuel Volume Regulator Control Circuit Low This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0002 mean on the Toyota Sienna?
Fuel Volume Regulator Control Circuit Range/Performance This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0001 mean on the Toyota Sienna?
Fuel Volume Regulator Control Circuit/Open This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are steering problems common on the Toyota Sienna?
Yes — 430 of 4000 real owner reports filed with NHTSA mention the steering. One owner reported: “steering component that breaks, causing a driver to lose control.…” See the owner-reported complaints section below for more.
Are brakes problems common on the Toyota Sienna?
Yes — 455 of 4000 real owner reports filed with NHTSA mention the brakes. One owner reported: “AIR BAGS DID NOT DEPLOY IN A FRONT END COLLISION. WE WERE TRAVELING AT ABOUT 65MPH ON THE INTERSTATE WHEN ANOTHER VEHICLE LOST CONTROL, WRECKED, AND CAME TO A COMPLETE STOP IN OUR LANE AND FACING US.…” See the owner-reported complaints section below for more.
Are electrical problems common on the Toyota Sienna?
Yes — 625 of 4000 real owner reports filed with NHTSA mention the electrical. One owner reported: “AIR BAGS DID NOT DEPLOY IN A FRONT END COLLISION. WE WERE TRAVELING AT ABOUT 65MPH ON THE INTERSTATE WHEN ANOTHER VEHICLE LOST CONTROL, WRECKED, AND CAME TO A COMPLETE STOP IN OUR LANE AND FACING US.…” See the owner-reported complaints section below for more.
What tyres does the Toyota Sienna (1998–2024) use?
The original OEM tyre size for the Toyota Sienna (1998–2024) is 215/55 R16. Compatible alternative sizes: ["235/55R19", "235/65R17", "245/45R19", "235/60R18", "235/50R20"]. See the Tyres section on this page to compare offers from the main suppliers.
What is the right battery for the Toyota Sienna (1998–2024)?
The battery specified for the Toyota Sienna (1998–2024) is group 35 (BCI), with a cold cranking rating of 650A. See the Battery section on this page for the main cross-references between brands.
Which OBD2 fault codes are commonly documented for the Toyota Sienna (1998–2024)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Toyota Sienna (1998–2024) be serviced?
Routine maintenance for the Toyota Sienna (1998–2024) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Have a specific fault code on your Toyota Sienna (1998–2024)? Search the code in the OBD2 section of this page or use the full TroubleAtlas DTC database. Need tyres? Compare prices and compatible sizes in the TroubleAtlas comparator.