TroubleAtlas Score
TOYOTA TERCEL (1990–1998): Technical Data, DTC & Service Schedule
Built 1990–1998 · all production years covered on this single page
1.5L I4 • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Toyota Tercel (1990–1998) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost8.4
Parts & repairability4.0
Maintenance & durability5.9
Documentation & support6.8
Independent · Verified · Never for sale
Every figure on this Toyota Tercel (1990–1998) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
Its battery is group 35 (BCI), rated at 325A cold-cranking amps. It is powered by a 1.5L I4 engine. Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Scheduled maintenance
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Easy
0.8h
€56 – €72
Rear brake pads
Difficulty: Easy
0.9h
€63 – €81
Engine oil change
Difficulty: Easy
0.3h
€21 – €27
ABS Module
Difficulty: Medium
2.0h
€140 – €180
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.5h | € 112–€ 187 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 0.8h | € 36–€ 60 |
| ABS Wheel Speed Sensor - Rear | 0.8h | € 36–€ 60 |
| Brake Bleed - All Four | 1.0h | € 45–€ 75 |
| Brake Booster | 2.5h | € 112–€ 187 |
| Brake Booster Check Valve | 0.3h | € 13–€ 22 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.5h | € 67–€ 112 |
| Coolant Flush | 1.0h | € 45–€ 75 |
| Coolant Reservoir | 0.5h | € 22–€ 37 |
| Coolant Temperature Sensor | 0.5h | € 22–€ 37 |
| Cooling Fan Assembly | 1.0h | € 45–€ 75 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 0.3h | € 13–€ 22 |
| Engine Oil Cooler | 2.0h | € 90–€ 150 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.0h | € 45–€ 75 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 2.0h | € 90–€ 150 |
| Airbag Module/Computer | 1.0h | € 45–€ 75 |
| Alternator | 1.5h | € 67–€ 112 |
| Alternator Belt | 0.5h | € 22–€ 37 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Camshaft Position Sensor | 1.0h | € 45–€ 75 |
| Camshaft R&R | 8.0h | € 360–€ 600 |
| Connecting Rod Bearings | 15.0h | € 675–€ 1125 |
| Crankshaft Position Sensor | 1.0h | € 45–€ 75 |
| Crankshaft R&R | 20.0h | € 900–€ 1500 |
| Cylinder Head R&R | 6.0h | € 270–€ 450 |
| Cylinder Head Resurface | 8.0h | € 360–€ 600 |
| Engine Mount - Front | 1.5h | € 67–€ 112 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 0.8h | € 36–€ 60 |
| Catalytic Converter - California | 1.5h | € 67–€ 112 |
| Catalytic Converter - Direct Fit | 1.5h | € 67–€ 112 |
| Catalytic Converter - Universal | 2.0h | € 90–€ 150 |
| Downpipe | 2.0h | € 90–€ 150 |
| EGR Cooler | 3.0h | € 135–€ 225 |
| EGR Tube | 1.5h | € 67–€ 112 |
| EGR Valve | 1.0h | € 45–€ 75 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.0h | € 45–€ 75 |
| EVAP Purge Valve | 0.8h | € 36–€ 60 |
| EVAP Vent Valve | 0.8h | € 36–€ 60 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 1.5h | € 67–€ 112 |
| Fuel Filter | 0.5h | € 22–€ 37 |
| Fuel Filter - In-Tank | 2.0h | € 90–€ 150 |
| Fuel Injector - Single | 1.0h | € 45–€ 75 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.5h | € 67–€ 112 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.5h | € 112–€ 187 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 0.5h | € 22–€ 37 |
| AC Condenser | 2.5h | € 112–€ 187 |
| AC Evaporator | 6.0h | € 270–€ 450 |
| AC Expansion Valve (TXV) | 4.0h | € 180–€ 300 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 2.5h | € 112–€ 187 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.2h | € 54–€ 90 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 3.5h | € 157–€ 262 |
| Power Steering Hose - High Pressure | 1.0h | € 45–€ 75 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.0h | € 45–€ 75 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.0h | € 45–€ 75 |
| Air Suspension Valve Block | 2.0h | € 90–€ 150 |
| Ball Joint - Lower | 1.8h | € 81–€ 135 |
| Ball Joint - Upper | 1.5h | € 67–€ 112 |
| Ball Joints - Upper and Lower | 3.0h | € 135–€ 225 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Kickdown Cable | 0.8h | € 36–€ 60 |
| Neutral Safety Switch | 1.0h | € 45–€ 75 |
| Overdrive Solenoid | 2.0h | € 90–€ 150 |
| Shift Cable | 1.5h | € 67–€ 112 |
| Shift Linkage | 1.0h | € 45–€ 75 |
| Transmission Control Module | 1.0h | € 45–€ 75 |
| Transmission Cooler Lines | 1.0h | € 45–€ 75 |
| Transmission Filter | 1.0h | € 45–€ 75 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
🔧 SCHEDULED MAINTENANCE
Engine Oil And Filter12,000 km / 6 months
Tire Rotation12,000 km / 6 months
Brake System Inspection12,000 km / 6 months
Steering And Suspension Inspection12,000 km / 6 months
Ball Joint And Dust Cover Inspection12,000 km / 6 months
Driveshaft Boots Inspection12,000 km / 6 months
Exhaust System Inspection12,000 km / 6 months
Fuel Lines And Connections Inspection12,000 km / 6 months
📋 RECALLS & TSB (3)
NHTSA 06E026000
Exterior Lighting
Date: 23/03/2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108,…
NHTSA 92V111000
Exterior Lighting › Headlights
Date: 13/07/1992
THERE CAN BE INTERFERENCE WITH THE HEADLAMP HOUSING IF HEADLAMP BULBS ARE REPLACED WITH ANY BRAND OTHER THAN KOITO BRAND BULBS.
NHTSA 08E050000
Exterior Lighting › Headlights
Date: 11/08/2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLE…
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1661
powertrain
MODERATEP1658
powertrain
HIGHP1656
powertrain
MODERATEP1652
powertrain
MODERATEP1604
powertrain
HIGHP1510
powertrain
HIGHP1330
powertrain
HIGHP1315
powertrain
HIGHP1310
powertrain
HIGHP1305
powertrain
HIGHP1200
powertrain
HIGHP1765
powertrain
HIGHP1630
powertrain
HIGHP1512
powertrain
CRITICALP1129
powertrain
HIGHP1780
powertrain
HIGHP1405
powertrain
MODERATEP1150
powertrain
MODERATEP1700
powertrain
HIGHP1565
powertrain
LOW
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
60 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
Master Warning (Toyota)Electrical
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
Pre-Collision System Off (Toyota)ADAS
Lane Departure Alert Off (Toyota)ADAS
Slip Indicator (Toyota)Chassis
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
READY Light (Toyota)Electrical
EV Mode Indicator (Toyota)Electrical
B-Ready (EV Brake) (Toyota)Brakes
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
263 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Toyota Tercel across model years 1990–1998. These are real, verified reports submitted by vehicle owners.
84 crash reports 15 fires 85 injuries 3 deaths
Complaints by model year (most reported first)
Model year 199551
Model year 199345
Model year 199443
Model year 199640
Model year 199224
Model year 199720
Model year 199119
Model year 199018
Most reported components (all years)
Air Bags75
Seat Belts46
Engine And Engine Cooling34
Service Brakes17
Hydraulic15
Visibility15
Sample reports
WHILE TRAVELING AT 65 MPH CONSUMER APPLIED BRAKE WHICH CAUSED WHEELS TO LOCK. BRAKE PEDAL WENT TO FLOOR, AND WOULD NOT RETURN. PROBLEM CAUSED VEHICLE TO REAR END ANOTHER VEHICLE. MANUFACTURER WAS NOTIFIED. PLEASE FEEL FREE TO PROVIDE AN… (MY 1993)
VEHICLE FIRE. *SKD (MY 1991)
SET CAR IN REVERSE AND THE MILEAGE IS ERASED. PLEASE DESCRIBE. *AK (MY 1996)
SEAT BELT DETERIORATED TO THREADS IN THE FRONT SHOULDER BELT AREA. (MY 1992)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 1990–1998.
Frequently Asked Questions
Does the Toyota Tercel have any safety recalls?
Yes — 3 official NHTSA recall campaign(s) affect this model, mainly: EXTERIOR LIGHTING:HEADLIGHTS, EXTERIOR LIGHTING. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Toyota Tercel?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Toyota Tercel?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Toyota Tercel?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are brakes problems common on the Toyota Tercel?
Yes — 21 of 212 real owner reports filed with NHTSA mention the brakes. One owner reported: “IN APRIL 2004, MY TOYOTA TERCEL ACCELERATED FROM 05 TO APPROXIMATELY 90MPH IN A PARKING LOT, CRASHED INTO ANOTHER VEHICLE AND TOTALED MY CAR. ANOTHER PROBLEM WAS THE BRAKE PEDAL. EVEN AFTER CHANGING T…” See the owner-reported complaints section below for more.
Are engine problems common on the Toyota Tercel?
Yes — 26 of 212 real owner reports filed with NHTSA mention the engine. One owner reported: “1990 TOYOTA TERCEL ENGINE BLEW. CONSUMER STATES THAT THE ENGINE BLEW AND HAD ANOTHER ENGINE PUT IN BUT IT DID NOT LAST VERY LONG. *NJ…” See the owner-reported complaints section below for more.
Are airbags problems common on the Toyota Tercel?
Yes — 75 of 212 real owner reports filed with NHTSA mention the airbags. One owner reported: “AIR BAG, DRIVERS SIDE DID NOT DEPLOY DURING REAR-END CAR ACCIDENT. *NM…” See the owner-reported complaints section below for more.
What tyres does the Toyota Tercel (1990–1998) use?
The original OEM tyre size for the Toyota Tercel (1990–1998) is 215/55 R16. Compatible alternative sizes: ["245/45R19", "155/80R13", "185/60R14"]. See the Tyres section on this page to compare offers from the main suppliers.
What is the right battery for the Toyota Tercel (1990–1998)?
The battery specified for the Toyota Tercel (1990–1998) is group 35 (BCI), with a cold cranking rating of 325A. See the Battery section on this page for the main cross-references between brands.
Which OBD2 fault codes are commonly documented for the Toyota Tercel (1990–1998)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Toyota Tercel (1990–1998) be serviced?
Routine maintenance for the Toyota Tercel (1990–1998) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Found what you were looking for? Explore other Toyota models in our database, compare tyre offers in your size, or search a specific fault code in the TroubleAtlas OBD2 database.