TroubleAtlas Score
DAEWOO NUBIRA (1999–2002) Manual — Codes, Tyres & Parts
Built 1999–2002 · all production years covered on this single page
2.0L I4 • Gasoline
2002
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Daewoo Nubira (1999–2002) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair costn/a
Parts & repairability7.3
Maintenance & durabilityn/a
Documentation & supportn/a
Independent · Verified · Never for sale
Every figure on this Daewoo Nubira (1999–2002) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Daewoo Nubira (1999–2002) is powered by a 2.0L I4 engine. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Related codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Related codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Related codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Related codes: P0562
P0011LOW
Check with an OBD2 scanner.
Related codes: P0011
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (12)
NHTSA 02V257000
Service Brakes, Hydraulic › Foundation Components › Hoses, Lines/Piping, And Fittings
Date: 18/09/2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 106, "BRAKE HOSES." A CRACK CAN DEVELOP IN THE OUTER RUBBER LAYER OF THE FRONT BRAKE HOSE(S).
NHTSA 02V257000
Service Brakes, Hydraulic › Foundation Components › Hoses, Lines/Piping, And Fittings
Date: 18/09/2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 106, "BRAKE HOSES." A CRACK CAN DEVELOP IN THE OUTER RUBBER LAYER OF THE FRONT BRAKE HOSE(S).
NHTSA 02V257000
Service Brakes, Hydraulic › Foundation Components › Hoses, Lines/Piping, And Fittings
Date: 18/09/2002
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 106, "BRAKE HOSES." A CRACK CAN DEVELOP IN THE OUTER RUBBER LAYER OF THE FRONT BRAKE HOSE(S).
NHTSA 04V357000
Engine And Engine Cooling
Date: 14/07/2004
ON CERTAIN PASSENGER VEHICLES, THE CAMSHAFT POSITION SENSOR MAY MELT RESULTING IN A BURNING SMELL AND VISIBLE SMOKE, WHICH MAY SUBSEQUENTLY LEAD TO THE MELTING OF THE CAMSHAFT COVER AND THE CAMSHAFT POSITION SENSOR WIRE HARNESS.
NHTSA 04V357000
Engine And Engine Cooling
Date: 14/07/2004
ON CERTAIN PASSENGER VEHICLES, THE CAMSHAFT POSITION SENSOR MAY MELT RESULTING IN A BURNING SMELL AND VISIBLE SMOKE, WHICH MAY SUBSEQUENTLY LEAD TO THE MELTING OF THE CAMSHAFT COVER AND THE CAMSHAFT POSITION SENSOR WIRE HARNESS.
NHTSA 04V357000
Engine And Engine Cooling
Date: 14/07/2004
ON CERTAIN PASSENGER VEHICLES, THE CAMSHAFT POSITION SENSOR MAY MELT RESULTING IN A BURNING SMELL AND VISIBLE SMOKE, WHICH MAY SUBSEQUENTLY LEAD TO THE MELTING OF THE CAMSHAFT COVER AND THE CAMSHAFT POSITION SENSOR WIRE HARNESS.
NHTSA 04V357000
Engine And Engine Cooling
Date: 14/07/2004
ON CERTAIN PASSENGER VEHICLES, THE CAMSHAFT POSITION SENSOR MAY MELT RESULTING IN A BURNING SMELL AND VISIBLE SMOKE, WHICH MAY SUBSEQUENTLY LEAD TO THE MELTING OF THE CAMSHAFT COVER AND THE CAMSHAFT POSITION SENSOR WIRE HARNESS.
NHTSA 04V394000
Engine And Engine Cooling
Date: 06/08/2004
ON CERTAIN PASSENGER VEHICLES, THE CAMSHAFT POSITION SENSOR MAY MELT RESULTING IN A BURNING SMELL AND VISIBLE SMOKE, WHICH MAY SUBSEQUENTLY LEAD TO THE MELTING OF THE CAMSHAFT COVER AND THE CAMSHAFT POSITION SENSOR WIRE HARNESS.
NHTSA 04V394000
Engine And Engine Cooling
Date: 06/08/2004
ON CERTAIN PASSENGER VEHICLES, THE CAMSHAFT POSITION SENSOR MAY MELT RESULTING IN A BURNING SMELL AND VISIBLE SMOKE, WHICH MAY SUBSEQUENTLY LEAD TO THE MELTING OF THE CAMSHAFT COVER AND THE CAMSHAFT POSITION SENSOR WIRE HARNESS.
NHTSA 04V394000
Engine And Engine Cooling
Date: 06/08/2004
ON CERTAIN PASSENGER VEHICLES, THE CAMSHAFT POSITION SENSOR MAY MELT RESULTING IN A BURNING SMELL AND VISIBLE SMOKE, WHICH MAY SUBSEQUENTLY LEAD TO THE MELTING OF THE CAMSHAFT COVER AND THE CAMSHAFT POSITION SENSOR WIRE HARNESS.
NHTSA 04V394000
Engine And Engine Cooling
Date: 06/08/2004
ON CERTAIN PASSENGER VEHICLES, THE CAMSHAFT POSITION SENSOR MAY MELT RESULTING IN A BURNING SMELL AND VISIBLE SMOKE, WHICH MAY SUBSEQUENTLY LEAD TO THE MELTING OF THE CAMSHAFT COVER AND THE CAMSHAFT POSITION SENSOR WIRE HARNESS.
NHTSA R/2002/139
Front Flexible Brake Hoses May Crack
Date: 02-12-2002
It is possible that the outer rubber section of the front brake flexible hoses may crack and in the longer term leak hydraulic fluid.
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P0455
powertrain
LOW⏱ 0.62h avgP0442
powertrain
LOW⏱ 0.62h avgP0440
powertrain
LOW⏱ 0.78h avgP0420
powertrain
MEDIUM⏱ 1.24h avgP0300
powertrain
HIGH⏱ 1.22h avgP0172
powertrain
MEDIUM⏱ 1.13h avgP0171
powertrain
MEDIUM⏱ 0.95h avgP0730
transmission
MEDIUM⏱ 1.25h avgP0700
transmission
HIGH⏱ 1.25h avgP0401
powertrain
MEDIUM⏱ 1.25h avgP0011
powertrain
MEDIUM⏱ 5.4h avgU0100
network
HIGHP0562
electrical
MEDIUM⏱ 0.58h avgP0128
powertrain
MEDIUM⏱ 0.88h avg
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
211 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Daewoo Nubira across model years 1999–2002. These are real, verified reports submitted by vehicle owners.
3 crash reports 4 fires 1 injury 1 death
Complaints by model year (most reported first)
Model year 200160
Model year 200060
Model year 199959
Model year 200232
Most reported components (all years)
Engine And Engine Cooling150
Service Brakes45
Hydraulic44
Suspension13
Electrical System5
Tires3
Sample reports
A RECALL(04V357000) FOR THE CAM SHAFT POSITION SENSOR WAS REPAIRED, HOWEVER THE PROBLEM STILL EXIST. THE DEALER HAS BEEN NOTIFIED, BUT STATES THERE IS NOTHING THEY CAN DO. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB (MY 2000)
CAR QUIT IN MIDST OF DRIVING. I THOUGHT IT STALLED. TOWED TO SHOP TO FIND OUT THE TIMING BELT BROKE. THIS CAR HAD 44813 MILES ON IT WHEN THIS HAPPENED, MECHANIC SAID THIS IS UNHEARD OF AND DUG TO FIND THE REASON. WATER PUMP WAS LEAKI… (MY 1999)
DAEWOO NUBIRA'S BRAKE GOT STUCK AND LOST CONTOL OF THE VEHICLE. EMERGENCY BRAKE WAS FROZEN AND THE CAR DOES NOT GO IN REVERSE. *AK (MY 1999)
THE CONSUMER RECEIVED THE CAMSHAFT SENOR AND THE BRAKE RECALLS. THE DEALER STATED THE VEHICLE WAS NOT INCLUDED PER THE DAEWOO COMPUTER. *JB *NM (MY 2001)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 1999–2002.
Frequently Asked Questions
Does the Daewoo Nubira have any safety recalls?
Yes — 12 official NHTSA recall campaign(s) affect this model, mainly: ENGINE AND ENGINE COOLING, SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Daewoo Nubira?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Daewoo Nubira?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Daewoo Nubira?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are electrical problems common on the Daewoo Nubira?
Yes — 32 of 210 real owner reports filed with NHTSA mention the electrical. One owner reported: “DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON NORMAL ROAD CONDITIONS, THE ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO DETERMINED THE CRANKSHAFT POSITION CENTER ACTIVATED …” See the owner-reported complaints section below for more.
Are engine problems common on the Daewoo Nubira?
Yes — 39 of 210 real owner reports filed with NHTSA mention the engine. One owner reported: “DT*: THE CONTACT STATED THAT PRIOR TO RECEIVING A RECALL LETTER PERTAINING TO THE ENGINE AND ENGINE COOLING: CAMSHAFT CENSOR - CAMPAIGN ID # 04V357000, THE CONTACT HAD THE TIMING BELT REPAIRED ON TW…” See the owner-reported complaints section below for more.
Are brakes problems common on the Daewoo Nubira?
Yes — 43 of 210 real owner reports filed with NHTSA mention the brakes. One owner reported: “DT*: THE CONTACT STATED THAT PRIOR TO RECEIVING A RECALL LETTER PERTAINING TO THE ENGINE AND ENGINE COOLING: CAMSHAFT CENSOR - CAMPAIGN ID # 04V357000, THE CONTACT HAD THE TIMING BELT REPAIRED ON TW…” See the owner-reported complaints section below for more.
Which OBD2 fault codes are commonly documented for the Daewoo Nubira (1999–2002)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Daewoo Nubira (1999–2002) be serviced?
Routine maintenance for the Daewoo Nubira (1999–2002) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
This spec sheet is updated with data verified from OEM sources and shop databases. If you spot an inaccuracy or have additional data on the Daewoo Nubira (1999–2002), let us know — every correction improves quality for all users.