TroubleAtlas Score
MITSUBISHI L200 (1996–2026) Manual — Codes, Tyres & Parts
Built 1996–2026 · all production years covered on this single page
2.4 MPI (128 Hp) 4WD • Petrol (Gasoline)
2026
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Mitsubishi L200 (1996–2026) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair costn/a
Parts & repairability7.8
Maintenance & durabilityn/a
Documentation & supportn/a
Independent · Verified · Never for sale
Every figure on this Mitsubishi L200 (1996–2026) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Mitsubishi L200 (1996–2026) is powered by a 2.4 MPI (128 Hp) 4WD engine. Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Workshops nearby
COMMON PROBLEMS
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Related codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Related codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Related codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Related codes: P0562
P0011LOW
Check with an OBD2 scanner.
Related codes: P0011
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (13)
NHTSA R/2016/251
Airbag May Release Shrapnel If Deployed
Date: 30-11-2016
Certain driver side airbags the inflator might release shrapnel from the inflator container during deployment which could injure the driver.
NHTSA R/2016/155
Indicators And/Or Other Vehicle Lights May Switch Off Or Blink Without Warning
Date: 28-07-2016
Due to poor connectivity the indicators and/or vehicle lights may turn off or blink
NHTSA R/2013/054
Engine May Stall
Date: 28-06-2013
As a result of incorrect mapping of the ECU and/or inappropriate design of the air flow sensor connector low engine performance poor idling or in the worst case engine stalling might be experienced.
NHTSA R/2007/035
Fuel May Leak
Date: 25-05-2007
A crack may occur in the fuel filter water sensor which can lead to a leakage of fuel.
NHTSA R/2010/082
Top Suspension Ball Joint May Become Detached
Date: 18-08-2010
It has been established that is it possible due to misalignment of components that the ball joint mounting bolts may not have been torqued to the correct specification. If the vehicle is used in extreme circumstances this can cause the bolts to loosen and ultimately cause the ba…
NHTSA R/2013/132
In Extreme Cases Fire May Occur
Date: 03-12-2013
Due to an incorrect shape of the power seat reclining lever the switch may get stuck. This causes current to flow through the reclining motor which heats up. In the worst case the cushion from the power seat and surrounding parts may be damaged due to heat generated from the recl…
NHTSA R/2013/133
Fuel May Leak
Date: 03-12-2013
Poor welding may have occurred on the front prop shaft due to a manufacturing equipment failure on the supplier's production line. In the worst case the weld may break and the prop shaft may interfere with and damage the fuel line sufficiently for fuel to leak.
NHTSA R/2013/134
Vehicle May Become Unstable
Date: 03-12-2013
Either side front lower suspension arm can be damaged or broken due to improper welding by the supplier. This could cause the vehicle to pull to either side or can be unstable during driving.
NHTSA R/2013/138
Possible Risk Of Fire
Date: 03-12-2013
It is possible that a poorly soldered joint could cause a high resistance on the Door Entry Guard circuit board. This can cause a risk of fire.
NHTSA R/2004/162
Possibility That The Bonnet Safety Hook Is Defective
Date: 03-12-2004
The possibility exists that the bonnet safety hook (secondary locking device) is defective. With the result that should the primary lock not be fully engaged the safety hook may also fail due to lift created by the airflow and in the worst case the bonnet may open whilst the vehi…
NHTSA R/2008/128
Rear Axle May Become Insecure
Date: 01-12-2008
It has been identified that due to an incorrect manufacturing process the U bolts used to secure the rear axle could break resulting initially in a rattling noise emanating from the rear axle. Should this be symptom be ignored insecurity of the rear axle could result.
NHTSA R/2010/042
Rear Protection Bar May Detach
Date: 01-07-2010
It is possible that cracking can occur in the area of the welds on the mounting bracket to the tube of the rear under protection bar. This in extreme cases if not rectified could result in the detachment of the bar from the vehicle.
NHTSA R/2000/084
Possible Loss Of Steering Control
Date: 01-07-2001
Under severe and extreme conditions where the vehicle is used mainly off-road in a wet muddy environment it is possible that the tapered section of the ball pin on the steering 'Pitman arm' may break. This in the worst case could result in a loss of steering control.
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P0455
powertrain
LOW⏱ 0.62h avgP0442
powertrain
LOW⏱ 0.62h avgP0440
powertrain
LOW⏱ 0.78h avgP0420
powertrain
MEDIUM⏱ 1.24h avgP0300
powertrain
HIGH⏱ 1.22h avgP0172
powertrain
MEDIUM⏱ 1.13h avgP0171
powertrain
MEDIUM⏱ 0.95h avgP0730
transmission
MEDIUM⏱ 1.25h avgP0700
transmission
HIGH⏱ 1.25h avgP0401
powertrain
MEDIUM⏱ 1.25h avgP0011
powertrain
MEDIUM⏱ 5.4h avgU0100
network
HIGHP0562
electrical
MEDIUM⏱ 0.58h avgP0128
powertrain
MEDIUM⏱ 0.88h avg
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
Frequently Asked Questions
What tyres does the Mitsubishi L200 (1996–2026) use?
The original OEM tyre size for the Mitsubishi L200 (1996–2026) is 215/55 R16. Compatible alternative sizes: ["245/60R18", "245/45R19", "245/65R17", "265/70R16", "265/60R18"]. See the Tyres section on this page to compare offers from the main suppliers.
Which OBD2 fault codes are commonly documented for the Mitsubishi L200 (1996–2026)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Mitsubishi L200 (1996–2026) be serviced?
Routine maintenance for the Mitsubishi L200 (1996–2026) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Have a specific fault code on your Mitsubishi L200 (1996–2026)? Search the code in the OBD2 section of this page or use the full TroubleAtlas DTC database. Need tyres? Compare prices and compatible sizes in the TroubleAtlas comparator.