TroubleAtlas Score
CHEVROLET BLAZER-EV (2023–2024) — Verified Specs, Fluids & OBD2
Built 2023–2024 · all production years covered on this single page
Electric Dual Motor AWD • Electric
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Chevrolet Blazer-Ev (2023–2024) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost7.0
Parts & repairability3.1
Maintenance & durabilityn/a
Documentation & supportn/a
Independent · Verified · Never for sale
Every figure on this Chevrolet Blazer-Ev (2023–2024) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
Its battery is group 48 (BCI), rated at 760A cold-cranking amps. It is a fully electric vehicle (Electric Dual Motor AWD). Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Easy
0.8h
€56 – €72
Rear brake pads
Difficulty: Easy
0.9h
€63 – €81
ABS Module
Difficulty: Medium
2.0h
€140 – €180
ABS Pump
Difficulty: Hard
2.5h
€175 – €225
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.5h | € 112–€ 187 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 0.8h | € 36–€ 60 |
| ABS Wheel Speed Sensor - Rear | 0.8h | € 36–€ 60 |
| Brake Bleed - All Four | 1.0h | € 45–€ 75 |
| Brake Booster | 2.5h | € 112–€ 187 |
| Brake Booster Check Valve | 0.3h | € 13–€ 22 |
Cooling6 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Cooling Fan Assembly | 1.0h | € 45–€ 75 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 0.3h | € 13–€ 22 |
| Heater Control Valve | 3.0h | € 135–€ 225 |
| Heater Core | 3.0h | € 135–€ 225 |
| Heater Hoses | 3.0h | € 135–€ 225 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.0h | € 45–€ 75 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 2.0h | € 90–€ 150 |
| Airbag Module/Computer | 1.0h | € 45–€ 75 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
| Backup Camera | 1.0h | € 45–€ 75 |
| Battery | 0.3h | € 13–€ 22 |
Engine1 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Transmission Mount | 1.0h | € 45–€ 75 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.5h | € 67–€ 112 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.5h | € 112–€ 187 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 0.5h | € 22–€ 37 |
| AC Condenser | 2.5h | € 112–€ 187 |
| AC Evaporator | 6.0h | € 270–€ 450 |
| AC Expansion Valve (TXV) | 4.0h | € 180–€ 300 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 2.5h | € 112–€ 187 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.2h | € 54–€ 90 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 3.5h | € 157–€ 262 |
| Power Steering Hose - High Pressure | 1.0h | € 45–€ 75 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.0h | € 45–€ 75 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.0h | € 45–€ 75 |
| Air Suspension Valve Block | 2.0h | € 90–€ 150 |
| Ball Joint - Lower | 1.8h | € 81–€ 135 |
| Ball Joint - Upper | 1.5h | € 67–€ 112 |
| Ball Joints - Upper and Lower | 3.0h | € 135–€ 225 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Neutral Safety Switch | 6.0h | € 270–€ 450 |
| Overdrive Solenoid | 6.0h | € 270–€ 450 |
| Shift Cable | 1.5h | € 67–€ 112 |
| Shift Linkage | 1.0h | € 45–€ 75 |
| Shift Solenoid - Single | 3.6h | € 162–€ 270 |
| Shift Solenoids - All | 7.8h | € 351–€ 585 |
| Transmission Control Module | 6.0h | € 270–€ 450 |
| Transmission Cooler Lines | 1.0h | € 45–€ 75 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (0)
No official recall verified for this vehicle in the NHTSA database.
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
Coolant Thermostat Below Regulating Temperature
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1682
powertrain
HIGHP1638
powertrain
MODERATEP1635
powertrain
HIGHP1625
powertrain
HIGHP1621
powertrain
HIGHP1639
powertrain
HIGHP1637
powertrain
MODERATEP1634
powertrain
HIGHP1633
powertrain
HIGHP1600
powertrain
MODERATEC0445
chassis
HIGHC0441
chassis
CRITICALC0440
chassis
CRITICALC0425
chassis
MODERATEB0009
body
CRITICAL⏱ 1.13h avgU0253
network
CRITICALC0431
chassis
MODERATEU0197
network
LOWU0176
network
HIGHC0435
chassis
LOW
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
74 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Chevrolet Blazer-Ev across model years 2023–2024. These are real, verified reports submitted by vehicle owners.
2 crash reports 25 injuries
Complaints by model year (most reported first)
Model year 202474
Most reported components (all years)
Electrical System20
Forward Collision Avoidance19
Service Brakes15
Visibility/Wiper10
Fuel/Propulsion System8
Unknown Or Other8
Sample reports
The emergency brakes engaging in reverse and while in drive. Not available for inspection as the vehicle is now totaled. It was involved in a rollover accident. I believe the emergency brakes caused the rollover. If the rollover was in… (MY 2024)
I have had the car for 3 weeks and twice it has slammed on the brakes for an instant at slow speed. Both times I was at least 20 feet behind another vehicle travelling at less than 10mph when the brakes locked up for an instant throwing… (MY 2024)
See attached document for complaint. (MY 2024)
Complete brake failure 4 times in the first 450 miles. Can turns on and power brakes and not functioning. Clears after a restart. (MY 2024)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 2023–2024.
Frequently Asked Questions
What does fault code P0071 mean on the Chevrolet Blazer-ev?
Ambient Air Temperature Sensor Range/Performance This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0070 mean on the Chevrolet Blazer-ev?
Ambient Air Temperature Sensor Circuit This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Chevrolet Blazer-ev?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are brakes problems common on the Chevrolet Blazer-ev?
Yes — 26 of 73 real owner reports filed with NHTSA mention the brakes. One owner reported: “The contact owns a 2024 Chevrolet Blazer EV. The contact received notification of NHTSA Campaign Number: 25V433000 (PARKING BRAKE); however, the part to do the recall repair was unavailable. The conta…” See the owner-reported complaints section below for more.
Are electrical problems common on the Chevrolet Blazer-ev?
Yes — 30 of 73 real owner reports filed with NHTSA mention the electrical. One owner reported: “This vehicle experiences multiple recurring safety-critical system failures while driving, creating a dangerous operating condition for both the driver and the public. 1. Dashboard / Instrument Clust…” See the owner-reported complaints section below for more.
What tyres does the Chevrolet Blazer-Ev (2023–2024) use?
The original OEM tyre size for the Chevrolet Blazer-Ev (2023–2024) is 215/55 R16. Compatible alternative sizes: ["255/60R19", "245/45R19", "275/45R21", "265/50R20", "275/40R22"]. See the Tyres section on this page to compare offers from the main suppliers.
What is the right battery for the Chevrolet Blazer-Ev (2023–2024)?
The battery specified for the Chevrolet Blazer-Ev (2023–2024) is group 48 (BCI), with a cold cranking rating of 760A. See the Battery section on this page for the main cross-references between brands.
Which OBD2 fault codes are commonly documented for the Chevrolet Blazer-Ev (2023–2024)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Chevrolet Blazer-Ev (2023–2024) be serviced?
Routine maintenance for the Chevrolet Blazer-Ev (2023–2024) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Considering buying a Chevrolet Blazer-Ev (2023–2024)? Use this guide to check expected maintenance costs, the most reported fault codes and parts availability on the market. Real data, zero commercial estimates.