TroubleAtlas Score
CHEVROLET VENTURE (1997–2005) — Technical Guide, Fault Codes & Maintenance
Built 1997–2005 · all production years covered on this single page
3.4L V6 • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Chevrolet Venture (1997–2005) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost8.6
Parts & repairability4.7
Maintenance & durabilityn/a
Documentation & support9.2
Independent · Verified · Never for sale
Every figure on this Chevrolet Venture (1997–2005) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Chevrolet Venture (1997–2005) uses ACDelco dexos1 5W-30 engine oil. Its battery is group 75 (BCI), rated at 630A cold-cranking amps. It is powered by a 3.4L V6 engine. Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Medium
1.2h
€84 – €108
Rear brake pads
Difficulty: Medium
1.2h
€84 – €108
Engine oil change
Difficulty: Easy
0.5h
€35 – €45
ABS Module
Difficulty: Hard
2.4h
€168 – €216
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.4h | € 108–€ 180 |
| ABS Pump | 2.4h | € 108–€ 180 |
| ABS Tone Ring | 1.8h | € 81–€ 135 |
| ABS Wheel Speed Sensor - Front | 1.8h | € 81–€ 135 |
| ABS Wheel Speed Sensor - Rear | 1.8h | € 81–€ 135 |
| Brake Bleed - All Four | 1.8h | € 81–€ 135 |
| Brake Booster | 3.6h | € 162–€ 270 |
| Brake Booster Check Valve | 1.2h | € 54–€ 90 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.8h | € 81–€ 135 |
| Coolant Flush | 0.8h | € 36–€ 60 |
| Coolant Reservoir | 1.8h | € 81–€ 135 |
| Coolant Temperature Sensor | 1.2h | € 54–€ 90 |
| Cooling Fan Assembly | 1.8h | € 81–€ 135 |
| Cooling Fan Motor | 1.8h | € 81–€ 135 |
| Cooling Fan Relay | 1.2h | € 54–€ 90 |
| Engine Oil Cooler | 1.8h | € 81–€ 135 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.8h | € 81–€ 135 |
| Airbag - Passenger | 1.8h | € 81–€ 135 |
| Airbag - Side | 1.8h | € 81–€ 135 |
| Airbag Module/Computer | 1.8h | € 81–€ 135 |
| Alternator | 2.4h | € 108–€ 180 |
| Alternator Belt | 1.8h | € 81–€ 135 |
| Amplifier | 1.8h | € 81–€ 135 |
| Antenna | 0.6h | € 27–€ 45 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Camshaft Position Sensor | 1.8h | € 81–€ 135 |
| Camshaft R&R | 5.4h | € 243–€ 405 |
| Connecting Rod Bearings | 1.8h | € 81–€ 135 |
| Crankshaft Position Sensor | 1.8h | € 81–€ 135 |
| Crankshaft R&R | 1.8h | € 81–€ 135 |
| Cylinder Head R&R | 5.4h | € 243–€ 405 |
| Cylinder Head Resurface | 5.4h | € 243–€ 405 |
| Engine Mount - Front | 3.6h | € 162–€ 270 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 1.8h | € 81–€ 135 |
| Catalytic Converter - California | 2.4h | € 108–€ 180 |
| Catalytic Converter - Direct Fit | 2.4h | € 108–€ 180 |
| Catalytic Converter - Universal | 2.4h | € 108–€ 180 |
| Downpipe | 2.4h | € 108–€ 180 |
| EGR Cooler | 1.8h | € 81–€ 135 |
| EGR Tube | 1.8h | € 81–€ 135 |
| EGR Valve | 1.8h | € 81–€ 135 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.8h | € 81–€ 135 |
| EVAP Purge Valve | 1.8h | € 81–€ 135 |
| EVAP Vent Valve | 1.8h | € 81–€ 135 |
| Fuel Cap | 0.4h | € 18–€ 30 |
| Fuel Filler Neck | 3.6h | € 162–€ 270 |
| Fuel Filter | 1.2h | € 54–€ 90 |
| Fuel Filter - In-Tank | 1.2h | € 54–€ 90 |
| Fuel Injector - Single | 3.6h | € 162–€ 270 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 2.4h | € 108–€ 180 |
| AC Clutch Coil | 1.8h | € 81–€ 135 |
| AC Compressor | 2.4h | € 108–€ 180 |
| AC Compressor Clutch | 2.4h | € 108–€ 180 |
| AC Compressor Oil Add | 2.4h | € 108–€ 180 |
| AC Condenser | 2.4h | € 108–€ 180 |
| AC Evaporator | 2.4h | € 108–€ 180 |
| AC Expansion Valve (TXV) | 2.4h | € 108–€ 180 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.8h | € 81–€ 135 |
| Electric Power Steering Module | 1.8h | € 81–€ 135 |
| Electric Power Steering Motor | 1.8h | € 81–€ 135 |
| Idler Arm | 1.2h | € 54–€ 90 |
| Pitman Arm | 1.8h | € 81–€ 135 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 2.4h | € 108–€ 180 |
| Power Steering Hose - High Pressure | 1.8h | € 81–€ 135 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.8h | € 81–€ 135 |
| Air Spring/Air Bag | 1.8h | € 81–€ 135 |
| Air Suspension Compressor | 1.8h | € 81–€ 135 |
| Air Suspension Height Sensor | 1.8h | € 81–€ 135 |
| Air Suspension Valve Block | 1.8h | € 81–€ 135 |
| Ball Joint - Lower | 2.4h | € 108–€ 180 |
| Ball Joint - Upper | 2.4h | € 108–€ 180 |
| Ball Joints - Upper and Lower | 2.4h | € 108–€ 180 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Clutch Cable | 1.8h | € 81–€ 135 |
| Clutch Disc | 1.8h | € 81–€ 135 |
| Clutch Kit | 5.4h | € 243–€ 405 |
| Clutch Master Cylinder | 2.4h | € 108–€ 180 |
| Clutch Slave Cylinder | 2.4h | € 108–€ 180 |
| Flywheel Resurface | 5.4h | € 243–€ 405 |
| Kickdown Cable | 1.8h | € 81–€ 135 |
| Neutral Safety Switch | 1.8h | € 81–€ 135 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (21)
NHTSA 99V268000
Fuel System, Gasoline › Delivery › Hoses, Lines/Piping, And Fittings
Date: 29/09/1999
VEHICLE DESCRIPTION: MINI VANS WITH EXTENDED WHEELBASE. SOME OF THESE VEHICLES HAVE INOPERATIVE FUEL TANK ROLLOVER VALVES AND FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN A ROLLOVER TEST. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRIT…
NHTSA 98V145000
Seats › Front Assembly › Recliner
Date: 26/06/1998
VEHICLE DESCRIPTION: PASSENGER MINI VANS EQUIPPED WITH BUCKET SEATS OR A SPLIT BENCH SEAT IN THE SECOND (MIDDLE) OR THIRD (BACK) ROW. THE SEAT LATCH MECHANISMS ON BUCKET SEATS AND ON THE 40% PORTION OF THE SPLIT BENCH SEAT IN THE SECOND AND THIRD ROWS DO NOT HAVE PROTECTIVE COV…
NHTSA 04V597000
Latches/Locks/Linkages › Doors › Latch
Date: 22/12/2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
NHTSA 01V264000
Latches/Locks/Linkages › Doors › Latch
Date: 21/08/2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTAN…
NHTSA 09E005000
Steering
Date: 17/02/2009
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONSTM" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DE…
NHTSA 03V250000
Equipment › Other › Owners/Service/Other Manual
Date: 15/07/2003
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER…
NHTSA 03V051000
Air Bags › Frontal › Driver Side › Inflator Module
Date: 14/02/2003
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
NHTSA 01V383000
Seats › Front Assembly › Recliner
Date: 13/12/2001
VEHICLE DESCRIPTION: CERTAIN MINI VANS BUILT WITH SECOND ROW 50/50 SPLIT BENCH SEATS OR CAPTAIN'S CHAIRS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SEAT LATCH ANCHOR WIRE DIAMETER IS GREATER THAN 6.1 MM.
NHTSA 99V071000
Steering › Gear Box › Shaft Sector
Date: 12/04/1999
VEHICLE DESCRIPTION: PASSENGER MINI VANS. THE LEFT AND/OR RIGHT FRONT LOWER INSULATOR TO CRADLE CENTER METAL SLEEVE IS COLLAPSED, WHICH CAN RESULT IN LOSS OF CLAMP LOAD IN THE JOINT. IF THE CLAMP LOAD IS REDUCED OR LOST, THE BOLT CAN BE LOST OR BROKEN AND THE JOINT CAN SEPARATE…
NHTSA 07E021000
Fuel System, Other › Storage › Tank Assembly › Pressure Relief Devices
Date: 12/03/2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
NHTSA 08E050000
Exterior Lighting › Headlights
Date: 11/08/2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLE…
NHTSA 98V131000
Power Train › Automatic Transmission
Date: 11/06/1998
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES MAY HAVE (1) A BROKEN SHIFT CABLE FITTING OR (2) LOOSE SHIFT LINKAGE. CONSEQUENTLY, MOVING THE SHIFT LEVER TO A 'PARK' POSITION MAY NOT SHIFT THE TRANSMISSION TO 'PARK'.
NHTSA 02V329000
Air Bags › Frontal
Date: 09/12/2002
ON CERTAIN PASSENGER, SPORT UTILITY VEHICLES AND MINI VANS, SOME OF THESE VEHICLES HAVE A PASSENGER AIR BAG THAT WAS MANUFACTURED WITHOUT A CHECK VALVE PIN. AN AIR BAG WITHOUT THE CHECK VALVE PIN COULD PRODUCE INCREASED PRESSURE AT THE ONSET OF THE AIR BAG DEPLOYMENT AND REDUCED…
NHTSA 02V222000
Air Bags › Frontal
Date: 09/08/2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
NHTSA 07V349000
Fuel System, Gasoline › Storage
Date: 08/08/2007
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV).
NHTSA 04V177000
Equipment › Other › Labels
Date: 08/04/2004
CERTAIN MINIVANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 213, "CHILD RESTRAINT SYSTEMS." THESE VEHICLES DO NOT HAVE TEXT AND FORMATTING ON THE WARNING LABEL ATTACHED TO THE AVAILABLE SECOND-ROW INTEGRAL CHILD RESTRAINT AS SPECIFIED BY AME…
NHTSA 01V067000
Latches/Locks/Linkages › Doors › Latch
Date: 08/03/2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER …
NHTSA 00V228003
Seat Belts
Date: 07/08/2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT O…
NHTSA 98V072000
Visibility › Windshield Wiper/Washer › Linkages
Date: 07/04/1998
VEHICLE DESCRIPTION: PASSENGER MINI VANS EQUIPPED WITH TRACTION CONTROL SYSTEMS. THE WINDSHIELD WIPER LINKAGE ARM CAN CONTACT A BRAKE LINE WHICH IS CONNECTED TO THE TRACTION CONTROL SYSTEM MODULATOR VALVE. THIS CONTACT CAN CHAFE THE BRAKE LINE RESULTING IN A BRAKE FLUID LEAK.
NHTSA 02V286000
Steering › Rack And Pinion
Date: 04/11/2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND…
NHTSA 01V026000
Air Bags › Frontal
Date: 01/02/2001
VEHICLE DESCRIPTION: PASSENGER, SPORT UTILITY VEHICLES AND MINIVANS. THE PASSENGER AIR BAG INFLATOR MODULES WERE BUILT WITHOUT THE CORRECT AMOUNT OF GENERANT, WHICH PRODUCES THE GAS THAT FILLS THE AIR BAG. SOME WERE BUILT WITH A DOUBLE LOAD OF GENERANT AND SOME WERE BUILT WITH…
COMMON OBD2 CODES TO CHECK
P0420
Catalyst System Efficiency Below Threshold Bank 1
Powertrain
P0171
System Too Lean Bank 1
Powertrain
P0300
Random/Multiple Cylinder Misfire Detected
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
Coolant Thermostat Below Regulating Temperature
Powertrain
P0455
EVAP System Leak Detected (Gross Leak)
Powertrain
P0700
Transmission Control System (MIL Request)
Powertrain
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1014
powertrain
MODERATEP1012
powertrain
MODERATEP1011
powertrain
MODERATEP1516
powertrain
HIGHP1811
powertrain
HIGHP1884
powertrain
LOWP1875
powertrain
MODERATEP1870
powertrain
HIGHP1860
powertrain
MODERATEP1812
powertrain
CRITICALP1810
powertrain
HIGHP1632
powertrain
HIGHP1629
powertrain
HIGHP1626
powertrain
HIGHP1599
powertrain
MODERATEP1554
powertrain
MODERATEP1517
powertrain
HIGHP1515
powertrain
HIGHP1514
powertrain
HIGHP1483
powertrain
HIGH
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
2332 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Chevrolet Venture across model years 1997–2005. These are real, verified reports submitted by vehicle owners.
143 crash reports 37 fires 256 injuries 10 deaths
Complaints by model year (most reported first)
Model year 1997432
Model year 1998409
Model year 2000350
Model year 1999349
Model year 2001221
Model year 2002220
Model year 2003185
Model year 2004124
Most reported components (all years)
Engine And Engine Cooling494
Structure245
Electrical System233
Exterior Lighting222
Service Brakes175
Fuel System175
Sample reports
SYLVANIA BULB IN THE REAR BRAKE LIGHT SOCKET ON PASSENGER SIDE FAILED. WHEN I WENT TO REPLACE THE BULB I FOUND THE BULB AND SOCKET HAD MELTED. REPLACED THE BULB INTO THE BURNT SOCKET AND IT IS NOW WORKING. MY CONCERN IS THAT NO FUSE BLEW… (MY 2002)
FIRESTONE TIRES FR680, 215/70R15. REPLACED THE TIRES ON THE FRONT OF MY VEHICLE AT 25,000 MILES DUE TO SEVERE FLAT SPOTTING & STEEL CHORDS SHOWING. REAR TIRES FINE. CHEVY DEALER CONFIRMED NO WHEEL ALIGNMENT ISSUES EXIST. THE TIRES AR… (MY 2003)
ON MY 1997 CHEVY VENTURE THE MANIFOLD GASKET IS LEAKING! AND I DON'T HAVE THAT KIND OF MONEY TO FIX THAT IT, BECAUSE OF GM POOR ENGINEERING. THERE ARE THOUSANDS OF COMPLAINTS ONLINE ABOUT THIS DEFECT AND NO ONE SEEMS TO BE DOING ANYTHING… (MY 1997)
LEAKING HEAD GASKET ON MY 1999 CHEVY VENTURE WITH LOW COOLANT LIGHT COMING ON FREQUENTLY THE VAN HAS ABOUT 70000. TS (MY 1999)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 1997–2005.
Frequently Asked Questions
Does the Chevrolet Venture have any safety recalls?
Yes — 21 official NHTSA recall campaign(s) affect this model, mainly: STEERING, EXTERIOR LIGHTING:HEADLIGHTS, LATCHES/LOCKS/LINKAGES:DOORS:LATCH. Check the recalls section for your exact year/VIN.
What does fault code P0003 mean on the Chevrolet Venture?
Fuel Volume Regulator Control Circuit Low This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0002 mean on the Chevrolet Venture?
Fuel Volume Regulator Control Circuit Range/Performance This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0001 mean on the Chevrolet Venture?
Fuel Volume Regulator Control Circuit/Open This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are brakes problems common on the Chevrolet Venture?
Yes — 303 of 2207 real owner reports filed with NHTSA mention the brakes. One owner reported: “REAR BRAKE LAMPS KEEP FAILING, LIGHT BAR ON TOP WORKS FINE BUT BOTH SIDE REAR BRAKE LAMPS FAIL CONTINUOUSLY. UPON DISASSEMBLY OF BRAKE LIGHT ONE CAN SEE THE SOCKETS AND BULB CONTACTS ARE MELTING. THIS…” See the owner-reported complaints section below for more.
Are engine problems common on the Chevrolet Venture?
Yes — 401 of 2207 real owner reports filed with NHTSA mention the engine. One owner reported: “TL* THE CONTACT OWNS A 1997 CHEVROLET VENTURE. WITHIN LESS THAN 30 DAYS OF OWNING THE VEHICLE, THE SERVICE ENGINE LIGHT AND THE COOLANT LIGHT RANDOMLY KEPT ILLUMINATING. THE CONTACT STATED THAT THE VE…” See the owner-reported complaints section below for more.
Are electrical problems common on the Chevrolet Venture?
Yes — 533 of 2207 real owner reports filed with NHTSA mention the electrical. One owner reported: “TL* THE CONTACT OWNS A 1997 CHEVROLET VENTURE. WITHIN LESS THAN 30 DAYS OF OWNING THE VEHICLE, THE SERVICE ENGINE LIGHT AND THE COOLANT LIGHT RANDOMLY KEPT ILLUMINATING. THE CONTACT STATED THAT THE VE…” See the owner-reported complaints section below for more.
What tyres does the Chevrolet Venture (1997–2005) use?
The original OEM tyre size for the Chevrolet Venture (1997–2005) is 215/55 R16. Compatible alternative sizes: ["245/45R19", "225/60R16", "215/70R15"]. See the Tyres section on this page to compare offers from the main suppliers.
What is the right battery for the Chevrolet Venture (1997–2005)?
The battery specified for the Chevrolet Venture (1997–2005) is group 75 (BCI), with a cold cranking rating of 630A. See the Battery section on this page for the main cross-references between brands.
What engine oil should I use on the Chevrolet Venture (1997–2005)?
The engine oil specification for the Chevrolet Venture (1997–2005) is ACDelco dexos1 5W-30. Always use the viscosity grade approved by the manufacturer: a different oil can reduce engine protection and void the warranty. Check the change interval in the Maintenance section.
Which OBD2 fault codes are commonly documented for the Chevrolet Venture (1997–2005)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Chevrolet Venture (1997–2005) be serviced?
Routine maintenance for the Chevrolet Venture (1997–2005) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Have a specific fault code on your Chevrolet Venture (1997–2005)? Search the code in the OBD2 section of this page or use the full TroubleAtlas DTC database. Need tyres? Compare prices and compatible sizes in the TroubleAtlas comparator.