TroubleAtlas Score
DODGE DAYTONA (1990–1993) Manual — Codes, Tyres & Parts
Built 1990–1993 · all production years covered on this single page
3.0L V6 • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Dodge Daytona (1990–1993) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost9.2
Parts & repairability7.3
Maintenance & durabilityn/a
Documentation & support4.2
Independent · Verified · Never for sale
Every figure on this Dodge Daytona (1990–1993) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Dodge Daytona (1990–1993) uses Mopar 5W-20 Synthetic Blend engine oil. Its battery is group 34 (BCI), rated at 600A cold-cranking amps. It is powered by a 3.0L V6 engine. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Related codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Related codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Related codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Related codes: P0562
P0011LOW
Check with an OBD2 scanner.
Related codes: P0011
COMMON REPAIRS
Front brake pads
Difficulty: Medium
1.2h
€84 – €108
Rear brake pads
Difficulty: Medium
1.2h
€84 – €108
Engine oil change
Difficulty: Easy
0.5h
€35 – €45
ABS Module
Difficulty: Medium
2.0h
€140 – €180
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.0h | € 90–€ 150 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Rear | 1.5h | € 67–€ 112 |
| Brake Bleed - All Four | 1.5h | € 67–€ 112 |
| Brake Booster | 3.0h | € 135–€ 225 |
| Brake Booster Check Valve | 1.0h | € 45–€ 75 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.5h | € 67–€ 112 |
| Coolant Flush | 0.8h | € 36–€ 60 |
| Coolant Reservoir | 1.5h | € 67–€ 112 |
| Coolant Temperature Sensor | 1.0h | € 45–€ 75 |
| Cooling Fan Assembly | 1.5h | € 67–€ 112 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 1.0h | € 45–€ 75 |
| Engine Oil Cooler | 1.5h | € 67–€ 112 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.5h | € 67–€ 112 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 1.5h | € 67–€ 112 |
| Airbag Module/Computer | 1.5h | € 67–€ 112 |
| Alternator | 2.0h | € 90–€ 150 |
| Alternator Belt | 1.5h | € 67–€ 112 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Camshaft Position Sensor | 1.5h | € 67–€ 112 |
| Camshaft R&R | 4.5h | € 202–€ 337 |
| Connecting Rod Bearings | 1.5h | € 67–€ 112 |
| Crankshaft Position Sensor | 1.5h | € 67–€ 112 |
| Crankshaft R&R | 1.5h | € 67–€ 112 |
| Cylinder Head R&R | 4.5h | € 202–€ 337 |
| Cylinder Head Resurface | 4.5h | € 202–€ 337 |
| Engine Mount - Front | 3.0h | € 135–€ 225 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 1.5h | € 67–€ 112 |
| Catalytic Converter - California | 2.0h | € 90–€ 150 |
| Catalytic Converter - Direct Fit | 2.0h | € 90–€ 150 |
| Catalytic Converter - Universal | 2.0h | € 90–€ 150 |
| Downpipe | 2.0h | € 90–€ 150 |
| EGR Cooler | 1.5h | € 67–€ 112 |
| EGR Tube | 1.5h | € 67–€ 112 |
| EGR Valve | 1.5h | € 67–€ 112 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.5h | € 67–€ 112 |
| EVAP Purge Valve | 1.5h | € 67–€ 112 |
| EVAP Vent Valve | 1.5h | € 67–€ 112 |
| Fuel Cap | 0.3h | € 13–€ 22 |
| Fuel Filler Neck | 3.0h | € 135–€ 225 |
| Fuel Filter | 1.0h | € 45–€ 75 |
| Fuel Filter - In-Tank | 1.0h | € 45–€ 75 |
| Fuel Injector - Single | 3.0h | € 135–€ 225 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 2.0h | € 90–€ 150 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.0h | € 90–€ 150 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 2.0h | € 90–€ 150 |
| AC Condenser | 2.0h | € 90–€ 150 |
| AC Evaporator | 2.0h | € 90–€ 150 |
| AC Expansion Valve (TXV) | 2.0h | € 90–€ 150 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 1.5h | € 67–€ 112 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.5h | € 67–€ 112 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 2.0h | € 90–€ 150 |
| Power Steering Hose - High Pressure | 1.5h | € 67–€ 112 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.5h | € 67–€ 112 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.5h | € 67–€ 112 |
| Air Suspension Valve Block | 1.5h | € 67–€ 112 |
| Ball Joint - Lower | 2.0h | € 90–€ 150 |
| Ball Joint - Upper | 2.0h | € 90–€ 150 |
| Ball Joints - Upper and Lower | 2.0h | € 90–€ 150 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Clutch Cable | 1.5h | € 67–€ 112 |
| Clutch Disc | 1.5h | € 67–€ 112 |
| Clutch Kit | 4.5h | € 202–€ 337 |
| Clutch Master Cylinder | 2.0h | € 90–€ 150 |
| Clutch Slave Cylinder | 2.0h | € 90–€ 150 |
| Flywheel Resurface | 4.5h | € 202–€ 337 |
| Kickdown Cable | 1.5h | € 67–€ 112 |
| Neutral Safety Switch | 1.5h | € 67–€ 112 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (9)
NHTSA 89V237000
Engine And Engine Cooling › Engine
Date: 27/12/1989
THE ENGINE VALVE COVER GASKET MAY DISLOCATE AND ALLOW AN ENGINE OIL LEAK AT THE GASKET.
NHTSA 90V080000
Air Bags › Frontal › Sensor/Control Module-Inactive
Date: 25/04/1990
AIR BAG INFLATOR MODULES MAY NOT CONTAIN DIFFUSER HOLES BETWEEN THE IGNITOR AND PROPELLANT CHAMBERS.
NHTSA 91V078000
Parking Brake › Conventional › Mechanical › Linkage And Cable
Date: 14/05/1991
MISMATCHED PARKING BRAKE CABLE LENGTHS TO THE REAR WHEELS REDUCES BRAKING ABILITY OF ONE OF THE REAR WHEELS, IN VIOLATION OF FMVSS 105.
NHTSA 08E033000
Suspension
Date: 14/04/2008
FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FO…
NHTSA 92V015000
Steering › Steering Wheel/Handle Bar
Date: 14/02/1992
THE ZINC PLATING OPERATION PERFORMED ON THE UPPER STEERING COLUMN SHAFT COUPLING BOLT CAUSED HYDROGEN EMBRITTLEMENT AND BREAKAGE OF THE BOLT.
NHTSA 93V114000
Structure › Frame And Members
Date: 12/07/1993
THE WELDING ATTACHMENTS OF THE FRONT FRAME RAILS TO THE FLOOR PAN SHEET METAL MAY NOT BE PROPERLY WELDED.
NHTSA 92V016000
Structure › Body › Door
Date: 11/02/1992
THE OWNER'S MANUAL INCORRECTLY STATES THAT THE FRONT PASSENGER DOOR CANNOT BE OPENED FROM THE INSIDE IF THE DOOR IS LOCKED UNTIL THE LOCK CONTROL HANDLE HAS BEEN PULLED UP. ON THESE VEHICLES, THE FRONT PASSENGER DOOR CAN BE OPENED BY THE INSIDE DOOR HANDLE EVEN IF THE DOOR IS LOC…
NHTSA 90V169000
Equipment › Other › Labels
Date: 04/09/1990
INCORRECT TIRE PRESSURE PLACARD WAS INSTALLED ON CARS; DOES NOT COMPLY WITH FMVSS 110.
NHTSA 90V162000
Service Brakes, Hydraulic › Foundation Components › Disc › Caliper
Date: 04/09/1990
FRONT DISC BRAKE CALIPER GUIDE PIN BOLTS MAY NOT HAVE BEEN ADEQUATELY TORQUED AND COULD LOOSEN.
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P0455
powertrain
LOW⏱ 0.62h avgP0442
powertrain
LOW⏱ 0.62h avgP0440
powertrain
LOW⏱ 0.78h avgP0420
powertrain
MEDIUM⏱ 1.24h avgP0300
powertrain
HIGH⏱ 1.22h avgP0172
powertrain
MEDIUM⏱ 1.13h avgP0171
powertrain
MEDIUM⏱ 0.95h avgP0730
transmission
MEDIUM⏱ 1.25h avgP0700
transmission
HIGH⏱ 1.25h avgP0401
powertrain
MEDIUM⏱ 1.25h avgP0011
powertrain
MEDIUM⏱ 5.4h avgU0100
network
HIGHP0562
electrical
MEDIUM⏱ 0.58h avgP0128
powertrain
MEDIUM⏱ 0.88h avg
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
72 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Dodge Daytona across model years 1990–1993. These are real, verified reports submitted by vehicle owners.
9 crash reports 6 fires 9 injuries 2 deaths
Complaints by model year (most reported first)
Model year 199026
Model year 199217
Model year 199316
Model year 199113
Most reported components (all years)
Engine And Engine Cooling11
Structure11
Power Train9
Seats9
Electrical System5
Air Bags5
Sample reports
PAINT STARTED TO BLISTER AND PEEL OFF THE BODY OF VEHICLE. *AK (MY 1992)
DRIVER AND PASSENGER SIDE DOOR LATCH DOESN'T WORK . TT (MY 1990)
DRIVERS SIDE SEAT BROKE WHILE DRIVING. TT *JB (MY 1991)
WHEN REAR SEAT WAS OCCUPIED, TIRES WOULD RUB FENDERS. TT (MY 1992)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 1990–1993.
Frequently Asked Questions
Does the Dodge Daytona have any safety recalls?
Yes — 9 official NHTSA recall campaign(s) affect this model, mainly: SUSPENSION, AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE, ENGINE AND ENGINE COOLING:ENGINE. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Dodge Daytona?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Dodge Daytona?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Dodge Daytona?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are electrical problems common on the Dodge Daytona?
Yes — 6 of 52 real owner reports filed with NHTSA mention the electrical. One owner reported: “MANUFACTURERS DIAGRAMS SHOW THE THERMAL FLASHER LOCATED WITH THE FUSES ON THE LOWER DRIVER'S SIDE OF THE DASHBOARD. IT IS NOT THERE. I HAVE EMAILED DODGE REQUESTING INFORMATION ON WHERE IT IS PLACED…” See the owner-reported complaints section below for more.
Are transmission problems common on the Dodge Daytona?
Yes — 6 of 52 real owner reports filed with NHTSA mention the transmission. One owner reported: “THIS TRANSMISSION WAS A DEFECTIVE AND WAS REPLACED AT 14,000 MILES. THE REPLACEMENT TRANSMISSION WAS REPLACED AT 90,000 MILES AT MY COAST (1400.00 DOLLARS) THIS WAS THE SAME TRANS.(THE 41T) THAT CHRYS…” See the owner-reported complaints section below for more.
Are engine problems common on the Dodge Daytona?
Yes — 8 of 52 real owner reports filed with NHTSA mention the engine. One owner reported: “WHEN STARTING VEHICLE CONSUMER NOTICED SMOKE COMING FROM IGNITION AND VEHICLE SUDDENLY CAUGHT ON FIRE IN ENGINE COMPARTMENT. CAUSE OF THE FIRE HAS YET TO BE DETERMINED. PLEASE PROVIDE ANY FURTHER D…” See the owner-reported complaints section below for more.
What is the right battery for the Dodge Daytona (1990–1993)?
The battery specified for the Dodge Daytona (1990–1993) is group 34 (BCI), with a cold cranking rating of 600A. See the Battery section on this page for the main cross-references between brands.
What engine oil should I use on the Dodge Daytona (1990–1993)?
The engine oil specification for the Dodge Daytona (1990–1993) is Mopar 5W-20 Synthetic Blend. Always use the viscosity grade approved by the manufacturer: a different oil can reduce engine protection and void the warranty. Check the change interval in the Maintenance section.
Which OBD2 fault codes are commonly documented for the Dodge Daytona (1990–1993)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Dodge Daytona (1990–1993) be serviced?
Routine maintenance for the Dodge Daytona (1990–1993) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
This spec sheet is updated with data verified from OEM sources and shop databases. If you spot an inaccuracy or have additional data on the Dodge Daytona (1990–1993), let us know — every correction improves quality for all users.