TroubleAtlas Score
FORD E-150 (1990–2014) Manual — Codes, Tyres & Parts
Built 1990–2014 · all production years covered on this single page
5.4L V8 Triton • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Ford E-150 (1990–2014) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost5.5
Parts & repairability4.6
Maintenance & durability6.6
Documentation & support3.6
Independent · Verified · Never for sale
Every figure on this Ford E-150 (1990–2014) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Ford E-150 (1990–2014) uses Motorcraft 5W-20 Synthetic Blend engine oil. Its battery is group 65 (BCI), rated at 750A cold-cranking amps. It is powered by a 5.4L V8 Triton engine. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Scheduled maintenance
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Easy
0.8h
€56 – €72
Rear brake pads
Difficulty: Easy
0.9h
€63 – €81
Engine oil change
Difficulty: Easy
0.3h
€21 – €27
ABS Module
Difficulty: Medium
2.0h
€140 – €180
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.5h | € 112–€ 187 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 0.8h | € 36–€ 60 |
| ABS Wheel Speed Sensor - Rear | 0.8h | € 36–€ 60 |
| Brake Bleed - All Four | 1.0h | € 45–€ 75 |
| Brake Booster | 2.5h | € 112–€ 187 |
| Brake Booster Check Valve | 0.3h | € 13–€ 22 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.5h | € 67–€ 112 |
| Coolant Flush | 1.0h | € 45–€ 75 |
| Coolant Reservoir | 0.5h | € 22–€ 37 |
| Coolant Temperature Sensor | 0.5h | € 22–€ 37 |
| Cooling Fan Assembly | 1.0h | € 45–€ 75 |
| Cooling Fan Clutch | 1.0h | € 45–€ 75 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 0.3h | € 13–€ 22 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.0h | € 45–€ 75 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 2.0h | € 90–€ 150 |
| Airbag Module/Computer | 1.0h | € 45–€ 75 |
| Alternator | 1.5h | € 67–€ 112 |
| Alternator Belt | 0.5h | € 22–€ 37 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Camshaft Position Sensor | 1.0h | € 45–€ 75 |
| Camshaft R&R | 8.0h | € 360–€ 600 |
| Connecting Rod Bearings | 15.0h | € 675–€ 1125 |
| Crankshaft Position Sensor | 1.0h | € 45–€ 75 |
| Crankshaft R&R | 20.0h | € 900–€ 1500 |
| Cylinder Head R&R | 6.0h | € 270–€ 450 |
| Cylinder Head Resurface | 8.0h | € 360–€ 600 |
| Engine Mount - Front | 1.5h | € 67–€ 112 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 0.8h | € 36–€ 60 |
| Catalytic Converter - California | 1.5h | € 67–€ 112 |
| Catalytic Converter - Direct Fit | 1.5h | € 67–€ 112 |
| Catalytic Converter - Universal | 2.0h | € 90–€ 150 |
| Downpipe | 2.0h | € 90–€ 150 |
| EGR Cooler | 3.0h | € 135–€ 225 |
| EGR Tube | 1.5h | € 67–€ 112 |
| EGR Valve | 1.0h | € 45–€ 75 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.0h | € 45–€ 75 |
| EVAP Purge Valve | 0.8h | € 36–€ 60 |
| EVAP Vent Valve | 0.8h | € 36–€ 60 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 1.5h | € 67–€ 112 |
| Fuel Filter | 0.5h | € 22–€ 37 |
| Fuel Filter - In-Tank | 2.0h | € 90–€ 150 |
| Fuel Injector - Single | 1.0h | € 45–€ 75 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.5h | € 67–€ 112 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.5h | € 112–€ 187 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 0.5h | € 22–€ 37 |
| AC Condenser | 2.5h | € 112–€ 187 |
| AC Evaporator | 6.0h | € 270–€ 450 |
| AC Expansion Valve (TXV) | 4.0h | € 180–€ 300 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 2.5h | € 112–€ 187 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.2h | € 54–€ 90 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 3.5h | € 157–€ 262 |
| Power Steering Hose - High Pressure | 1.0h | € 45–€ 75 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.0h | € 45–€ 75 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.0h | € 45–€ 75 |
| Air Suspension Valve Block | 2.0h | € 90–€ 150 |
| Ball Joint - Lower | 1.8h | € 81–€ 135 |
| Ball Joint - Upper | 1.5h | € 67–€ 112 |
| Ball Joints - Upper and Lower | 3.0h | € 135–€ 225 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Kickdown Cable | 0.8h | € 36–€ 60 |
| Neutral Safety Switch | 1.0h | € 45–€ 75 |
| Overdrive Solenoid | 2.0h | € 90–€ 150 |
| Shift Cable | 1.5h | € 67–€ 112 |
| Shift Linkage | 1.0h | € 45–€ 75 |
| Shift Solenoid - Single | 4.3h | € 193–€ 322 |
| Shift Solenoids - All | 9.4h | € 423–€ 705 |
| Torque Converter | 7.2h | € 324–€ 540 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
🔧 SCHEDULED MAINTENANCE
Drive Belt—
Power Steering Fluid—
Windshield Wiper Blades12 months
Engine Oil And Filter12,000 km / 6 months
Tire Rotation12,000 km / 6 months
Multi-Point Inspection12,000 km / 12 months
Cabin Air Filter24,000 km / 12 months
Brake System Inspection24,000 km / 12 months
📋 RECALLS & TSB (51)
NHTSA 11V450000
Fuel System, Other › Fuel Injection System
Date: 31/08/2011
ROUSH IS RECALLING CERTAIN MODEL YEAR 2009-2011 FORD E-150, E-250, AND E-350 5.4L ENGIN VANS/WAGONS/CUTAWAYS, AND MODEL YEAR 2010-2011 FORD E-450 6.8L ENGINE CUTAWAY VEHICLES ALTERED BY ROUCH TO OPERATE USING THE ROUSH BRANDED CLEANTECH PROPANE AUTOGAS FUEL SYSTEM. THE FUEL RAIL…
NHTSA 11E033000
Fuel System, Other › Fuel Injection System
Date: 31/08/2011
ROUSH IS RECALLING CERTAIN AFTERMARKET ROUSH CLEAN TECH LIQUID PROPANE AUTOGAS FUEL SYSTEM KITS USED FOR INSTALLATION ON THE FOLLOWING VEHICLES: MODEL YEAR 2007 AND 2008 FORD E-350 (DUEL REAR WHEEL), MY 2009-2011 FORD E- 150, E-250, AND E-350, AND MY 2009-2011 FORD E-450 CUTAWA…
NHTSA 11E019000
Fuel System, Other › Delivery › Hoses, Lines/Piping, And Fittings
Date: 31/05/2011
ROUSH IS RECALLING CERTAIN AFTERMARKET ROUSH CLEAN TECH LIQUID PROPANE AUTOGAS FUEL SYSTEM KITS PRODUCED BETWEEN DECEMBER 17, 2010, AND MAY 6, 2011, USED FOR INSTALLATION ON FLEET VEHICLES MODEL YEAR 2009 THROUGH 2011 FORD E-SERIES VANS/WAGONS/SHUTTLES/CUTAWAY (150, 250 AND 350)…
NHTSA 11V307000
Fuel System, Other › Delivery › Hoses, Lines/Piping, And Fittings
Date: 31/05/2011
ROUSH PERFORMANCE PRODUCTS IS RECALLING CERTAIN 2011 FORD E-SERIES VANS EQUIPPED WITH 5.4 OR 6.8 LITER ENGINES THAT HAVE BEEN ALTERED BY ROUSH TO OPERATE USING THE ROUSH LIQUID PROPANE AUTOGAS FUEL SYSTEM. A VALVE IN THE SYSTEM MAY HAVE BEEN MISMACHINED ALLOWING A PROPANE LEAK.
NHTSA 09V297000
Equipment Adaptive/Mobility
Date: 29/07/2009
R&R MOBILITY IS RECALLING 7 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETEC…
NHTSA 09V298000
Equipment Adaptive/Mobility
Date: 29/07/2009
R&R MOBILITY IS RECALLING 7 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT …
NHTSA 14V279000
Equipment Adaptive/Mobility
Date: 27/05/2014
Mobility Specialists, Inc. (Mobility Specialists) is recalling certain model year 2007-2008 Ford E-150 vans modified by Mobility Specialists and equipped with Braun NCL-2, and NVL-2 wheel chair lifts. Over time, and with frequent use, the roll stop latches on the outer barrier o…
NHTSA 09V102000
Equipment Adaptive/Mobility
Date: 27/03/2009
VAN CONVERSIONS IS RECALLING 74 MY 2004-2007 FORD E-150, E-250 E-350 AND MY 2006 GM SAVANNA 3500 VANS BUILT ON FORD AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDAR…
NHTSA 09V100000
Equipment Adaptive/Mobility
Date: 27/03/2009
VAN CONVERSIONS IS RECALLING 52 MY 2004-2007 FORD E-150, E-250 E-350 AND MY 2006 GM SAVANNA 3500 VANS BUILT ON FORD AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD N…
NHTSA 11V445000
Visibility › Windshield
Date: 26/08/2011
Ford Motor Company (Ford) is recalling certain model year 2011 Ford E-150, E-250, E-350, and E-450 vehicles built from May 12, 2011, through May 26, 2011. Due to improper manufacturing conditions, some of the windshields may form bubbles after an extended time in hot temperature…
NHTSA 08V568000
Equipment Adaptive/Mobility
Date: 24/10/2008
CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENT…
NHTSA 08V569000
Equipment Adaptive/Mobility
Date: 24/10/2008
CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENT…
NHTSA 92V123000
Equipment › Other › Labels
Date: 24/08/1992
THE TIRE CERTIFICATION LABELS INCORRECTLY IDENTIFY THE VEHICLE TIRE REQUIREMENTS AS P235/75R15 SL (STANDARD LOAD), RATHER THAN AS P235/75R15 XL (EXTRA LOAD).
NHTSA 14V584000
Equipment Adaptive/Mobility
Date: 23/09/2014
National Van Builders, Inc. (National Van) is recalling certain 2007-2014 Ford E-150 and E-250 vehicles manufactured February 26, 2007, to August 19, 2014, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporat…
NHTSA 13V261000
Equipment
Date: 21/06/2013
Mobility Works is recalling certain model year 2006-2012 Ford E-150, E-250 and E-350 vehicles manufactured August 2006 through August 2012. The vehicles are equipped with certain Ricon S series and K Series wheelchair lifts with an optional armored pendant cable. The armored cab…
NHTSA 11V246000
Seats › Front Assembly › Power Adjust
Date: 20/04/2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 E-150, E-250, E-350 AND E-450 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." IT MAY BE POSSIBLE THAT UNDER UNUSUALLY HIGH LOADS, SUCH AS DURING A CRASH, THE DRIVER …
NHTSA 10V270000
Seats
Date: 17/06/2010
ACCESS OPTIONS IS RECALLING CERTAIN TRUCKS AND VANS BUILT ON FORD E150, E350, TOYOTA SIENNA, AND DODGE GRAND CARAVAN CHASSIS AND EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THE SIX WAY POWER SEAT BASE MAY HAVE A DEFECTIVE (COLD) WELD ON THE PIVOT PIN WHICH IS WELDED TO THE SW…
NHTSA 10V271000
Equipment Adaptive/Mobility
Date: 15/06/2010
ALL IN ONE MOBILITY IS RECALLING CERTAIN MODEL YEAR 1997 THROUGH 2008 CONVERSION VANS EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THERE IS A POSSIBILITY OF A DEFECTIVE WELD AT THE JOINT BETWEEN THE PIVOTING PLATE AND THE PIVOTING PLATE PIN.
NHTSA 10V153000
Equipment Adaptive/Mobility
Date: 15/04/2010
COMM-TRANS IS RECALLING CERTAIN MODEL YEAR 2007-2009 ADA CONVERSION VANS BUILT ON FORD E-150, E-250, AND E-350 CHASSIS BETWEEN DECEMBER 7, 2007 AND DECEMBER 23, 2009 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE …
NHTSA 10V151000
Equipment Adaptive/Mobility
Date: 15/04/2010
COMM-TRANS IS RECALLING CERTAIN MODEL YEAR 2007-2009 ADA CONVERSION VANS BUILT ON FORD E-150, E-250, AND E-350 CHASSIS BETWEEN DECEMBER 7, 2007 AND DECEMBER 23, 2009 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM …
NHTSA 99V046000
Latches/Locks/Linkages › Doors › Latch
Date: 15/03/1999
VEHICLE DESCRIPTION: UTILITY VANS EQUIPPED WITH THE "60/40" HINGED SIDE CARGO DOORS. THE STRIKERS FOR THE 60/40 DOOR SINGLE LATCH SYSTEM WERE FOUND TO CONTAIN STRESS CRACKS AT THE STRIKER WIRE LOWER STAKE JOINT. STRIKERS WITH STRESS CRACKS MAY NOT MEET THE REQUIREMENTS OF FMV…
NHTSA 09V273000
Equipment Adaptive/Mobility
Date: 14/07/2009
WEST TEXAS REHABILIATION CENTER IS RECALLING 1 MY 2005 CHEVROLET G3500 VAN AND 1 MY 2006 FORD E-150 VAN EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT INSTA…
NHTSA 09V274000
Equipment Adaptive/Mobility
Date: 14/07/2009
WEST TEXAS REHABILIATION CENTER IS RECALLING 1 MY 2005 CHEVROLET G3500 VAN AND 1 MY 2006 FORD E-150 VAN EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT INSTA…
NHTSA 09V399000
Vehicle Speed Control
Date: 13/10/2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUI…
NHTSA 04V445000
Engine And Engine Cooling
Date: 13/09/2004
ON CERTAIN VANS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTE…
NHTSA 04V444000
Electrical System › Wiring
Date: 13/09/2004
ON CERTAIN VANS, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT.
NHTSA 06E056000
Fuel System, Gasoline
Date: 13/06/2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH T…
NHTSA 10V206000
Equipment Adaptive/Mobility
Date: 13/05/2010
MOBILITY WORKS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS AFTER NOVEMBER 2007 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE O…
NHTSA 94V128000
Interior Lighting
Date: 11/07/1994
THE TRANSFORMER USED TO POWER THE NEON CENTER LIGHTBEAM CAN OVERHEAT AND CATCH ON FIRE.
NHTSA 14V426000
Fuel System, Other › Delivery › Hoses, Lines/Piping, And Fittings
Date: 10/07/2014
Roush Performance Products, Inc. (Roush) is recalling certain model year 2010-2012 Ford E-150 Wagons and Cargo Vans, E-250 Cargo Vans and Extended Cargo Vans, E-350 Wagons, Extended Wagons, Cargo Vans, and Extended Vans, and E-450 Cutaway models. These models were modified by Rou…
NHTSA 10V207000
Equipment Adaptive/Mobility
Date: 10/05/2010
MOBILITY WORKS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS AND CHEVROLET 2500 CHASSIS AFTER NOVEMBER 2007 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE …
NHTSA 05V520000
Visibility › Windshield Wiper/Washer › Motor
Date: 09/11/2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
NHTSA 94V087000
Equipment › Other › Labels
Date: 09/05/1994
THE MANUFACTURER'S CERTIFICATION LABEL AND/OR THE DRIVER AIR BAG ADVISORY LABEL MAY BE MISSING FROM THE VEHICLES, WHICH DOES NOT CONFORM TO THE REQUIREMENTS OF 49 CFR 567.
NHTSA 11E047000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 08/11/2011
FORD IS RECALLING CERTAIN REPLACEMENT FUEL TANKS THAT COULD BE INSTALLED INTO MODEL YEAR 2004 THROUGH 2008 E-150, E-250, AND E-350 VANS AND WAGONS. THE AFFECTED FUEL TANKS HAVE AN EXTRA OBDII SENSOR HOLE ON THE TOP OF THE TANK THAT MAY NOT BE PROPERLY SEALED AND MAY LEAK FUEL.
NHTSA 08V537000
Equipment Adaptive/Mobility
Date: 06/10/2008
ACCUBUILT IS RECALLING 890 MY 2006-2008 FORD E150, E250, AND E350 CARGO VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE A…
NHTSA 08V536000
Equipment Adaptive/Mobility
Date: 06/10/2008
ACCUBUILT IS RECALLING 890 MY 2006-2008 FORD E150, E250, AND E350 CARGO VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATION IN MOTOR VEHICLES." T…
NHTSA 08V518000
Equipment Adaptive/Mobility
Date: 06/10/2008
MOBILITYWORKS IS RECALLING 224 MY 2007-2008 FORD E150, MY 2006-2008 E250, MY 2004-2007 E350, MY 2006 E450, MY 2005-2007 CHEVROLET 2500, MY 2007 CHEVROLET 1500, AND MY 2006 DODGE 2500 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE…
NHTSA 14V501000
Fuel System, Other › Delivery › Hoses, Lines/Piping, And Fittings
Date: 06/08/2014
Adrian Steel Company (Adrian) is recalling certain model year 2012 Ford E-150, E-250 and E-350 Commercial Cargo Vans modified by Adrian between September 21, 2012, to September 24, 2012. The affected vehicles are equipped with certain propane fuel system conversion kits with an …
NHTSA 14V706000
Equipment Adaptive/Mobility
Date: 05/11/2014
Cummings Mobility Conversion & Supply (Cummings) is recalling certain model year 2006-2014 Ford E-150, E-250, E-350, Chevrolet Express, 2006-2008 Dodge Sprinter, and 2009-2014 Mercedes-Benz Sprinter, and 2013 Ford Transit Connect vehicles manufactured January 1, 2006, to October …
NHTSA 01V114000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 05/04/2001
VEHICLE DESCRIPTION: ON CERTAIN VANS WITH AMBULANCE PREP PACKAGES OR OTHER SEVERE-DUTY APPLICATIONS INVOLVING OPERATION AT OR NEAR THE GROSS VEHICLE WEIGHT WITH FREQUENT TWISTING OF THE VEHICLE BODY, SUCH AS OFF-ROAD, ROUGH ROAD OR SPEED BUMP EVENTS, THE 35 GALLON MID-SHIP FUEL…
NHTSA 08V057000
Fuel System, Gasoline › Fuel Injection System › Fuel Rail
Date: 05/02/2008
FORD IS RECALLING 57,199 MY 2006-2007 E-150, E-250, E-350, AND MY 2007 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES EQUIPPED WITH 5.4L ENGINES. THE FUEL RAIL CROSS-OVER HOSE MAY CONTAIN WEAK AREAS. AS A RESULT, THE HOSE MAY CRACK, WHICH COULD CAUSE A FUEL ODOR AND/OR FUEL LEAK.
NHTSA 15V729000
Equipment Adaptive/Mobility
Date: 04/11/2015
MobilityWorks (WMK Inc.) is recalling certain model year 2006-2014 Ford E-150, E-250, and E-350 vans modified by MobilityWorks to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The affected lifts ar…
NHTSA 91V146000
Fuel System, Gasoline › Storage › Auxillary Tank › Selector Devices
Date: 04/09/1991
THE DUAL FUEL TANK SELECTOR VALVE MAY MALFUNCTION AND CAUSE AN OVERFILL CONDITION IN ONE OF THE FUEL TANKS, RESULTING IN AN OVERFLOW OF FUEL PAST THE FILLER CAP.
NHTSA 10V242000
Equipment Adaptive/Mobility
Date: 04/06/2010
MOBILITY TRANSPORTATION (MTS) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS FROM SEPTEMBER 16, 2008 THROUGH APRIL 15, 2009 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PRE…
NHTSA 10V243000
Equipment Adaptive/Mobility
Date: 04/06/2010
MOBILITY TRANSPORTATION (MTS) IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2009 CONVERSION VANS BUILT ON FORD E150, E250, AND E350 CHASSIS FROM SEPTEMBER 16, 2008 THROUGH APRIL 15, 2009 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBL…
NHTSA 14V097000
Fuel System, Other › Storage
Date: 04/03/2014
Landi Renzo USA is recalling certain model year 2011-2014 Ford E-150, E-250, and E-350 vehicles modified January 2, 2011, through February 24, 2014 to operate on compressed natural gas (CNG). In the affected vehicles, the left and right rear brackets that support the rear CNG cy…
NHTSA 08V051000
Vehicle Speed Control › Cruise Control
Date: 04/02/2008
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHIC…
NHTSA 07V336000
Vehicle Speed Control
Date: 03/08/2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
NHTSA 19V271000
Equipment Adaptive/Mobility
Date: 03/04/2019
Mobility Specialists, Inc. (Mobility Specialists) is recalling certain 2014-2017 Ford E-150 and Transit vans modified to be equipped with Ricon S-Series and K-Series wheel chair lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the plat…
NHTSA 14V232000
Equipment Adaptive/Mobility
Date: 02/05/2014
WMK Inc., doing business as Mobility Works, Inc. (Mobility), is recalling certain model year 2013-2014 Mobility-modified Ford E-150, and E-250 transit buses manufactured December 1, 2013, through January 4, 2014, and equipped with certain Ricon S series and K series wheelchair li…
NHTSA 06V286000
Vehicle Speed Control
Date: 01/08/2006
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1233
powertrain
HIGHP1651
powertrain
LOWP1650
powertrain
LOWP1641
powertrain
HIGHP1579
powertrain
HIGHP1537
powertrain
LOWP1455
powertrain
MODERATEP1451
powertrain
LOWP1409
powertrain
MODERATEP1383
powertrain
MODERATEP1285
powertrain
HIGHP1270
powertrain
LOWP1237
powertrain
HIGHP1235
powertrain
HIGHP1152
powertrain
MODERATEP1117
powertrain
LOWP1116
powertrain
LOWP1103
powertrain
MODERATEP1783
powertrain
CRITICALP1746
powertrain
HIGH
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
57 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
Low Oil Pressure (Ford)Engine
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
AdvanceTrac Off (Ford)Chassis
SYNC System Fault (Ford)Electrical
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
MyKey Speed Limit (Ford)Electrical
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
442 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Ford E-150 across model years 1990–2014. These are real, verified reports submitted by vehicle owners.
31 crash reports 4 fires 33 injuries
Complaints by model year (most reported first)
Model year 2008265
Model year 199860
Model year 200526
Model year 201319
Model year 200617
Model year 199115
Model year 200712
Model year 201212
Most reported components (all years)
Electrical System73
Structure50
Power Train48
Service Brakes34
Engine34
Tires32
Sample reports
06-03-2007 RIGHT DOOR HANDLE (OUTSIDE PART) BROKE AND I COULD NOT GET INTO MY VAN. NO ABUSE ON MY PART. I HAD THE DOOR HANDLE REPLACED BY FORD DEALERSHIP AT MY EXPENSE ($125.00). 03-03-2008 LEFT DOOR HANDLE (OUTSIDE PART) BROKE WHEN I… (MY 1998)
12-25-2016 AFTER DROOPING OFF MAID AND GARDENER HERE IN HUATULCO MEXICO MY POWER STEERING QUIT. SINCE GOING SO SLOW DOWN HILL ON VILLAGE STREET I THOUGHT THAT MOTOR HAD QUIT. REALIZED THAT MOTOR WAS RUNNING. THEN NOTICED DASH WARNING TH… (MY 2013)
IGNITION SWITCH FAILURE. REPEATED PROBLEM SINCE PURCHASED NEW!! KEY WON'T TURN LOCK OR GETS STUCK. *JS (MY 2008)
TL* THE CONTACT OWNS A 2008 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE SUDDENLY BEGAN TO DECELERATE. THE VEHICLE WAS MANEUVERED TO THE SHOULDER AND STOPPED. THE VEHICLE WAS THEN TOWED TO AN INDEPENDENT MECHANIC… (MY 2008)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 1990–2014.
Frequently Asked Questions
Does the Ford E-150 have any safety recalls?
Yes — 51 official NHTSA recall campaign(s) affect this model, mainly: FUEL SYSTEM, GASOLINE:STORAGE:AUXILLARY TANK:SELECTOR DEVICES, VEHICLE SPEED CONTROL:CRUISE CONTROL. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Ford E-150?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Ford E-150?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Ford E-150?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are steering problems common on the Ford E-150?
Yes — 55 of 428 real owner reports filed with NHTSA mention the steering. One owner reported: “I PURCHASED FOUR GOODYEAR WRANGLER ATD 255/70R16 TIRES FROM SAM'S WHOLESALE CLUB. I HAVE EXPERIENCED IRREGULAR AND EXCESSIVE WEAR ON OUTER EDGES OF ALL FOUR TIRES, CAUSING VIBRATION AND HANDLING PROB…” See the owner-reported complaints section below for more.
Are electrical problems common on the Ford E-150?
Yes — 55 of 428 real owner reports filed with NHTSA mention the electrical. One owner reported: “DRIVING DOWN THE HIGHWAY I HEARD A POPPING SOUND, THE TRUCK STALLED AND THE CHECK ENGINE LIGHT CAME ON. THE TRUCK CONTINUED TO STALL. I CALLED CLARK FORD AFTER HEARING ABOUT A SPARK PLUG PROBLEM WITH …” See the owner-reported complaints section below for more.
Are engine problems common on the Ford E-150?
Yes — 80 of 428 real owner reports filed with NHTSA mention the engine. One owner reported: “Picked up vehicle from auto shop, work had been done on the front brakes, engine temp sensor, heater blower relay, map sensor, throttle control position sensor and ECM had been replaced. Shortly after…” See the owner-reported complaints section below for more.
What is the right battery for the Ford E-150 (1990–2014)?
The battery specified for the Ford E-150 (1990–2014) is group 65 (BCI), with a cold cranking rating of 750A. See the Battery section on this page for the main cross-references between brands.
What engine oil should I use on the Ford E-150 (1990–2014)?
The engine oil specification for the Ford E-150 (1990–2014) is Motorcraft 5W-20 Synthetic Blend. Always use the viscosity grade approved by the manufacturer: a different oil can reduce engine protection and void the warranty. Check the change interval in the Maintenance section.
Which OBD2 fault codes are commonly documented for the Ford E-150 (1990–2014)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Ford E-150 (1990–2014) be serviced?
Routine maintenance for the Ford E-150 (1990–2014) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Considering buying a Ford E-150 (1990–2014)? Use this guide to check expected maintenance costs, the most reported fault codes and parts availability on the market. Real data, zero commercial estimates.