HYUNDAI KONA (2017–2025)
TroubleAtlas Score
HYUNDAI KONA (2017–2025) Manual — Codes, Tyres & Parts
Built 2017–2025 · all production years covered on this single page
1.0L I3 T-GDi 120 • Gasoline
🚗 Hyundai KONA 2025
TroubleAtlas Score
An independent value score for the Hyundai Kona (2017–2025) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost7.8
Parts & repairability4.4
Maintenance & durabilityn/a
Documentation & support3.3
Independent · Verified · Never for sale
Every figure on this Hyundai Kona (2017–2025) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Hyundai Kona (2017–2025) is powered by a 1.0L I3 T-GDi 120 engine. Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Easy
0.9h
€63 – €81
Rear brake pads
Difficulty: Easy
1.0h
€70 – €90
Engine oil change
Difficulty: Easy
0.5h
€35 – €45
ABS Module
Difficulty: Medium
1.8h
€126 – €162
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 1.8h | € 81–€ 135 |
| ABS Pump | 1.8h | € 81–€ 135 |
| ABS Tone Ring | 1.4h | € 62–€ 105 |
| ABS Wheel Speed Sensor - Front | 1.4h | € 62–€ 105 |
| ABS Wheel Speed Sensor - Rear | 1.4h | € 62–€ 105 |
| Brake Bleed - All Four | 1.4h | € 62–€ 105 |
| Brake Booster | 2.8h | € 125–€ 210 |
| Brake Booster Check Valve | 0.9h | € 40–€ 67 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.4h | € 62–€ 105 |
| Coolant Flush | 0.7h | € 31–€ 52 |
| Coolant Reservoir | 1.4h | € 62–€ 105 |
| Coolant Temperature Sensor | 0.5h | € 22–€ 37 |
| Cooling Fan Assembly | 1.4h | € 62–€ 105 |
| Cooling Fan Clutch | 1.4h | € 62–€ 105 |
| Cooling Fan Motor | 1.4h | € 62–€ 105 |
| Cooling Fan Relay | 0.9h | € 40–€ 67 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.4h | € 62–€ 105 |
| Airbag - Passenger | 1.4h | € 62–€ 105 |
| Airbag - Side | 1.4h | € 62–€ 105 |
| Airbag Module/Computer | 1.4h | € 62–€ 105 |
| Alternator | 1.4h | € 62–€ 105 |
| Alternator Belt | 1.4h | € 62–€ 105 |
| Amplifier | 1.4h | € 62–€ 105 |
| Antenna | 0.5h | € 22–€ 37 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Boost Pressure Sensor | 2.8h | € 125–€ 210 |
| Camshaft Position Sensor | 1.4h | € 62–€ 105 |
| Camshaft R&R | 4.1h | € 184–€ 307 |
| Connecting Rod Bearings | 1.4h | € 62–€ 105 |
| Crankshaft Position Sensor | 1.4h | € 62–€ 105 |
| Crankshaft R&R | 1.4h | € 62–€ 105 |
| Cylinder Head R&R | 4.1h | € 184–€ 307 |
| Cylinder Head Resurface | 4.1h | € 184–€ 307 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 1.4h | € 62–€ 105 |
| Catalytic Converter - California | 1.8h | € 81–€ 135 |
| Catalytic Converter - Direct Fit | 1.8h | € 81–€ 135 |
| Catalytic Converter - Universal | 1.8h | € 81–€ 135 |
| Downpipe | 1.8h | € 81–€ 135 |
| EGR Cooler | 1.4h | € 62–€ 105 |
| EGR Tube | 1.4h | € 62–€ 105 |
| EGR Valve | 1.4h | € 62–€ 105 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.4h | € 62–€ 105 |
| EVAP Purge Valve | 1.4h | € 62–€ 105 |
| EVAP Vent Valve | 1.4h | € 62–€ 105 |
| Fuel Cap | 0.3h | € 13–€ 22 |
| Fuel Filler Neck | 2.8h | € 125–€ 210 |
| Fuel Filter | 0.5h | € 22–€ 37 |
| Fuel Filter - In-Tank | 0.9h | € 40–€ 67 |
| Fuel Injector - Single | 2.8h | € 125–€ 210 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.8h | € 81–€ 135 |
| AC Clutch Coil | 1.4h | € 62–€ 105 |
| AC Compressor | 1.8h | € 81–€ 135 |
| AC Compressor Clutch | 1.8h | € 81–€ 135 |
| AC Compressor Oil Add | 1.8h | € 81–€ 135 |
| AC Condenser | 1.8h | € 81–€ 135 |
| AC Evaporator | 1.8h | € 81–€ 135 |
| AC Expansion Valve (TXV) | 1.8h | € 81–€ 135 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.4h | € 62–€ 105 |
| Electric Power Steering Module | 1.4h | € 62–€ 105 |
| Electric Power Steering Motor | 1.4h | € 62–€ 105 |
| Idler Arm | 0.9h | € 40–€ 67 |
| Pitman Arm | 1.4h | € 62–€ 105 |
| Power Steering Fluid Flush | 1.8h | € 81–€ 135 |
| Power Steering Gear Box | 1.8h | € 81–€ 135 |
| Power Steering Hose - High Pressure | 1.4h | € 62–€ 105 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.4h | € 62–€ 105 |
| Air Spring/Air Bag | 1.4h | € 62–€ 105 |
| Air Suspension Compressor | 1.4h | € 62–€ 105 |
| Air Suspension Height Sensor | 1.4h | € 62–€ 105 |
| Air Suspension Valve Block | 1.4h | € 62–€ 105 |
| Ball Joint - Lower | 1.4h | € 62–€ 105 |
| Ball Joint - Upper | 1.8h | € 81–€ 135 |
| Ball Joints - Upper and Lower | 1.8h | € 81–€ 135 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Kickdown Cable | 1.4h | € 62–€ 105 |
| Neutral Safety Switch | 1.4h | € 62–€ 105 |
| Overdrive Solenoid | 1.4h | € 62–€ 105 |
| Shift Cable | 1.4h | € 62–€ 105 |
| Shift Fork | 1.5h | € 67–€ 112 |
| Shift Linkage | 1.4h | € 62–€ 105 |
| Shift Solenoid - Single | 1.4h | € 62–€ 105 |
| Shift Solenoids - All | 1.4h | € 62–€ 105 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
📋 RECALLS & TSB (8)
NHTSA 21V301000
Engine
Date: 28/04/2021
Hyundai Motor America (Hyundai) is recalling certain 2019-2020 Elantra, 2019-2021 Kona and Veloster vehicles equipped with 2.0L Nu MPI engines. The piston oil rings may not have been properly heat-treated, which could result in engine damage.
NHTSA 23V526000
Power Train › Automatic Transmission › Fluid/Lubricant › Pump
Date: 27/07/2023
Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Palisade Tucson, 2023 Sonata, Elantra, and Kona vehicles. The electronic controller for the Idle Stop & Go oil pump assembly may contain damaged electrical components that can cause the pump controller to overheat.
NHTSA 23V901000
Electrical System › 12V/24V/48V Battery › Cables
Date: 26/12/2023
Hyundai Motor America (Hyundai) is recalling certain 2024 Kona vehicles. The 12-Volt battery cables may chafe against the engine control module bracket and short circuit during a crash.
NHTSA 23V650000
Seat Belts › Rear/Other › Retractor
Date: 22/09/2023
Hyundai Motor America (Hyundai) is recalling certain 2024 Kona vehicles. The seat belt assemblies in the right and left rear seats may not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occu…
NHTSA R/2021/014
Date: 22-02-2021
The vehicle VIN information may not be registered correctly within the eCall unit.
NHTSA 20V022000
Equipment › Other › Labels
Date: 17/01/2020
Hyundai Motor America (Hyundai) is recalling certain 2020 Kona vehicles. The certification label may indicate incorrect Gross Axle Weight Rating (GAWR). As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 567, "C…
NHTSA 24V308000
Engine And Engine Cooling › Exhaust System › Emission Control › Gas Recirculation Valve (Egr Valve)
Date: 01/05/2024
Hyundai Motor America (Hyundai) is recalling certain 2024 Elantra, Venue, and Kona vehicles. An electrical short circuit may occur in the exhaust gas recirculation (EGR) valve assembly, which can result in a loss of drive power.
NHTSA R/2019/115
Brake Fluid Line And A/C Tube Pipes Could Become Damaged And Leak
Date: 01-05-2019
A right-front brake fluid line and a/c tube may become damaged and leak.
COMMON OBD2 CODES TO CHECK
P0420
Catalyst System Efficiency Below Threshold Bank 1
Powertrain
P0171
System Too Lean Bank 1
Powertrain
P0300
Random/Multiple Cylinder Misfire Detected
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
Coolant Thermostat Below Regulating Temperature
Powertrain
P0455
EVAP System Leak Detected (Gross Leak)
Powertrain
P0700
Transmission Control System (MIL Request)
Powertrain
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1123
powertrain
MODERATEP1693
powertrain
MODERATEP1611
powertrain
LOWP1586
powertrain
MODERATEP1307
powertrain
LOWP1295
powertrain
HIGHP1147
powertrain
HIGHP1118
powertrain
HIGHP1166
powertrain
MODERATEP1505
powertrain
MODERATEP1124
powertrain
MODERATEP1608
powertrain
CRITICALP1151
powertrain
HIGHP1440
powertrain
LOWP1110
powertrain
HIGHP1506
powertrain
MODERATEP1523
powertrain
LOWP1155
powertrain
HIGHP1134
powertrain
MODERATEP1111
powertrain
LOW
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
57 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
TPMS Warning (Hyundai)Tyres
e-4WD Fault (Hyundai)Chassis
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
Lane Keeping Assist Off (Hyundai)ADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
BlueLink Connected (Hyundai)Electrical
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
717 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Hyundai Kona across model years 2017–2025. These are real, verified reports submitted by vehicle owners.
42 crash reports 19 fires 43 injuries 1 death
Complaints by model year (most reported first)
Model year 2019174
Model year 2020147
Model year 2021108
Model year 202293
Model year 201872
Model year 202361
Model year 202438
Model year 202524
Most reported components (all years)
Engine342
Electrical System114
Unknown Or Other112
Power Train80
Forward Collision Avoidance50
Vehicle Speed Control36
Sample reports
The car has never been good on gas or changing gears when drive mode was changed to sport from the beginning. It would say 200 miles to drive I will drive 30 miles and it will go down to 130. Recently the engine light has come on the c… (MY 2021)
Leased 5/24/2020. Poor mileage . Told had to break in. On 3/24, 3/29 and 3/30, 2020, car stalled out in traffic. Called for service and given date 3 weeks later. Called Another dealer and got appt. for next day.Spoke to Hyundai Ca. (Soni… (MY 2020)
After a routine service visit, the vehicle’s braking and speed‑control systems began to behave abnormally. The ABS/ESC control module was replaced or reprogrammed without documentation, and immediately afterward the vehicle’s braking fee… (MY 2023)
The horn does not work. The fuse is fine, it is the horn itself that does not work. (MY 2022)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 2017–2025.
Frequently Asked Questions
Does the Hyundai Kona have any safety recalls?
Yes — 17 official NHTSA recall campaign(s) affect this model, mainly: ENGINE, EQUIPMENT:OTHER:LABELS, POWER TRAIN:AUTOMATIC TRANSMISSION:FLUID/LUBRICANT:PUMP. Check the recalls section for your exact year/VIN.
What does fault code P0071 mean on the Hyundai Kona?
Ambient Air Temperature Sensor Range/Performance This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0070 mean on the Hyundai Kona?
Ambient Air Temperature Sensor Circuit This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Hyundai Kona?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are transmission problems common on the Hyundai Kona?
Yes — 83 of 823 real owner reports filed with NHTSA mention the transmission. One owner reported: “The DCT(Dual Clutch Transmission) has always been an issue since I purchased the vehicle. Anytime I would be going at a slow pace in a drive-thru or traffic on the freeway the car would jolt and shake…” See the owner-reported complaints section below for more.
Are electrical problems common on the Hyundai Kona?
Yes — 360 of 823 real owner reports filed with NHTSA mention the electrical. One owner reported: “The contact owns a 2018 Hyundai Koa. The contact stated that while the daughter was driving the vehicle began to sputter and jerk before stalling. During the failure the oil warning light flashed off …” See the owner-reported complaints section below for more.
Are engine problems common on the Hyundai Kona?
Yes — 360 of 823 real owner reports filed with NHTSA mention the engine. One owner reported: “The contact owns a 2018 Hyundai Koa. The contact stated that while the daughter was driving the vehicle began to sputter and jerk before stalling. During the failure the oil warning light flashed off …” See the owner-reported complaints section below for more.
What tyres does the Hyundai Kona (2017–2025) use?
The original OEM tyre size for the Hyundai Kona (2017–2025) is 215/55 R16. Compatible alternative sizes: ["235/50R18", "215/55R18", "215/60R17", "245/45R19", "205/65R16"]. See the Tyres section on this page to compare offers from the main suppliers.
Which OBD2 fault codes are commonly documented for the Hyundai Kona (2017–2025)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Hyundai Kona (2017–2025) be serviced?
Routine maintenance for the Hyundai Kona (2017–2025) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
This spec sheet is updated with data verified from OEM sources and shop databases. If you spot an inaccuracy or have additional data on the Hyundai Kona (2017–2025), let us know — every correction improves quality for all users.