TroubleAtlas Score
KIA BORREGO (2009–2011) — Technical Guide, Fault Codes & Maintenance
Built 2009–2011 · all production years covered on this single page
4.6L V8 • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Kia Borrego (2009–2011) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost8.6
Parts & repairability3.9
Maintenance & durabilityn/a
Documentation & support3.2
Independent · Verified · Never for sale
Every figure on this Kia Borrego (2009–2011) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Kia Borrego (2009–2011) is powered by a 4.6L V8 engine. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Easy
0.8h
€56 – €72
Rear brake pads
Difficulty: Easy
0.9h
€63 – €81
Engine oil change
Difficulty: Easy
0.3h
€21 – €27
ABS Module
Difficulty: Medium
2.0h
€140 – €180
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.5h | € 112–€ 187 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 0.8h | € 36–€ 60 |
| ABS Wheel Speed Sensor - Rear | 0.8h | € 36–€ 60 |
| Brake Bleed - All Four | 1.0h | € 45–€ 75 |
| Brake Booster | 2.5h | € 112–€ 187 |
| Brake Booster Check Valve | 0.3h | € 13–€ 22 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.5h | € 67–€ 112 |
| Coolant Flush | 1.0h | € 45–€ 75 |
| Coolant Reservoir | 0.5h | € 22–€ 37 |
| Coolant Temperature Sensor | 0.5h | € 22–€ 37 |
| Cooling Fan Assembly | 1.0h | € 45–€ 75 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 0.3h | € 13–€ 22 |
| Engine Oil Cooler | 2.0h | € 90–€ 150 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.0h | € 45–€ 75 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 2.0h | € 90–€ 150 |
| Airbag Module/Computer | 1.0h | € 45–€ 75 |
| Alternator | 1.5h | € 67–€ 112 |
| Alternator Belt | 0.5h | € 22–€ 37 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Camshaft Position Sensor | 1.0h | € 45–€ 75 |
| Camshaft R&R | 8.0h | € 360–€ 600 |
| Connecting Rod Bearings | 15.0h | € 675–€ 1125 |
| Crankshaft Position Sensor | 1.0h | € 45–€ 75 |
| Crankshaft R&R | 20.0h | € 900–€ 1500 |
| Cylinder Head R&R | 6.0h | € 270–€ 450 |
| Cylinder Head Resurface | 8.0h | € 360–€ 600 |
| Engine Mount - Front | 1.5h | € 67–€ 112 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 0.8h | € 36–€ 60 |
| Catalytic Converter - California | 1.5h | € 67–€ 112 |
| Catalytic Converter - Direct Fit | 1.5h | € 67–€ 112 |
| Catalytic Converter - Universal | 2.0h | € 90–€ 150 |
| Downpipe | 2.0h | € 90–€ 150 |
| EGR Cooler | 3.0h | € 135–€ 225 |
| EGR Tube | 1.5h | € 67–€ 112 |
| EGR Valve | 1.0h | € 45–€ 75 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.0h | € 45–€ 75 |
| EVAP Purge Valve | 0.8h | € 36–€ 60 |
| EVAP Vent Valve | 0.8h | € 36–€ 60 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 1.5h | € 67–€ 112 |
| Fuel Filter | 0.5h | € 22–€ 37 |
| Fuel Filter - In-Tank | 2.0h | € 90–€ 150 |
| Fuel Injector - Single | 1.0h | € 45–€ 75 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.5h | € 67–€ 112 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.5h | € 112–€ 187 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 0.5h | € 22–€ 37 |
| AC Condenser | 2.5h | € 112–€ 187 |
| AC Evaporator | 6.0h | € 270–€ 450 |
| AC Expansion Valve (TXV) | 4.0h | € 180–€ 300 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 2.5h | € 112–€ 187 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.2h | € 54–€ 90 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 3.5h | € 157–€ 262 |
| Power Steering Hose - High Pressure | 1.0h | € 45–€ 75 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.0h | € 45–€ 75 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.0h | € 45–€ 75 |
| Air Suspension Valve Block | 2.0h | € 90–€ 150 |
| Ball Joint - Lower | 1.8h | € 81–€ 135 |
| Ball Joint - Upper | 1.5h | € 67–€ 112 |
| Ball Joints - Upper and Lower | 3.0h | € 135–€ 225 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Kickdown Cable | 0.8h | € 36–€ 60 |
| Neutral Safety Switch | 1.0h | € 45–€ 75 |
| Overdrive Solenoid | 2.0h | € 90–€ 150 |
| Shift Cable | 1.5h | € 67–€ 112 |
| Shift Linkage | 1.0h | € 45–€ 75 |
| Transmission Control Module | 1.0h | € 45–€ 75 |
| Transmission Cooler Lines | 1.0h | € 45–€ 75 |
| Transmission Filter | 1.0h | € 45–€ 75 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
📋 RECALLS & TSB (4)
NHTSA 12V245000
Service Brakes, Hydraulic › Pedals And Linkages
Date: 31/05/2012
KIA IS RECALLING CERTAIN MODEL YEAR 2009 BORREGO VEHICLES, MANUFACTURED FROM MAY 2, 2008, THROUGH JANUARY 20, 2009, EQUIPPED WITH NON-ADJUSTABLE BRAKE PEDALS. CERTAIN PEDAL MOUNTS MAY HAVE A FIBERGLASS COMPOSITION THAT ALLOWS THEM TO BREAK OFF IN A COLLISION WHERE THE IMPACT HAS…
NHTSA 23V652000
Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip › Control Unit/Module
Date: 25/09/2023
Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Con…
NHTSA 23V692000
Structure › Body › Roof And Pillars
Date: 13/10/2023
Kia America, Inc. (Kia) is recalling certain 2009-2014 Borrego vehicles. The headliner plates may not be secured properly, which can result in the plates detaching in the event of a side curtain air bag deployment.
NHTSA 13V114000
Exterior Lighting › Brake Lights › Switch
Date: 01/04/2013
Kia Motors Corporation (Kia) is recalling certain model year 2007-2010 Rondo, model year 2007-2011 Sedona, Sorento and Sportage, model year 2010-2011 Soul, model year 2008-2011 Optima, model year 2010 Forte, model year 2007-2009 Amanti, and model year 2009 Borrego vehicles. Orig…
COMMON OBD2 CODES TO CHECK
P0420
Catalyst System Efficiency Below Threshold Bank 1
Powertrain
P0171
System Too Lean Bank 1
Powertrain
P0300
Random/Multiple Cylinder Misfire Detected
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
Coolant Thermostat Below Regulating Temperature
Powertrain
P0455
EVAP System Leak Detected (Gross Leak)
Powertrain
P0700
Transmission Control System (MIL Request)
Powertrain
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1123
powertrain
MODERATEP1693
powertrain
MODERATEP1611
powertrain
LOWP1586
powertrain
MODERATEP1307
powertrain
LOWP1295
powertrain
HIGHP1147
powertrain
HIGHP1118
powertrain
HIGHP1166
powertrain
MODERATEP1505
powertrain
MODERATEP1124
powertrain
MODERATEP1608
powertrain
CRITICALP1151
powertrain
HIGHP1440
powertrain
LOWP1110
powertrain
HIGHP1506
powertrain
MODERATEP1523
powertrain
LOWP1155
powertrain
HIGHP1134
powertrain
MODERATEP1111
powertrain
LOW
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
56 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
LDWS Fault (Kia)ADAS
AEB Fault (Kia)ADAS
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
Drive Mode (Kia)Engine
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
89 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Kia Borrego across model years 2009–2011. These are real, verified reports submitted by vehicle owners.
8 crash reports 3 injuries
Complaints by model year (most reported first)
Model year 200987
Model year 20102
Most reported components (all years)
Electrical System16
Service Brakes15
Power Train15
Seat Belts11
Unknown Or Other9
Exterior Lighting8
Sample reports
TL* THE CONTACT OWNS A 2009 KIA BORREGO. THE CONTACT STATED THAT SOME OF THE SEAT BELTS IN THE VEHICLE WOULD NOT LATCH PROPERLY WITHOUT FIRST DEPRESSING THE RELEASE BUTTON ON THE SEAT BELT. ONCE THE SEAT BELT WAS LATCHED, IT BECAME UNLAT… (MY 2009)
DRIVER'S SEAT BELT RANDOMLY DISCHARGES AND DISCONNECTS. WE BEGAN TO BE ABLE TO FEEL THE DIFFERENCE WHEN PUTTING IT ON WHEN IT WOULD LATCH VS WHEN IT WOULDN'T PROPERLY AND SECURELY LATCH. SOMETIMES IT WOULD TAKE 3-5 ATTEMPTS TO MAKE THE… (MY 2009)
AFTER STARTING THE CAR THEN MOVING THE SHIFTER IN TO DRIVE . AS I GET THE SHIFTER IN THE REVERSE POSITION GOING TO DRIVE .. THE CAR JERKS FORWARD LIKE I HAVE MY FOOT ON THE GAS.. IT IS VERY STARTLING. GOES IN REVERSE FINE.. BUT W… (MY 2009)
DRIVERS SEATBELT DOES NOT STAY LATCHED. POPS OPEN DRIVING DOWN ROAD WITHOUT TOUCHING IT. IT HAPPENS DRIVING STRAIGHT ON HIGHWAYS CITY STREETS GOING STRAIGHT AND TURNING. IT HAS BEEN AN ONGOING PROBLEM FOR AT LEAST A YEAR NOW. (MY 2009)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 2009–2011.
Frequently Asked Questions
Does the Kia Borrego have any safety recalls?
Yes — 4 official NHTSA recall campaign(s) affect this model, mainly: SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES, EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH. Check the recalls section for your exact year/VIN.
What does fault code P0003 mean on the Kia Borrego?
Fuel Volume Regulator Control Circuit Low This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0002 mean on the Kia Borrego?
Fuel Volume Regulator Control Circuit Range/Performance This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0001 mean on the Kia Borrego?
Fuel Volume Regulator Control Circuit/Open This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are transmission problems common on the Kia Borrego?
Yes — 20 of 89 real owner reports filed with NHTSA mention the transmission. One owner reported: “Something within the brake system is causing my shifter to not communicate with the brakes and will not allow my car to go into reverse or park. It stays stuck on drive or neutral. The only thing I ca…” See the owner-reported complaints section below for more.
Are brakes problems common on the Kia Borrego?
Yes — 26 of 89 real owner reports filed with NHTSA mention the brakes. One owner reported: “Something within the brake system is causing my shifter to not communicate with the brakes and will not allow my car to go into reverse or park. It stays stuck on drive or neutral. The only thing I ca…” See the owner-reported complaints section below for more.
Are electrical problems common on the Kia Borrego?
Yes — 36 of 89 real owner reports filed with NHTSA mention the electrical. One owner reported: “Something within the brake system is causing my shifter to not communicate with the brakes and will not allow my car to go into reverse or park. It stays stuck on drive or neutral. The only thing I ca…” See the owner-reported complaints section below for more.
Which OBD2 fault codes are commonly documented for the Kia Borrego (2009–2011)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Kia Borrego (2009–2011) be serviced?
Routine maintenance for the Kia Borrego (2009–2011) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Have a specific fault code on your Kia Borrego (2009–2011)? Search the code in the OBD2 section of this page or use the full TroubleAtlas DTC database. Need tyres? Compare prices and compatible sizes in the TroubleAtlas comparator.