TroubleAtlas Score
KIA SPECTRA (2000–2009) Manual — Codes, Tyres & Parts
Built 2000–2009 · all production years covered on this single page
2.0L I4 • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Kia Spectra (2000–2009) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost7.0
Parts & repairability4.5
Maintenance & durabilityn/a
Documentation & support4.3
Independent · Verified · Never for sale
Every figure on this Kia Spectra (2000–2009) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Kia Spectra (2000–2009) is powered by a 2.0L I4 engine. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Easy
0.8h
€56 – €72
Rear brake pads
Difficulty: Easy
0.9h
€63 – €81
Engine oil change
Difficulty: Easy
0.3h
€21 – €27
ABS Module
Difficulty: Medium
2.0h
€140 – €180
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.5h | € 112–€ 187 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 0.8h | € 36–€ 60 |
| ABS Wheel Speed Sensor - Rear | 0.8h | € 36–€ 60 |
| Brake Bleed - All Four | 1.0h | € 45–€ 75 |
| Brake Booster | 2.5h | € 112–€ 187 |
| Brake Booster Check Valve | 0.3h | € 13–€ 22 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.5h | € 67–€ 112 |
| Coolant Flush | 1.0h | € 45–€ 75 |
| Coolant Reservoir | 0.5h | € 22–€ 37 |
| Coolant Temperature Sensor | 0.5h | € 22–€ 37 |
| Cooling Fan Assembly | 1.0h | € 45–€ 75 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 0.3h | € 13–€ 22 |
| Engine Oil Cooler | 2.0h | € 90–€ 150 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.0h | € 45–€ 75 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 2.0h | € 90–€ 150 |
| Airbag Module/Computer | 1.0h | € 45–€ 75 |
| Alternator | 1.5h | € 67–€ 112 |
| Alternator Belt | 0.5h | € 22–€ 37 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Camshaft Position Sensor | 1.0h | € 45–€ 75 |
| Camshaft R&R | 8.0h | € 360–€ 600 |
| Connecting Rod Bearings | 15.0h | € 675–€ 1125 |
| Crankshaft Position Sensor | 1.0h | € 45–€ 75 |
| Crankshaft R&R | 20.0h | € 900–€ 1500 |
| Cylinder Head R&R | 6.0h | € 270–€ 450 |
| Cylinder Head Resurface | 8.0h | € 360–€ 600 |
| Engine Mount - Front | 1.5h | € 67–€ 112 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 0.8h | € 36–€ 60 |
| Catalytic Converter - California | 1.5h | € 67–€ 112 |
| Catalytic Converter - Direct Fit | 1.5h | € 67–€ 112 |
| Catalytic Converter - Universal | 2.0h | € 90–€ 150 |
| Downpipe | 2.0h | € 90–€ 150 |
| EGR Cooler | 3.0h | € 135–€ 225 |
| EGR Tube | 1.5h | € 67–€ 112 |
| EGR Valve | 1.0h | € 45–€ 75 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.0h | € 45–€ 75 |
| EVAP Purge Valve | 0.8h | € 36–€ 60 |
| EVAP Vent Valve | 0.8h | € 36–€ 60 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 1.5h | € 67–€ 112 |
| Fuel Filter | 0.5h | € 22–€ 37 |
| Fuel Filter - In-Tank | 2.0h | € 90–€ 150 |
| Fuel Injector - Single | 1.0h | € 45–€ 75 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.5h | € 67–€ 112 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.5h | € 112–€ 187 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 0.5h | € 22–€ 37 |
| AC Condenser | 2.5h | € 112–€ 187 |
| AC Evaporator | 6.0h | € 270–€ 450 |
| AC Expansion Valve (TXV) | 4.0h | € 180–€ 300 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 2.5h | € 112–€ 187 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.2h | € 54–€ 90 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 3.5h | € 157–€ 262 |
| Power Steering Hose - High Pressure | 1.0h | € 45–€ 75 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.0h | € 45–€ 75 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.0h | € 45–€ 75 |
| Air Suspension Valve Block | 2.0h | € 90–€ 150 |
| Ball Joint - Lower | 1.8h | € 81–€ 135 |
| Ball Joint - Upper | 1.5h | € 67–€ 112 |
| Ball Joints - Upper and Lower | 3.0h | € 135–€ 225 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Kickdown Cable | 0.8h | € 36–€ 60 |
| Neutral Safety Switch | 1.0h | € 45–€ 75 |
| Overdrive Solenoid | 2.0h | € 90–€ 150 |
| Shift Cable | 1.5h | € 67–€ 112 |
| Shift Linkage | 1.0h | € 45–€ 75 |
| Shift Solenoid - Single | 3.6h | € 162–€ 270 |
| Shift Solenoids - All | 7.8h | € 351–€ 585 |
| Torque Converter | 6.0h | € 270–€ 450 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
📋 RECALLS & TSB (2)
NHTSA 05V183000
Steering › Linkages › Tie Rod Assembly
Date: 28/04/2005
ON CERTAIN PASSENGER VEHICLES, THE STEERING TIE RODS MAY HAVE A MANUFACTURING FLAW THAT AFFECTS THE METALLURGY.
NHTSA 11V256000
Fuel System, Other › Storage › Tank Assembly › Mounting
Date: 25/04/2011
KIA IS RECALLING CERTAIN MODEL YEAR 2004-2007 SPECTRA LD VEHICLES MANUFACTURED FROM NOVEMBER 7, 2003, THROUGH MARCH 6, 2007, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, …
COMMON OBD2 CODES TO CHECK
P0420
Catalyst System Efficiency Below Threshold Bank 1
Powertrain
P0171
System Too Lean Bank 1
Powertrain
P0300
Random/Multiple Cylinder Misfire Detected
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
Coolant Thermostat Below Regulating Temperature
Powertrain
P0455
EVAP System Leak Detected (Gross Leak)
Powertrain
P0700
Transmission Control System (MIL Request)
Powertrain
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1123
powertrain
MODERATEP1693
powertrain
MODERATEP1611
powertrain
LOWP1586
powertrain
MODERATEP1307
powertrain
LOWP1295
powertrain
HIGHP1147
powertrain
HIGHP1118
powertrain
HIGHP1166
powertrain
MODERATEP1505
powertrain
MODERATEP1124
powertrain
MODERATEP1608
powertrain
CRITICALP1151
powertrain
HIGHP1440
powertrain
LOWP1110
powertrain
HIGHP1506
powertrain
MODERATEP1523
powertrain
LOWP1155
powertrain
HIGHP1134
powertrain
MODERATEP1111
powertrain
LOW
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
56 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
LDWS Fault (Kia)ADAS
AEB Fault (Kia)ADAS
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
Drive Mode (Kia)Engine
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
949 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Kia Spectra across model years 2000–2009. These are real, verified reports submitted by vehicle owners.
190 crash reports 20 fires 162 injuries 6 deaths
Complaints by model year (most reported first)
Model year 2007162
Model year 2008136
Model year 2006118
Model year 2009114
Model year 2005103
Model year 200292
Model year 200390
Model year 200471
Most reported components (all years)
Air Bags383
Electrical System87
Service Brakes82
Power Train78
Vehicle Speed Control69
Seat Belts54
Sample reports
My car seems like someone entered something in my gas tank while i may been in the store (MY 2009)
TL* THE CONTACT OWNS A 2006 KIA SPECTRA. THE CONTACT STATED THAT A BURNING ODOR WAS PRESENT IN THE VEHICLE AND THE HEAT BLOWER WOULD NOT OPERATE. THE CONTACT INDICATED THAT SHE WAS UNABLE TO DEFROST THE FRONT WINDSHIELD BECAUSE THE HEAT… (MY 2006)
THE AIRBAG LIGHT IN THE DASHBOARD STAYS ON AT ALL TIMES. I TOOK IT TO THE DEALER AND THE COST TO REPAIR IS OVER $1,600. I AM GETTING IT REPAIRED, SINCE THIS IS A SAFETY ISSUE. THE MANUFACTURER DID NOT INCLUDE ANY INFORMATION ABOUT THE AI… (MY 2008)
TL* THE CONTACT OWNED A 2005 KIA SPECTRA. WHILE DRIVING 45 MPH, THE CONTACT NOTICED THAT THE BRAKE PEDAL WAS STIFF WHEN IT WAS DEPRESSED. THE BRAKES FAILED WITHOUT WARNING AND A CRASH OCCURRED. A POLICE REPORT WAS FILED AND THERE WERE NO… (MY 2005)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 2000–2009.
Frequently Asked Questions
Does the Kia Spectra have any safety recalls?
Yes — 2 official NHTSA recall campaign(s) affect this model, mainly: FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY:MOUNTING, STEERING:LINKAGES:TIE ROD ASSEMBLY. Check the recalls section for your exact year/VIN.
What does fault code P0003 mean on the Kia Spectra?
Fuel Volume Regulator Control Circuit Low This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0002 mean on the Kia Spectra?
Fuel Volume Regulator Control Circuit Range/Performance This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0001 mean on the Kia Spectra?
Fuel Volume Regulator Control Circuit/Open This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are engine problems common on the Kia Spectra?
Yes — 158 of 928 real owner reports filed with NHTSA mention the engine. One owner reported: “ENGINE OVERHEATS A LOT.WHEN I START THE CAR AT TIME SMOKE CAME FROM UNDER NEAT OF THE STEERING WHEEL. AC LINE FROZEN . COOLING FAN NOT WORKING. FIRST TIME THEY REPLACED JUNCTION BLOCK, SECOND TIME TH…” See the owner-reported complaints section below for more.
Are electrical problems common on the Kia Spectra?
Yes — 334 of 928 real owner reports filed with NHTSA mention the electrical. One owner reported: “THE AIR BAG LIGHT KEEP COMING ON AFTER STARTING THE CAR. FIRST TIME I WAS TOLD IT'S THE CLOCK SPRING,SECOND TIME IT WAS THE AIR BAG MODULE ,THIRD TIME I WAS TOLD IT WAS THE CLOCKY SPRING MODULE AGAIN.…” See the owner-reported complaints section below for more.
Are airbags problems common on the Kia Spectra?
Yes — 375 of 928 real owner reports filed with NHTSA mention the airbags. One owner reported: “MY WIFE WAS DRIVING OUR 2000 KIA SPECTRA WHEN THE CLAM SHELL (STEERING COLUMN COVER) CAME APART WHILE SHE WAS MAKING A TURN. THE TOP PIECE PULL A WIRE LOOSE CAUSING THE AIR BAG INDICATOR TO COME ON, …” See the owner-reported complaints section below for more.
Which OBD2 fault codes are commonly documented for the Kia Spectra (2000–2009)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Kia Spectra (2000–2009) be serviced?
Routine maintenance for the Kia Spectra (2000–2009) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Considering buying a Kia Spectra (2000–2009)? Use this guide to check expected maintenance costs, the most reported fault codes and parts availability on the market. Real data, zero commercial estimates.