TroubleAtlas Score
MAZDA 929 (1990–1995) Manual — Codes, Tyres & Parts
Built 1990–1995 · all production years covered on this single page
3.0L V6 • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Mazda 929 (1990–1995) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost7.7
Parts & repairability7.3
Maintenance & durabilityn/a
Documentation & support4.5
Independent · Verified · Never for sale
Every figure on this Mazda 929 (1990–1995) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Mazda 929 (1990–1995) is powered by a 3.0L V6 engine. Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Related codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Related codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Related codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Related codes: P0562
P0011LOW
Check with an OBD2 scanner.
Related codes: P0011
COMMON REPAIRS
Front brake pads
Difficulty: Easy
0.8h
€56 – €72
Rear brake pads
Difficulty: Easy
0.9h
€63 – €81
Engine oil change
Difficulty: Easy
0.3h
€21 – €27
ABS Module
Difficulty: Medium
2.0h
€140 – €180
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.5h | € 112–€ 187 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 0.8h | € 36–€ 60 |
| ABS Wheel Speed Sensor - Rear | 0.8h | € 36–€ 60 |
| Brake Bleed - All Four | 1.0h | € 45–€ 75 |
| Brake Booster | 2.5h | € 112–€ 187 |
| Brake Booster Check Valve | 0.3h | € 13–€ 22 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.5h | € 67–€ 112 |
| Coolant Flush | 1.0h | € 45–€ 75 |
| Coolant Reservoir | 0.5h | € 22–€ 37 |
| Coolant Temperature Sensor | 0.5h | € 22–€ 37 |
| Cooling Fan Assembly | 1.0h | € 45–€ 75 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 0.3h | € 13–€ 22 |
| Engine Oil Cooler | 2.0h | € 90–€ 150 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.0h | € 45–€ 75 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 2.0h | € 90–€ 150 |
| Airbag Module/Computer | 1.0h | € 45–€ 75 |
| Alternator | 1.5h | € 67–€ 112 |
| Alternator Belt | 0.5h | € 22–€ 37 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Camshaft Position Sensor | 1.0h | € 45–€ 75 |
| Camshaft R&R | 8.0h | € 360–€ 600 |
| Connecting Rod Bearings | 15.0h | € 675–€ 1125 |
| Crankshaft Position Sensor | 1.0h | € 45–€ 75 |
| Crankshaft R&R | 20.0h | € 900–€ 1500 |
| Cylinder Head R&R | 6.0h | € 270–€ 450 |
| Cylinder Head Resurface | 8.0h | € 360–€ 600 |
| Engine Mount - Front | 1.5h | € 67–€ 112 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 0.8h | € 36–€ 60 |
| Catalytic Converter - California | 1.5h | € 67–€ 112 |
| Catalytic Converter - Direct Fit | 1.5h | € 67–€ 112 |
| Catalytic Converter - Universal | 2.0h | € 90–€ 150 |
| Downpipe | 2.0h | € 90–€ 150 |
| EGR Cooler | 3.0h | € 135–€ 225 |
| EGR Tube | 1.5h | € 67–€ 112 |
| EGR Valve | 1.0h | € 45–€ 75 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.0h | € 45–€ 75 |
| EVAP Purge Valve | 0.8h | € 36–€ 60 |
| EVAP Vent Valve | 0.8h | € 36–€ 60 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 1.5h | € 67–€ 112 |
| Fuel Filter | 0.5h | € 22–€ 37 |
| Fuel Filter - In-Tank | 2.0h | € 90–€ 150 |
| Fuel Injector - Single | 1.0h | € 45–€ 75 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.5h | € 67–€ 112 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.5h | € 112–€ 187 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 0.5h | € 22–€ 37 |
| AC Condenser | 2.5h | € 112–€ 187 |
| AC Evaporator | 6.0h | € 270–€ 450 |
| AC Expansion Valve (TXV) | 4.0h | € 180–€ 300 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 2.5h | € 112–€ 187 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.2h | € 54–€ 90 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 3.5h | € 157–€ 262 |
| Power Steering Hose - High Pressure | 1.0h | € 45–€ 75 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.0h | € 45–€ 75 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.0h | € 45–€ 75 |
| Air Suspension Valve Block | 2.0h | € 90–€ 150 |
| Ball Joint - Lower | 1.8h | € 81–€ 135 |
| Ball Joint - Upper | 1.5h | € 67–€ 112 |
| Ball Joints - Upper and Lower | 3.0h | € 135–€ 225 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Kickdown Cable | 0.8h | € 36–€ 60 |
| Neutral Safety Switch | 1.0h | € 45–€ 75 |
| Overdrive Solenoid | 2.0h | € 90–€ 150 |
| Shift Cable | 1.5h | € 67–€ 112 |
| Shift Linkage | 1.0h | € 45–€ 75 |
| Transmission Control Module | 1.0h | € 45–€ 75 |
| Transmission Cooler Lines | 1.0h | € 45–€ 75 |
| Transmission Filter | 1.0h | € 45–€ 75 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
📋 RECALLS & TSB (2)
NHTSA 95V103005
Seat Belts › Front › Buckle Assembly
Date: 24/05/1995
THE FRONT SAFETY BELT BUCKLE RELEASE BUTTONS CAN BREAK. THESE RED PLASTIC RELEASE BUTTONS ARE MARKED "PRESS." IF A BUTTON BREAKS, PIECES CAN FALL INTO THE BUCKLE ASSEMBLY CAUSING THE BUCKLE TO OPERATE IMPROPERLY.
NHTSA 15V674000
Electrical System › Ignition › Switch
Date: 19/10/2015
Mazda North American Operations (Mazda) is recalling certain model year 1989-1998 MPV, 1990-1995 323, 1990-1998 Protege, 1992-1993 MX-3, 1993-1995 929, 1993-1997 MX-6, and 1993-1998 626 vehicles. In the affected vehicles, grease applied to the contact points inside the ignition …
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P0455
powertrain
LOW⏱ 0.62h avgP0442
powertrain
LOW⏱ 0.62h avgP0440
powertrain
LOW⏱ 0.78h avgP0420
powertrain
MEDIUM⏱ 1.24h avgP0300
powertrain
HIGH⏱ 1.22h avgP0172
powertrain
MEDIUM⏱ 1.13h avgP0171
powertrain
MEDIUM⏱ 0.95h avgP0730
transmission
MEDIUM⏱ 1.25h avgP0700
transmission
HIGH⏱ 1.25h avgP0401
powertrain
MEDIUM⏱ 1.25h avgP0011
powertrain
MEDIUM⏱ 5.4h avgU0100
network
HIGHP0562
electrical
MEDIUM⏱ 0.58h avgP0128
powertrain
MEDIUM⏱ 0.88h avg
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
56 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
i-ACTIVSENSE Fault (Mazda)ADAS
MRCC Fault (Mazda)ADAS
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
i-stop (Mazda)Engine
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
102 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Mazda 929 across model years 1990–1995. These are real, verified reports submitted by vehicle owners.
14 crash reports 2 fires 12 injuries
Complaints by model year (most reported first)
Model year 199236
Model year 199319
Model year 199118
Model year 199013
Model year 199413
Model year 19953
Most reported components (all years)
Service Brakes28
Hydraulic27
Engine And Engine Cooling14
Seat Belts10
Seats10
Visibility9
Sample reports
SMELL FUEL IN THE TRUNK AND INSIDE OF VEHICLE...SEARCHED INTERNET FORUM AND FOUND A LOT OF PEOPLE HAVING SIMILAR PROBLEMS ON SAME MODEL OF VEHICLE...*JB (MY 1991)
WINDSHIELD SHATTERED WHILE CLEANING SNOW FROM IT-NO ONE WAS INJURIED. TT (MY 1993)
BRAKE ROTORS WARP PREMATURELY DUE TO ASBESTOS FREE BRAKE PADS. *SKD (MY 1992)
BRAKE ROTORS WARPED, CAUSING BRAKES/FRONT END TO VIBRATE. 8AK (MY 1990)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 1990–1995.
Frequently Asked Questions
Does the Mazda 929 have any safety recalls?
Yes — 2 official NHTSA recall campaign(s) affect this model, mainly: SEAT BELTS:FRONT:BUCKLE ASSEMBLY, ELECTRICAL SYSTEM:IGNITION:SWITCH. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Mazda 929?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Mazda 929?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Mazda 929?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are airbags problems common on the Mazda 929?
Yes — 8 of 70 real owner reports filed with NHTSA mention the airbags. One owner reported: “THE CONSUMER STATED THE ENGINE ACCELERATED WITHOUT WARNING, AND JUMPED A CONCRETE BARRIER AND CRASHED INTO A BUILDING. UPON IMPACT, THE AIR BAGS FAILED TO DEPLOY. MAZDA DENIED ANY LIABILITY. DEALER …” See the owner-reported complaints section below for more.
Are engine problems common on the Mazda 929?
Yes — 11 of 70 real owner reports filed with NHTSA mention the engine. One owner reported: “ENGINE IS HESITATING AS IF IN NEUTRAL DUE TO TRANSMISIION SLIPPING. TRANSMISSION HAS BEEN REBUILT. *AK…” See the owner-reported complaints section below for more.
Are brakes problems common on the Mazda 929?
Yes — 16 of 70 real owner reports filed with NHTSA mention the brakes. One owner reported: “BRAKE ROTORS WARPED, CAUSING BRAKES/FRONT END TO VIBRATE. 8AK…” See the owner-reported complaints section below for more.
What tyres does the Mazda 929 (1990–1995) use?
The original OEM tyre size for the Mazda 929 (1990–1995) is 215/55 R16. Compatible alternative sizes: ["245/45R19"]. See the Tyres section on this page to compare offers from the main suppliers.
Which OBD2 fault codes are commonly documented for the Mazda 929 (1990–1995)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Mazda 929 (1990–1995) be serviced?
Routine maintenance for the Mazda 929 (1990–1995) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Considering buying a Mazda 929 (1990–1995)? Use this guide to check expected maintenance costs, the most reported fault codes and parts availability on the market. Real data, zero commercial estimates.