TroubleAtlas Score
MAZDA MAZDA6 (2003–2024): Full Technical Specs & OBD2 Diagnostics
Built 2003–2024 · all production years covered on this single page
2.5L I4 Turbo • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Mazda Mazda6 (2003–2024) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost5.8
Parts & repairability4.1
Maintenance & durabilityn/a
Documentation & support8.7
Independent · Verified · Never for sale
Every figure on this Mazda Mazda6 (2003–2024) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Mazda Mazda6 (2003–2024) is powered by a 2.5L I4 Turbo engine. Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Easy
0.8h
€56 – €72
Rear brake pads
Difficulty: Easy
0.9h
€63 – €81
Engine oil change
Difficulty: Easy
0.3h
€21 – €27
ABS Module
Difficulty: Medium
2.0h
€140 – €180
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.5h | € 112–€ 187 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 0.8h | € 36–€ 60 |
| ABS Wheel Speed Sensor - Rear | 0.8h | € 36–€ 60 |
| Brake Bleed - All Four | 1.0h | € 45–€ 75 |
| Brake Booster | 2.5h | € 112–€ 187 |
| Brake Booster Check Valve | 0.3h | € 13–€ 22 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.5h | € 67–€ 112 |
| Coolant Flush | 1.0h | € 45–€ 75 |
| Coolant Reservoir | 0.5h | € 22–€ 37 |
| Coolant Temperature Sensor | 0.5h | € 22–€ 37 |
| Cooling Fan Assembly | 1.0h | € 45–€ 75 |
| Cooling Fan Clutch | 1.0h | € 45–€ 75 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 0.3h | € 13–€ 22 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.0h | € 45–€ 75 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 2.0h | € 90–€ 150 |
| Airbag Module/Computer | 1.0h | € 45–€ 75 |
| Alternator | 1.5h | € 67–€ 112 |
| Alternator Belt | 0.5h | € 22–€ 37 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Boost Pressure Sensor | 0.5h | € 22–€ 37 |
| Camshaft Position Sensor | 1.0h | € 45–€ 75 |
| Camshaft R&R | 8.0h | € 360–€ 600 |
| Connecting Rod Bearings | 15.0h | € 675–€ 1125 |
| Crankshaft Position Sensor | 1.0h | € 45–€ 75 |
| Crankshaft R&R | 20.0h | € 900–€ 1500 |
| Cylinder Head R&R | 6.0h | € 270–€ 450 |
| Cylinder Head Resurface | 8.0h | € 360–€ 600 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 0.8h | € 36–€ 60 |
| Catalytic Converter - California | 1.5h | € 67–€ 112 |
| Catalytic Converter - Direct Fit | 1.5h | € 67–€ 112 |
| Catalytic Converter - Universal | 2.0h | € 90–€ 150 |
| Downpipe | 2.0h | € 90–€ 150 |
| EGR Cooler | 3.0h | € 135–€ 225 |
| EGR Tube | 1.5h | € 67–€ 112 |
| EGR Valve | 1.0h | € 45–€ 75 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.0h | € 45–€ 75 |
| EVAP Purge Valve | 0.8h | € 36–€ 60 |
| EVAP Vent Valve | 0.8h | € 36–€ 60 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 1.5h | € 67–€ 112 |
| Fuel Filter | 0.5h | € 22–€ 37 |
| Fuel Filter - In-Tank | 2.0h | € 90–€ 150 |
| Fuel Injector - Single | 1.0h | € 45–€ 75 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.5h | € 67–€ 112 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.5h | € 112–€ 187 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 0.5h | € 22–€ 37 |
| AC Condenser | 2.5h | € 112–€ 187 |
| AC Evaporator | 6.0h | € 270–€ 450 |
| AC Expansion Valve (TXV) | 4.0h | € 180–€ 300 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 2.5h | € 112–€ 187 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.2h | € 54–€ 90 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 3.5h | € 157–€ 262 |
| Power Steering Hose - High Pressure | 1.0h | € 45–€ 75 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.0h | € 45–€ 75 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.0h | € 45–€ 75 |
| Air Suspension Valve Block | 2.0h | € 90–€ 150 |
| Ball Joint - Lower | 1.8h | € 81–€ 135 |
| Ball Joint - Upper | 1.5h | € 67–€ 112 |
| Ball Joints - Upper and Lower | 3.0h | € 135–€ 225 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Kickdown Cable | 0.8h | € 36–€ 60 |
| Neutral Safety Switch | 1.0h | € 45–€ 75 |
| Overdrive Solenoid | 2.0h | € 90–€ 150 |
| Shift Cable | 1.5h | € 67–€ 112 |
| Shift Linkage | 1.0h | € 45–€ 75 |
| Shift Solenoid - Single | 4.1h | € 184–€ 307 |
| Shift Solenoids - All | 9.0h | € 405–€ 675 |
| Torque Converter | 6.9h | € 310–€ 517 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
📋 RECALLS & TSB (30)
NHTSA 19V781000
Air Bags › Frontal › Passenger Side › Inflator Module
Date: 31/10/2019
Mazda North American Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2004-2005 MPV, 2004 RX-8, and 2006-2007 Mazdaspeed6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. …
NHTSA 19V782000
Air Bags › Frontal › Passenger Side › Inflator Module
Date: 31/10/2019
Mazda North American Operations (Mazda) is recalling certain 2007-2012 CX-7, CX-9, and 2009-2012 Maza6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode d…
NHTSA 17V429000
Air Bags › Frontal › Passenger Side › Inflator Module
Date: 29/06/2017
Mazda North America Operations (Mazda) is recalling certain 2009-2011 Mazda6, and 2007-2011 CX-7 and CX-9 vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacemen…
NHTSA 14V675000
Tires › Pressure Monitoring And Regulating Systems
Date: 27/10/2014
Mazda North American Operations (Mazda) is recalling certain model year 2014-2015 Mazda6 vehicles manufactured October 25, 2012, to October 10, 2014. If the pressures of four of the tires on an affected vehicle gradually drop at the same time, the tire pressure monitoring system…
NHTSA 19V497000
Engine
Date: 27/06/2019
Mazda North American Operations (Mazda) is recalling certain 2018-2019 CX-5, Mazda6, and 2019 Mazda3 vehicles. A software error in the powertrain control module (PCM) may cause the engine to stall.
NHTSA 17V474000
Air Bags › Frontal › Driver Side › Inflator Module
Date: 26/07/2017
Mazda North American Operations (Mazda) is recalling certain model year 2003-2008 Mazda6, 2004-2008 RX-8, and 2006-2007 Mazdaspeed6 vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other facto…
NHTSA 19V323000
Structure
Date: 25/04/2019
Mazda North American Operations (Mazda) is recalling certain 2011-2013 Mazda6 vehicles sold, or ever registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland,Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New …
NHTSA 11V134000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 25/02/2011
MAZDA IS RECALLING CERTAIN MODEL YEAR 2009-2010 MAZDA6 VEHICLES MANUFACTURED FROM APRIL 8, 2008, THROUGH FEBRUARY 8, 2010. A CERTAIN TYPE OF SPIDER MAY WEAVE A WEB IN THE EVAPORATIVE CANISTER VENT LINE AND THIS MAY CAUSE A RESTRICTION IN THE LINE. IF THIS OCCURS, THE FUEL TANK …
NHTSA 13V425000
Latches/Locks/Linkages › Doors › Latch
Date: 24/09/2013
Mazda is recalling certain model year 2009-2013 Mazda6 vehicles manufactured February 4, 2008, through August 24, 2012. The door latch mounting screws may become loose.
NHTSA 17V393000
Parking Brake
Date: 22/06/2017
Mazda North American Operations (Mazda) is recalling certain 2014-2015 Mazda6 and 2014-2016 Mazda3 vehicles. Water could possibly enter the brake caliper causing the parking brake actuator shaft to corrode and possibly bind.
NHTSA 16V753000
Exterior Lighting › Turn Signal
Date: 18/10/2016
Mazda North American Operations (Mazda) is recalling certain model year 2017 Mazda6 vehicles manufactured August 12, 2016, to September 28, 2016 and equipped with optional accessory fog lights. Due to an incorrect combination switch being installed, the turn signals may not auto…
NHTSA 17V457000
Air Bags › Frontal › Passenger Side › Inflator Module
Date: 18/07/2017
Mazda North America Operations (Mazda) is recalling certain 2012 CX-7, CX-9 and Mazda6 vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern…
NHTSA 03V531000
Fuel System, Gasoline › Delivery
Date: 16/12/2003
ON CERTAIN PASSENGER VEHICLES, THE FUEL SENDER UNIT (FSU) MAY HAVE BEEN IMPROPERLY INSTALLED IN THE FUEL TANK, PRODUCING AN INADEQUATE SEAL, AND FUEL MAY LEAK.
NHTSA 08V412000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 15/08/2008
MAZDA IS RECALLING 7,200 MY 2007-2008 MAZDA6 VEHICLES WITH CALIFORNIA EMISSION SPECIFICATIONS. THE METAL FUEL TANKS ON THE AFFECTED VEHICLES MAY HAVE HAD THE PVC PROTECTIVE COATING ON THE OUTSIDE OF THE FUEL TANK DAMAGED DURING THE ASSEMBLY PROCESS WHICH MAY RESULT IN REDUCED CO…
NHTSA 18V402000
Air Bags › Frontal › Passenger Side › Inflator Module
Date: 15/06/2018
Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, H…
NHTSA 18V631000
Suspension › Front › Control Arm
Date: 14/09/2018
Mazda North American Operations (Mazda) is recalling certain 2009-2010 Mazda Mazda6 vehicles sold, or ever registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, O…
NHTSA 21V875000
Fuel System, Gasoline › Delivery › Fuel Pump
Date: 12/11/2021
Mazda North American Operations (Mazda) is recalling certain 2018 Mazda3, Mazda6, 2019 CX-3, 2018-2019 MX-5, CX-5, CX-9, and 2019-2020 Mazda2 vehicles. The impeller inside the low-pressure fuel pump may crack and deform, potentially causing the fuel pump to fail.
NHTSA 18V717000
Air Bags › Frontal › Passenger Side › Inflator Module
Date: 12/10/2018
Mazda North American Operations (Mazda) is recalling certain 2014-2015 Mazda CX-9 vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Maria…
NHTSA 16V594000
Air Bags › Frontal › Sensor/Control Module-Inactive
Date: 11/08/2016
Mazda North American Operations (Mazda) is recalling certain model year 2009-2010 Mazda6 vehicles manufactured February 4, 2008, to December 3, 2009. The protective coating may not have been properly applied to the air bag control unit (ACU) and, as a result, moisture may damage…
NHTSA 09E025000
Exterior Lighting › Headlights
Date: 11/05/2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
NHTSA 14V114000
Fuel System, Gasoline
Date: 11/03/2014
Mazda North America Operations (Mazda) is recalling certain model year 2010-2012 Mazda6 vehicles manufactured September 14, 2009, through May 2, 2011, and equipped with 2.5L engine. In the affected vehicles, spiders may weave a web in the evaporative canister vent hose, blocking…
NHTSA 04V582000
Seat Belts › Rear/Other
Date: 10/12/2004
ON CERTAIN PASSENGER VEHICLES, THE RIGHT AND/OR LEFT REAR SEAT BELTS MAY NOT LOCK PROPERLY DUE TO MISSING RETAINING PINS ON THE HOUSING.
NHTSA 18V018000
Air Bags › Frontal › Passenger Side › Inflator Module
Date: 09/01/2018
Mazda North American Operations (Mazda) is recalling certain 2013 Mazda6 and CX-9 vehicles sold, or ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Maria…
NHTSA 09E012000
Exterior Lighting
Date: 07/04/2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
NHTSA 03V207000
Parking Brake › Indicator Light
Date: 05/06/2003
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "PASSENGER CAR BRAKE SYSTEMS." DURING PRODUCTION, THE FLOAT IN THE FLUID LEVEL SENSOR IN THE BRAKE RESERVOIR CAN BE FORCED OFF OF THE GUIDE RAIL DURING THE FILLING OF TH…
NHTSA 03V206000
Exterior Lighting › Fog Lights
Date: 05/06/2003
ON CERTAIN MINI VANS AND PASSENGER VEHICLES, THE SOCKET HOLDER IN THE FOG LIGHTS IS INSTALLED IN THE LAMP CASING USING PRESSURE. DURING OPERATION OF THE FOG LIGHT, THE HEAT FROM THE BULB CAN EXPAND THE SOCKET HOLDER. THE EXPANSION CAN FORCE THE SOCKET HOLDER REARWARD. AFTER RE…
NHTSA 09V043000
Structure › Body › Door › Hinge And Attachments
Date: 04/02/2009
MAZDA IS RECALLING 29,000 MY 2009 MAZDA6. THE OUTER DOOR HANDLES MAY STICK WHICH MAY PREVENT THE DOOR FROM LATCHING. THIS SITUATION MAY ALLOW THE DOOR TO OPEN WHILE THE VEHICLE IS IN MOTION.
NHTSA 14V173000
Electrical System › Alternator/Generator/Regulator
Date: 03/04/2014
Mazda North America Operations (Mazda) is recalling certain model year 2014 Mazda3 vehicles manufactured June 12, 2013, through December 18, 2013, and model year 2014-2015 Mazda6 vehicles manufactured May 20, 2013, through December 4, 2013, and both equipped with a 2.5L engine an…
NHTSA 14V170000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 03/04/2014
Mazda North America Operations (Mazda) is recalling certain model year 2014 Mazda6 vehicles manufactured October 25, 2012, through May 9, 2013. In the affected vehicles, it is possible to fill the fuel tank beyond its rated capacity.
NHTSA 09E011000
Equipment
Date: 02/04/2009
THULE, INC. IS RECALLING 2,323 OWNER-INSTALLED ROOF-MOUNTED FIT KITS, MODELS 3068 AND 3069, MANUFACTURED BETWEEN JANUARY 1, 2008 AND FEBRUARY 28, 2009 THAT ARE USED WITH THULE PODIUM FOOT PACKS, MODELS 460 AND 460R. THESE FIT KITS WERE SOLD AS AFTERMARKET EQUIPMENT FOR USE ON TH…
COMMON OBD2 CODES TO CHECK
P0420
Catalyst System Efficiency Below Threshold Bank 1
Powertrain
P0171
System Too Lean Bank 1
Powertrain
P0300
Random/Multiple Cylinder Misfire Detected
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
Coolant Thermostat Below Regulating Temperature
Powertrain
P0455
EVAP System Leak Detected (Gross Leak)
Powertrain
P0700
Transmission Control System (MIL Request)
Powertrain
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1504
powertrain
MODERATEP1309
powertrain
HIGHP1132
powertrain
MODERATEP1744
powertrain
MODERATEP1260
powertrain
CRITICALP1000
powertrain
LOWP1512
powertrain
LOWP1131
powertrain
MODERATEP1780
powertrain
LOWP1631
powertrain
HIGHP1450
powertrain
MODERATEP1506
powertrain
MODERATEP1443
powertrain
LOWP1507
powertrain
MODERATEP1101
powertrain
MODERATEP1401
powertrain
MODERATEP1605
powertrain
MODERATEP1345
powertrain
CRITICALP1633
powertrain
LOWP1600
powertrain
LOW
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
56 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
i-ACTIVSENSE Fault (Mazda)ADAS
MRCC Fault (Mazda)ADAS
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
i-stop (Mazda)Engine
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
2006 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Mazda Mazda6 across model years 2003–2024. These are real, verified reports submitted by vehicle owners.
111 crash reports 26 fires 82 injuries 2 deaths
Complaints by model year (most reported first)
Model year 2009385
Model year 2010224
Model year 2006193
Model year 2003175
Model year 2007165
Model year 2004159
Model year 2005147
Model year 2011132
Most reported components (all years)
Air Bags616
Structure266
Suspension201
Unknown Or Other189
Electrical System184
Power Train157
Sample reports
TL* THE CONTACT OWNS A 2006 MAZDA MAZDASPEED6 . THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE TRANSMISSION WOULD SLIP INTO NEUTRAL WITHOUT WARNING. THE CONTACT MENTIONED THAT WHILE DECELERATING TO ATTEMPT A TURN, THE VEHIC… (MY 2006)
TL*THE CONTACT OWNS A 2006 MAZDA 6. WHILE DRIVING 55 MPH IN SIXTH GEAR, THE VEHICLE MAKES A LOUD NOISE AND SUDDENLY DOWNSHIFTS INTO THIRD GEAR. THE VEHICLE HAS BEEN TO THE DEALER SEVERAL TIMES AND THEY REPLACED THE VALVE BODY AND FLUSH… (MY 2006)
2013 Mazda 6 VIN [XXX] 1)Fuel tank leak. yes it is available for inspection 2)Gas leak with danger of fire or explosion. 3) Yes 4) No 5)Yes Reoccurring The 2014 Mazda 6 had a recall for the exact same problem I am having where the tan… (MY 2013)
TL* TAKATA RECALL. THE CONTACT OWNS A 2006 MAZDA 6. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V781000 (AIR BAGS). THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY RECALLED AND REPAIRED IN 2016 PER NHTSA CAMPAIGN NUM… (MY 2006)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 2003–2024.
Frequently Asked Questions
Does the Mazda Mazda6 have any safety recalls?
Yes — 30 official NHTSA recall campaign(s) affect this model, mainly: AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE, AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE, EXTERIOR LIGHTING. Check the recalls section for your exact year/VIN.
What does fault code P0003 mean on the Mazda Mazda6?
Fuel Volume Regulator Control Circuit Low This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0002 mean on the Mazda Mazda6?
Fuel Volume Regulator Control Circuit Range/Performance This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0001 mean on the Mazda Mazda6?
Fuel Volume Regulator Control Circuit/Open This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are engine problems common on the Mazda Mazda6?
Yes — 273 of 1950 real owner reports filed with NHTSA mention the engine. One owner reported: “2003 MAZDA6 MODEL CARS WERE BUILT WITH FAULTY THROTTLE BODIES. UNAWARE OF THIS, I BOUGHT ONE OF THESE VEHICLES AND IMMEDIATELY BEGAN EXPERIENCING ISSUES WITH IT. WHEN DRIVING VERY SLOWLY, UNDER 15 …” See the owner-reported complaints section below for more.
Are electrical problems common on the Mazda Mazda6?
Yes — 505 of 1950 real owner reports filed with NHTSA mention the electrical. One owner reported: “TL* THE CONTACT OWNS A 2003 MAZDA 6. WHILE BACKING OUT OF A PARKING SPACE, THE STEERING WHEEL REQUIRED MORE FORCE TO STEER AND THE ELECTRONIC POWER STEERING WARNING LIGHT ILLUMINATED. THE CONTACT REST…” See the owner-reported complaints section below for more.
Are airbags problems common on the Mazda Mazda6?
Yes — 583 of 1950 real owner reports filed with NHTSA mention the airbags. One owner reported: “ON 01/18/2019 I TOOK VEHICLE I PURCHASED, TO MOCK FORD IN GRANT'S PASS OREGON FOR TAKARA AIRBAG RECALL. THIS IS WHEN I BECAME AWARE OF SAFETY ISSUE THAT VEHICLES AUR BAGS HAD BEEN CUT OUT AND REMOVE…” See the owner-reported complaints section below for more.
What tyres does the Mazda Mazda6 (2003–2024) use?
The original OEM tyre size for the Mazda Mazda6 (2003–2024) is 215/55 R16. Compatible alternative sizes: ["245/45R19", "225/55R17", "225/50R18"]. See the Tyres section on this page to compare offers from the main suppliers.
Which OBD2 fault codes are commonly documented for the Mazda Mazda6 (2003–2024)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Mazda Mazda6 (2003–2024) be serviced?
Routine maintenance for the Mazda Mazda6 (2003–2024) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Found what you were looking for? Explore other Mazda models in our database, compare tyre offers in your size, or search a specific fault code in the TroubleAtlas OBD2 database.