TroubleAtlas Score
MERCURY CAPRI (1990–1995): Technical Data, DTC & Service Schedule
Built 1990–1995 · all production years covered on this single page
1.6 turbo (132 Hp) • Petrol (Gasoline)
1995
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Mercury Capri (1990–1995) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair costn/a
Parts & repairability7.3
Maintenance & durabilityn/a
Documentation & supportn/a
Independent · Verified · Never for sale
Every figure on this Mercury Capri (1990–1995) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Mercury Capri (1990–1995) is powered by a 1.6 turbo (132 Hp) engine. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Related codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Related codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Related codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Related codes: P0562
P0011LOW
Check with an OBD2 scanner.
Related codes: P0011
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (5)
NHTSA 91V009000
Power Train › Automatic Transmission › Cooling Unit And Lines
Date: 08/01/1991
THE RUBBER TUBE THAT CONNECTS THE TRANSMISSION TO THE TRANSMISSION OIL COOLER (IN THE RADIATOR) MAY DISCONNECT CAUSING DISCHARGE OF FLUID.
NHTSA 93V180000
Power Train › Automatic Transmission › Cooling Unit And Lines
Date: 05/11/1993
THE TRANSMISSION FLUID RUBBER TUBE CONNECTING THE TRANSMISSION TO THE TRANSMISSION OIL COOLER LOCATED IN THE RADIATOR CAN BECOME DISCONNECTED FROM THE TRANSMISSION, RESULTING IN DISCHARGE OF TRANSMISSION FLUID.
NHTSA 07V336000
Vehicle Speed Control
Date: 03/08/2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
NHTSA 92V080000
Air Bags
Date: 02/06/1992
THE AIR BAG MODULES DO NOT MEET THE FORD SPECIFICATIONS FOR HIGH AMBIENT TEMPERATURE PERFORMANCE.
NHTSA 92V080000
Air Bags
Date: 02/06/1992
THE AIR BAG MODULES DO NOT MEET THE FORD SPECIFICATIONS FOR HIGH AMBIENT TEMPERATURE PERFORMANCE.
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P0455
powertrain
LOW⏱ 0.62h avgP0442
powertrain
LOW⏱ 0.62h avgP0440
powertrain
LOW⏱ 0.78h avgP0420
powertrain
MEDIUM⏱ 1.24h avgP0300
powertrain
HIGH⏱ 1.22h avgP0172
powertrain
MEDIUM⏱ 1.13h avgP0171
powertrain
MEDIUM⏱ 0.95h avgP0730
transmission
MEDIUM⏱ 1.25h avgP0700
transmission
HIGH⏱ 1.25h avgP0401
powertrain
MEDIUM⏱ 1.25h avgP0011
powertrain
MEDIUM⏱ 5.4h avgU0100
network
HIGHP0562
electrical
MEDIUM⏱ 0.58h avgP0128
powertrain
MEDIUM⏱ 0.88h avg
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
48 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Mercury Capri across model years 1990–1995. These are real, verified reports submitted by vehicle owners.
4 crash reports 4 fires 3 injuries
Complaints by model year (most reported first)
Model year 199133
Model year 19927
Model year 19935
Model year 19943
Most reported components (all years)
Power Train10
Engine And Engine Cooling8
Air Bags7
Structure6
Electrical System5
Visibility5
Sample reports
NO DEPLOYMENT OF DRIVER'S AIR BAG TWICE DURING TWO ACCIDENTS. *SKD (MY 1991)
TOOK VEHICLE TO DEALER. WAS INFORMED BY MECHANIC NO PARTS AVAILABLE FOR NEUTRAL SAFETY SWITCH. THE PART WAS DISCONTINUED BY MANUFACTURER. THE SWITCH IS USED TO PUT VEHICLE IN EITHER PARK, NEUTRAL OR DRIVE. *AK (MY 1991)
TRANSMISSION FAILED. (MY 1991)
TRANS AXLE FAILED. (MY 1991)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 1990–1995.
Frequently Asked Questions
Does the Mercury Capri have any safety recalls?
Yes — 5 official NHTSA recall campaign(s) affect this model, mainly: POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES, AIR BAGS, VEHICLE SPEED CONTROL. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Mercury Capri?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Mercury Capri?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Mercury Capri?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are transmission problems common on the Mercury Capri?
Yes — 5 of 31 real owner reports filed with NHTSA mention the transmission. One owner reported: “CONSUMER HAD 4 TRANSMISSIONS REPLACED SINCE 1996. CAUSE OF PREMATURE FAILURE IS UNKNOWN. ALSO, AIRBAG LIGHT STAYS ON.*AK…” See the owner-reported complaints section below for more.
Are airbags problems common on the Mercury Capri?
Yes — 6 of 31 real owner reports filed with NHTSA mention the airbags. One owner reported: “VEHICLE COLLIDED HEAD-ON WITH A POLE TRAVELING APPROXIMATELY 60MPH. CONSUMER STATES THAT DRIVER'S FRONT AIR BAG 'EXPLODED', CRACKING THE FRONT WINDSHIELD, AND CAUSING INJURY TO DRIVER'S HEAD, CHIN, …” See the owner-reported complaints section below for more.
Are engine problems common on the Mercury Capri?
Yes — 7 of 31 real owner reports filed with NHTSA mention the engine. One owner reported: “DRIVING, THEN COMING TO A STOP OR SLOWING DOWN, WHEN SUDDENLY THE ENGINE STOPS RUNNING, AND WILL NOT RE-START. AT FIRST IT RESTARTED AFTER ABOUT 4 HOURS. NEXT WHEN IT HAD HAPPENED IT DID NOT RESTART U…” See the owner-reported complaints section below for more.
Which OBD2 fault codes are commonly documented for the Mercury Capri (1990–1995)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Mercury Capri (1990–1995) be serviced?
Routine maintenance for the Mercury Capri (1990–1995) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Found what you were looking for? Explore other Mercury models in our database, compare tyre offers in your size, or search a specific fault code in the TroubleAtlas OBD2 database.