PEUGEOT 505 (1979–1994) — Technical Guide, Fault Codes & Maintenance
Built 1979–1994 · all production years covered on this single page
1994
© Wikimedia Commons CC BY-SA
Every figure on this Peugeot 505 (1979–1994) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Peugeot 505 (1979–1994). Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Related codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Related codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Related codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Related codes: P0562
P0011LOW
Check with an OBD2 scanner.
Related codes: P0011
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (9)
NHTSA 84V151000
Fuel System, Gasoline › Storage › Tank Assembly › Filler Pipe And Cap
Date: 26/11/1984
THE FUEL CAPS ON THE INVOLVED VEHICLES DO NOT SEAL PROPERLY AND ARE NOT IN COMPLIANCE WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY." CONTACT WITH FUEL CAUSES THE FUEL CAP GASKET TO SWELL, PREVENTING ADEQUATE SEALING BETWEEN CAP AND FILLER OPENING.
NHTSA 84V151000
Fuel System, Gasoline › Storage › Tank Assembly › Filler Pipe And Cap
Date: 26/11/1984
THE FUEL CAPS ON THE INVOLVED VEHICLES DO NOT SEAL PROPERLY AND ARE NOT IN COMPLIANCE WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY." CONTACT WITH FUEL CAUSES THE FUEL CAP GASKET TO SWELL, PREVENTING ADEQUATE SEALING BETWEEN CAP AND FILLER OPENING.
NHTSA 89V231000
Equipment › Other › Labels
Date: 14/12/1989
POSSIBLE OVERLOADING OF REAR AXLE IF THE VEHICLE IS LOADED WITH 8 PEOPLE PLUS CARGO.
NHTSA 96V028000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 05/01/1996
THE CORROSION PROTECTION OF THE FUEL TANK MOUNTING DETERIORATES ALLOWING WATER AND FOREIGN MATERIAL TO CORRODE THE TANK MOUNTING FLANGE DIRECTLY.
NHTSA 96V028000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 05/01/1996
THE CORROSION PROTECTION OF THE FUEL TANK MOUNTING DETERIORATES ALLOWING WATER AND FOREIGN MATERIAL TO CORRODE THE TANK MOUNTING FLANGE DIRECTLY.
NHTSA 96V028000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 05/01/1996
THE CORROSION PROTECTION OF THE FUEL TANK MOUNTING DETERIORATES ALLOWING WATER AND FOREIGN MATERIAL TO CORRODE THE TANK MOUNTING FLANGE DIRECTLY.
NHTSA 96V028000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 05/01/1996
THE CORROSION PROTECTION OF THE FUEL TANK MOUNTING DETERIORATES ALLOWING WATER AND FOREIGN MATERIAL TO CORRODE THE TANK MOUNTING FLANGE DIRECTLY.
NHTSA 96V028000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 05/01/1996
THE CORROSION PROTECTION OF THE FUEL TANK MOUNTING DETERIORATES ALLOWING WATER AND FOREIGN MATERIAL TO CORRODE THE TANK MOUNTING FLANGE DIRECTLY.
NHTSA 86V019000
Electrical System
Date: 05/01/1986
RETAINING BOLTS USED THROUGHOUT THE CAR WHICH GROUND CERTAIN ELECTRICAL SYSTEMS AND COMPONENTS WERE IMPROPERLY HEAT TREATED, MAKING THE BOLTS BRITTLE AND SUBJECT TO BREAKAGE. …
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P0455
powertrain
LOW⏱ 0.62h avgP0442
powertrain
LOW⏱ 0.62h avgP0440
powertrain
LOW⏱ 0.78h avgP0420
powertrain
MEDIUM⏱ 1.24h avgP0300
powertrain
HIGH⏱ 1.22h avgP0172
powertrain
MEDIUM⏱ 1.13h avgP0171
powertrain
MEDIUM⏱ 0.95h avgP0730
transmission
MEDIUM⏱ 1.25h avgP0700
transmission
HIGH⏱ 1.25h avgP0401
powertrain
MEDIUM⏱ 1.25h avgP0011
powertrain
MEDIUM⏱ 5.4h avgU0100
network
HIGHP0562
electrical
MEDIUM⏱ 0.58h avgP0128
powertrain
MEDIUM⏱ 0.88h avg
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
6 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Peugeot 505 across model years 1979–1994. These are real, verified reports submitted by vehicle owners.
1 fire
Complaints by model year (most reported first)
Model year 19892
Model year 19821
Model year 19851
Model year 19861
Model year 19881
Most reported components (all years)
Electrical System2
Fuel System2
Gasoline2
Power Train1
Tires1
Sample reports
FUEL TANK HAS METAL BRACKET THAT SUPPORTS TANK. AT FRONT RUBBER PIECE CONNECTS THE TWO BROKE RESULTING IN GAS TANK HITTING GROUND WHILE IN MOTION. TT (MY 1989)
GAS TANK BOLT RUSTED OUT, RESULTING IN GAS TANK DISCONNETED AND FELL DOWN. TT (MY 1989)
WHILE PARKED, WIRING UNDER THE HOOD IGNITED, RESULTIN GIN AN ELECTRICAL FIRE. *AK (MY 1985)
I BOUGHT 5 KELLY ULTRA TECH 175R14 TIRES FROM COKER TIRES. 1317 CHESTNUT STREET, CHATTANOOGA, TN. 37402. 5/28/2002 ORIGINAL ORDER NUMBER 901887. I HAVE HAD NOTHING BUT PROBLEMS WITH THESE TIRES DEVELOPING BULGES ON THE TREADS. THEY REPLA… (MY 1986)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 1979–1994.
Frequently Asked Questions
Does the Peugeot 505 have any safety recalls?
Yes — 9 official NHTSA recall campaign(s) affect this model, mainly: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP, ELECTRICAL SYSTEM. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Peugeot 505?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Peugeot 505?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Peugeot 505?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Which OBD2 fault codes are commonly documented for the Peugeot 505 (1979–1994)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Peugeot 505 (1979–1994) be serviced?
Routine maintenance for the Peugeot 505 (1979–1994) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Bookmark this page to consult it at the workshop or when buying parts. TroubleAtlas updates its technical data continuously — check back for new information on the Peugeot 505 (1979–1994).