SATURN RELAY (2005–2007)
SATURN RELAY (2005–2007) — Verified Specs, Fluids & OBD2
Built 2005–2007 · all production years covered on this single page
3.5L V6 • Gasoline
2007
🚗 Saturn RELAY 2007
Every figure on this Saturn Relay (2005–2007) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Saturn Relay (2005–2007) is powered by a 3.5L V6 engine. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Related codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Related codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Related codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Related codes: P0562
P0011LOW
Check with an OBD2 scanner.
Related codes: P0011
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (6)
NHTSA 05V287000
Parking Brake
Date: 20/06/2005
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND TH…
NHTSA 05V061000
Seats › Mid/Rear Assembly
Date: 18/02/2005
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT …
NHTSA 09E005000
Steering
Date: 17/02/2009
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONSTM" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DE…
NHTSA 09E005000
Steering
Date: 17/02/2009
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONSTM" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DE…
NHTSA 09E005000
Steering
Date: 17/02/2009
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONSTM" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DE…
NHTSA 05V552000
Equipment › Other › Labels
Date: 07/12/2005
CERTAIN TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SHIPPED WITH TIRE AND LOADING INFORMATION LABELS LISTING AN INACCCURATE VEHICLE CAPACITY WEIGHT.
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P0455
powertrain
LOW⏱ 0.62h avgP0442
powertrain
LOW⏱ 0.62h avgP0440
powertrain
LOW⏱ 0.78h avgP0420
powertrain
MEDIUM⏱ 1.24h avgP0300
powertrain
HIGH⏱ 1.22h avgP0172
powertrain
MEDIUM⏱ 1.13h avgP0171
powertrain
MEDIUM⏱ 0.95h avgP0730
transmission
MEDIUM⏱ 1.25h avgP0700
transmission
HIGH⏱ 1.25h avgP0401
powertrain
MEDIUM⏱ 1.25h avgP0011
powertrain
MEDIUM⏱ 5.4h avgU0100
network
HIGHP0562
electrical
MEDIUM⏱ 0.58h avgP0128
powertrain
MEDIUM⏱ 0.88h avg
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
91 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Saturn Relay across model years 2005–2007. These are real, verified reports submitted by vehicle owners.
4 crash reports 1 fire 3 injuries
Complaints by model year (most reported first)
Model year 200560
Model year 200619
Model year 200712
Most reported components (all years)
Service Brakes34
Electrical System21
Hydraulic17
Structure14
Latches/Locks/Linkages9
Power Train7
Sample reports
TL* THE CONTACT OWNS A 2005 SATURN RELAY. WHILE DRIVING THE REAR SLIDING DOOR OPENED WITHOUT WARNING. HE PULLED OVER AND IT TOOK 10 MINUTES TO CLOSE THE DOOR. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE CENSORS AND MOTOR WERE REPLACED… (MY 2005)
TL*THE CONTACT OWNS A 2005 SATURN RELAY. WHILE DRIVING 35 MPH, THE DOOR ALARM SOUNDS AND INDICATES THAT BOTH REAR PASSENGER DOORS ARE OPEN. THE CONTACT MUST PULL THE VEHICLE OVER AND CLOSE THE DOORS. THE MANUFACTURER STATED THAT THE V… (MY 2005)
FUEL READ A LITTLE LESS THAN 1/4 OF A TANK. DRIVING 40 MPH DOWN THE STREET, ENGINE STOPPED. WOULD NOT START. TOWED HOME. PUT GAS IN IT AND IT STARTED. HAPPENED AGAIN ON DEC 20. DRIVING 70MPH ON THE INTERSTATE. FUEL GAUGE AT 1/4 TANK.… (MY 2005)
PURCHASED S 2005 SATURN RELAY IN APRIL 06. SINCE DAY ONE THINGS HAVE BEEN WRONG, BRAKE ROTORS WARPED, AXEL BROKEN, INTERIOR PARTS NEEDING REPLACEMENT AND NOW IT IS IN THE SHOP FOR WEEKS FOR TRANSMISSION PROBLEMS. I HAVE A FILE OPEN WIT… (MY 2005)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 2005–2007.
Frequently Asked Questions
Does the Saturn Relay have any safety recalls?
Yes — 6 official NHTSA recall campaign(s) affect this model, mainly: STEERING, EQUIPMENT:OTHER:LABELS, SEATS:MID/REAR ASSEMBLY. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Saturn Relay?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Saturn Relay?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Saturn Relay?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are steering problems common on the Saturn Relay?
Yes — 22 of 89 real owner reports filed with NHTSA mention the steering. One owner reported: “TL* THE CONTACT OWNS A 2005 SATURN RELAY. WHILE OPERATING THE VEHICLE, THE SPEED SENSOR AND TRACTION CONTROL SENSOR LIGHTS ILLUMINATED AND THE BRAKING DISTANCE INCREASED WHEN THE BRAKE PEDAL WAS DEPRE…” See the owner-reported complaints section below for more.
Are electrical problems common on the Saturn Relay?
Yes — 35 of 89 real owner reports filed with NHTSA mention the electrical. One owner reported: “EXACT SAME ISSUE AS DESCRIBED IN APRIL 2014 GM RECALL 14063. SUDDEN LOSS OF ELECTRICAL POWER WHILE DRIVING CAUSING THE ENGINE TO SHUT OFF. UNPREDICTABLE VERY DANGEROUS. SEEMS TO BE THE IGNITION SWITCH…” See the owner-reported complaints section below for more.
Are brakes problems common on the Saturn Relay?
Yes — 39 of 89 real owner reports filed with NHTSA mention the brakes. One owner reported: “THE ANTI-LOCK BRAKE SYSTEM WARNING LIGHT AND TRACTION CONTROL SYSTEM (TCS) WARNING LIGHT CONTINUE TO LIGHT UP AND STAYS ON I HAVE SEEN SIMILAR COMPLAINTS ON VARIOUS CHAT SESSIONS.…” See the owner-reported complaints section below for more.
Which OBD2 fault codes are commonly documented for the Saturn Relay (2005–2007)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Saturn Relay (2005–2007) be serviced?
Routine maintenance for the Saturn Relay (2005–2007) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Found what you were looking for? Explore other Saturn models in our database, compare tyre offers in your size, or search a specific fault code in the TroubleAtlas OBD2 database.