SATURN SW (1993–2001): Technical Data, DTC & Service Schedule
Built 1993–2001 · all production years covered on this single page
1.9L I4 • Gasoline
2001
© Wikimedia Commons CC BY-SA
Every figure on this Saturn Sw (1993–2001) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Saturn Sw (1993–2001) is powered by a 1.9L I4 engine. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Related codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Related codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Related codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Related codes: P0562
P0011LOW
Check with an OBD2 scanner.
Related codes: P0011
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (15)
NHTSA 99V297000
Structure › Body
Date: 27/10/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A CONSOLE ARMREST FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACTS." THE ARMRESTS WERE PRODUCED WITH A LATCH THAT WILL NOT WITHSTAND THE VERTICAL FORCE REQUIREMENTS OF THE STANDARD…
NHTSA 93V094000
Electrical System › 12V/24V/48V Battery › Cables
Date: 25/05/1993
THE POSITIVE BATTERY CABLE TERMINAL AT THE STARTER SOLENOID MAY BE FORMED INCORRECTLY. INCORRECTLY FORMED TERMINALS CAN CONTACT THE STARTER SOLENOID HOUSING AND CAUSE AN ELECTRIC SHORT CIRCUIT.
NHTSA 99V231000
Service Brakes, Hydraulic › Foundation Components
Date: 24/08/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 135, "PASSENGER CAR BRAKE SYSTEMS." THESE VEHICLES WERE PRODUCED WITH BRAKE PIPE ATTACHMENT NUTS THAT MAY NOT BE TIGHTENED TO SPECIFICATIONS.
NHTSA 99V232000
Structure › Body › Bumpers
Date: 23/08/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 581, "BUMPER STANDARD." THESE VEHICLES WERE PRODUCED WITH REAR BUMPER FASTENERS THAT MAY BE LOOSE OR MISSING.
NHTSA 99V230000
Unknown Or Other
Date: 23/08/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES WERE MANUFACTURED WITH WELDS IN THE INSTRUMENT PANEL CARRIER ASSEMBLY THAT DO NOT MEET SATURN QUALITY STANDARDS.
NHTSA 99V280000
Seat Belts › Front › Anchorage
Date: 20/10/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." SOME OF THE VEHICLES WERE PRODUCED WITH SEAT BELT SHOULDER GUIDE ANCHOR BOLTS THAT WERE NOT ADEQUATELY TIGHTENED AT THE CENTER PILLAR AND …
NHTSA 99V280000
Seat Belts › Front › Anchorage
Date: 20/10/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." SOME OF THE VEHICLES WERE PRODUCED WITH SEAT BELT SHOULDER GUIDE ANCHOR BOLTS THAT WERE NOT ADEQUATELY TIGHTENED AT THE CENTER PILLAR AND …
NHTSA 00V310000
Power Train › Automatic Transmission › Park/Neutral Start Interlock Switch
Date: 12/10/2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, EQUIPPED WITH AUTOMATIC TRANSAXLES, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." THESE VEHICLES WERE BUILT WITH AN IMPROPERLY ADJUSTED AUTOMATIC TRANSAXLE PARK LOCK CABLE ASSEMBLY. IF IMPROPERLY ADJ…
NHTSA 00V309000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 12/10/2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THESE VEHICLES WERE BUILT WITH AN INADEQUATE VENT VALVE WELD ON THE TOP PORTION OF THE FUEL TANK.
NHTSA 00V310000
Power Train › Automatic Transmission › Park/Neutral Start Interlock Switch
Date: 12/10/2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, EQUIPPED WITH AUTOMATIC TRANSAXLES, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." THESE VEHICLES WERE BUILT WITH AN IMPROPERLY ADJUSTED AUTOMATIC TRANSAXLE PARK LOCK CABLE ASSEMBLY. IF IMPROPERLY ADJ…
NHTSA 00V309000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 12/10/2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THESE VEHICLES WERE BUILT WITH AN INADEQUATE VENT VALVE WELD ON THE TOP PORTION OF THE FUEL TANK.
NHTSA 99V045000
Seats
Date: 12/03/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME FRONT SEAT BACK RECLINER GEAR TEETH MAY WEAR EXCESSIVELY THROUGH REPEATED USE, AND COULD CAUSE THE SEAT BACK TO SLIP PARTIALLY REARWARD WHEN FORCE IS APPLIED.
NHTSA 99V045000
Seats
Date: 12/03/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME FRONT SEAT BACK RECLINER GEAR TEETH MAY WEAR EXCESSIVELY THROUGH REPEATED USE, AND COULD CAUSE THE SEAT BACK TO SLIP PARTIALLY REARWARD WHEN FORCE IS APPLIED.
NHTSA 93V132000
Electrical System › Alternator/Generator/Regulator
Date: 10/08/1993
THE GENERATOR ELECTRICAL WIRING IS NOT PROTECTED AGAINST EXCESSIVE CURRENT FLOW WHICH MAY BE CAUSED BY AN ELECTRICAL SHORT CIRCUIT IN THE GENERATOR.
NHTSA 94V217000
Power Train › Clutch Assembly › Pedal/Hand Lever(Motorcycle)
Date: 08/11/1994
THE AUTOMATIC TRANSAXLE PARK LOCK CABLE ASSEMBLY WAS IMPROPERLY ADJUSTED MAKING IT POSSIBLE TO SHIFT FROM THE "PARK" POSITION WITH THE IGNITION KEY REMOVED, OR REMOVE THE IGNITION KEY WITH THE SHIFT LEVER IN A POSITION OTHER THAN "PARK." THIS DOES NOT MEET THE REQUIREMENTS OF FMV…
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P0455
powertrain
LOW⏱ 0.62h avgP0442
powertrain
LOW⏱ 0.62h avgP0440
powertrain
LOW⏱ 0.78h avgP0420
powertrain
MEDIUM⏱ 1.24h avgP0300
powertrain
HIGH⏱ 1.22h avgP0172
powertrain
MEDIUM⏱ 1.13h avgP0171
powertrain
MEDIUM⏱ 0.95h avgP0730
transmission
MEDIUM⏱ 1.25h avgP0700
transmission
HIGH⏱ 1.25h avgP0401
powertrain
MEDIUM⏱ 1.25h avgP0011
powertrain
MEDIUM⏱ 5.4h avgU0100
network
HIGHP0562
electrical
MEDIUM⏱ 0.58h avgP0128
powertrain
MEDIUM⏱ 0.88h avg
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
208 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Saturn Sw across model years 1993–2001. These are real, verified reports submitted by vehicle owners.
29 crash reports 7 fires 32 injuries 1 death
Complaints by model year (most reported first)
Model year 199536
Model year 199731
Model year 199430
Model year 199827
Model year 199327
Model year 199620
Model year 199916
Model year 200015
Most reported components (all years)
Service Brakes33
Hydraulic32
Engine And Engine Cooling31
Electrical System21
Seats21
Power Train19
Sample reports
MASTER CYLINDER IS DEFECTIVE, CAUSING THE BRAKE PEDAL TO HIT FLOOR, RESULTING IN LOSS OF BRAKES, ALSO FRONT BRAKES GET VERY HOT, BUT BACK BRAKES ARE COOL. *AK (MY 1998)
DRIVING ABOUT 50 MPH WHEN VEHICLE IN FRONT STOPPED SUDDENLY, APPLIED BRAKES (ABS) HARD, PEDAL WENT TO FLOOR, SLID ABOUT 30 FEET W/BLACK TIRE MARKS BEHIND VEHICLE, REARENDED VEHICLE IN FRONT, AIR BAG DID NOT DEPLOY UPON IMPACT. *AK (MY 1994)
TIRE WAS READY TO THROW TREAD (FIRESTONE AFFINITY TOURING TI - P185-65R15). NLM (MY 1997)
TWO MAJOR GASKET PROBLEMS WITH A SATURN 2000 SW2 WAGON. TOTAL REPAIR COST $1,500.*AK (MY 2000)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 1993–2001.
Frequently Asked Questions
Does the Saturn Sw have any safety recalls?
Yes — 15 official NHTSA recall campaign(s) affect this model, mainly: POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH, FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Saturn Sw?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Saturn Sw?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Saturn Sw?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are electrical problems common on the Saturn Sw?
Yes — 23 of 177 real owner reports filed with NHTSA mention the electrical. One owner reported: “BRACKET UNDER THE PASSENGER'S SIDE WAS BROKE AND RUSTED, AND WAS STILL HOLDING BY A PLATE. THE BRACKET HOLDS THE ANTI-LOCK BRAKE ELECTRICAL WIRE AWAY FROM OTHER WHEEL ASSEMBLY TO PREVENT CHAFING AND …” See the owner-reported complaints section below for more.
Are engine problems common on the Saturn Sw?
Yes — 32 of 177 real owner reports filed with NHTSA mention the engine. One owner reported: “WHEN TRYING TO START THE VEHICLE UP ALL THE LIGHTS CAME ON ,AND THE VEHICLE WASN'T STARTING. ALSO, CONSUMER HAD THE WATER PUMP REPLACED AND THE WATER PUMP WENT OUT AGAIN. THE ENGINE CHECK LIGHT CAME…” See the owner-reported complaints section below for more.
Are brakes problems common on the Saturn Sw?
Yes — 39 of 177 real owner reports filed with NHTSA mention the brakes. One owner reported: “WHILE DRIVING IN COLD WEATHER BRAKES WILL MALFUNCTION, AND WILL NOT WORK AS DURING DRY/WARMER WEATHER, COULD STEP ON BRAKES AND OPERATE AS SHOULD BE.*AK…” See the owner-reported complaints section below for more.
Which OBD2 fault codes are commonly documented for the Saturn Sw (1993–2001)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Saturn Sw (1993–2001) be serviced?
Routine maintenance for the Saturn Sw (1993–2001) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Considering buying a Saturn Sw (1993–2001)? Use this guide to check expected maintenance costs, the most reported fault codes and parts availability on the market. Real data, zero commercial estimates.