SUZUKI SIDEKICK (1989–1998): Full Technical Specs & OBD2 Diagnostics
Built 1989–1998 · all production years covered on this single page
1.6L I4 • Gasoline
1998
© Wikimedia Commons CC BY-SA
Every figure on this Suzuki Sidekick (1989–1998) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Suzuki Sidekick (1989–1998) is powered by a 1.6L I4 engine. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Related codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Related codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Related codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Related codes: P0562
P0011LOW
Check with an OBD2 scanner.
Related codes: P0011
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (8)
NHTSA 95V103008
Seat Belts › Front › Buckle Assembly
Date: 24/05/1995
THE FRONT SAFETY BELT BUCKLE RELEASE BUTTONS CAN BREAK. THESE RED PLASTIC RELEASE BUTTONS ARE MARKED "PRESS." IF A BUTTON BREAKS, PIECES CAN FALL INTO THE BUCKLE ASSEMBLY CAUSING THE BUCKLE TO OPERATE IMPROPERLY.
NHTSA 95V103008
Seat Belts › Front › Buckle Assembly
Date: 24/05/1995
THE FRONT SAFETY BELT BUCKLE RELEASE BUTTONS CAN BREAK. THESE RED PLASTIC RELEASE BUTTONS ARE MARKED "PRESS." IF A BUTTON BREAKS, PIECES CAN FALL INTO THE BUCKLE ASSEMBLY CAUSING THE BUCKLE TO OPERATE IMPROPERLY.
NHTSA 95V103008
Seat Belts › Front › Buckle Assembly
Date: 24/05/1995
THE FRONT SAFETY BELT BUCKLE RELEASE BUTTONS CAN BREAK. THESE RED PLASTIC RELEASE BUTTONS ARE MARKED "PRESS." IF A BUTTON BREAKS, PIECES CAN FALL INTO THE BUCKLE ASSEMBLY CAUSING THE BUCKLE TO OPERATE IMPROPERLY.
NHTSA 00V008000
Suspension
Date: 20/01/2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. INSUFFICIENT STRENGTH OF THE MOUNTING BASE ON THE UPPER END OF THE FRONT STRUTS CAN LEAD TO BREAKAGE OF THE MOUNTING BOLTS THAT ATTACH THE UPPER END OF THE FRONT STRUTS TO THE VEHICLE BODY.
NHTSA 00V008000
Suspension
Date: 20/01/2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. INSUFFICIENT STRENGTH OF THE MOUNTING BASE ON THE UPPER END OF THE FRONT STRUTS CAN LEAD TO BREAKAGE OF THE MOUNTING BOLTS THAT ATTACH THE UPPER END OF THE FRONT STRUTS TO THE VEHICLE BODY.
NHTSA 94V073002
Suspension › Rear
Date: 16/04/1994
THE RIGHT REAR AND LEFT AXLE SHAFT HOUSING TUBES WERE INCORRECTLY WELDED AND CAN FRACTURE. FRACTURE OF THE REAR AXLE SHAFT HOUSING CAN RESULT IN SEPARATION OF THE AFFECTED WHEEL ASSEMBLY AND SEPARATION OF THE BRAKE LINE.
NHTSA 94V073002
Suspension › Rear
Date: 16/04/1994
THE RIGHT REAR AND LEFT AXLE SHAFT HOUSING TUBES WERE INCORRECTLY WELDED AND CAN FRACTURE. FRACTURE OF THE REAR AXLE SHAFT HOUSING CAN RESULT IN SEPARATION OF THE AFFECTED WHEEL ASSEMBLY AND SEPARATION OF THE BRAKE LINE.
NHTSA 96V121002
Fuel System, Gasoline › Storage › Tank Assembly
Date: 02/07/1996
THE FUEL TANK ON THESE VEHICLES CAN BECOME PUNCTURED BY A FUEL TANK FLANGE ATTACHMENT REINFORCEMENT DURING REAR-END COLLISIONS. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL TANK INTEGRITY."
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P0455
powertrain
LOW⏱ 0.62h avgP0442
powertrain
LOW⏱ 0.62h avgP0440
powertrain
LOW⏱ 0.78h avgP0420
powertrain
MEDIUM⏱ 1.24h avgP0300
powertrain
HIGH⏱ 1.22h avgP0172
powertrain
MEDIUM⏱ 1.13h avgP0171
powertrain
MEDIUM⏱ 0.95h avgP0730
transmission
MEDIUM⏱ 1.25h avgP0700
transmission
HIGH⏱ 1.25h avgP0401
powertrain
MEDIUM⏱ 1.25h avgP0011
powertrain
MEDIUM⏱ 5.4h avgU0100
network
HIGHP0562
electrical
MEDIUM⏱ 0.58h avgP0128
powertrain
MEDIUM⏱ 0.88h avg
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
226 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Suzuki Sidekick across model years 1989–1998. These are real, verified reports submitted by vehicle owners.
25 crash reports 9 fires 32 injuries 1 death
Complaints by model year (most reported first)
Model year 199652
Model year 199747
Model year 199827
Model year 199527
Model year 199421
Model year 199115
Model year 199314
Model year 199211
Most reported components (all years)
Power Train37
Suspension34
Engine And Engine Cooling30
Service Brakes21
Hydraulic21
Seat Belts21
Sample reports
REAR END PROBLEMS. *SD (MY 1994)
AXLE SEAL FAILED, CAUSED BRAKE SHOES TO ROTATE AND LOCK RR WHEEL. *AK (MY 1996)
CLUTCH PEDAL SEPARATES FROM PIVOT SHAFT. WELD BRAKES, PEDAL DETACHES, VEHICLE DISABLED. THIRD OCCURRENCE. OEM PEDAL REPLACEMENT REVEALS NO-WARRANTY, COMMON OCCURRENCE FAILURE MODE. PEDAL RE-ATTACHED TO SHAFT BY PROFESSIONAL WELDERS ON TW… (MY 1996)
SPRING IN REAR DOOR LATCH SEPERATED FROM OTHER PARTS CAUSING LATCH TO FAIL. (MY 1994)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 1989–1998.
Frequently Asked Questions
Does the Suzuki Sidekick have any safety recalls?
Yes — 8 official NHTSA recall campaign(s) affect this model, mainly: SUSPENSION, FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Suzuki Sidekick?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Suzuki Sidekick?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Suzuki Sidekick?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are brakes problems common on the Suzuki Sidekick?
Yes — 24 of 192 real owner reports filed with NHTSA mention the brakes. One owner reported: “THE MASTER CYLINDER IS DEFECTIVE. THE BRAKES DRAG INTERMITENTLY, AND THE MECHANIC HAS TOLD ME THAT THE 'CHECK VALVE' INSIDE THE MASTER CYLINDER IS FAILING TO RELEASE WHEN I TAKE MY FOOT OFF OF THE BR…” See the owner-reported complaints section below for more.
Are transmission problems common on the Suzuki Sidekick?
Yes — 30 of 192 real owner reports filed with NHTSA mention the transmission. One owner reported: “FIREWALL CRACKED AFTE CLUTCH WAS INSTALLED IN VEHICLE. CONSUMER TOOK IT TO DEALER, AND WAS TOLD BY MECHANIIC THAT THERE WAS A WEAK SPOT IN FIREWALL. COST TO HAVE IT REPAIRED WAS $1700.OO. CONSUM…” See the owner-reported complaints section below for more.
Are engine problems common on the Suzuki Sidekick?
Yes — 34 of 192 real owner reports filed with NHTSA mention the engine. One owner reported: “TL*THE CONTACT OWNS A 1989 SUZUKI SIDEKICK. THE CONTACT NOTICED THAT THE CHECK ENGINE LIGHT WAS CONSTANTLY ILLUMINATED ON THE INSTRUMENT PANEL. ON TWO OCCASIONS, HE TOOK THE VEHICLE TO THE DEALER AN…” See the owner-reported complaints section below for more.
Which OBD2 fault codes are commonly documented for the Suzuki Sidekick (1989–1998)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Suzuki Sidekick (1989–1998) be serviced?
Routine maintenance for the Suzuki Sidekick (1989–1998) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Bookmark this page to consult it at the workshop or when buying parts. TroubleAtlas updates its technical data continuously — check back for new information on the Suzuki Sidekick (1989–1998).