SUZUKI VERONA (2004–2006): Technical Data, DTC & Service Schedule
Built 2004–2006 · all production years covered on this single page
2.5L I6 • Gasoline
2006
© Wikimedia Commons CC BY-SA
Every figure on this Suzuki Verona (2004–2006) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Suzuki Verona (2004–2006) is powered by a 2.5L I6 engine. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Related codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Related codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Related codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Related codes: P0562
P0011LOW
Check with an OBD2 scanner.
Related codes: P0011
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (9)
NHTSA 03V426000
Air Bags › Frontal
Date: 29/10/2003
ON CERTAIN PASSENGER CARS, THE DUAL STAGE DRIVER'S AIR BAG DEPLOYS IN AN IMPROPER SEQUENCE.
NHTSA 05V022000
Exterior Lighting › Brake Lights › Switch
Date: 28/01/2005
ON CERTAIN PASSENGER VEHICLES, THE BRAKE LIGHT SWITCH MAY BECOME MISADJUSTED IF AN UPWARD/REARWARD FORCE IS APPLIED TO THE BRAKE PEDAL. IF THIS SHOULD OCCUR, THE BRAKE LIGHT SWITCH WILL NOT FUNCTION PROPERLY, CAUSING THE BRAKE LIGHTS, INCLUDING THE HIGH MOUNTED STOP LAMP, TO REM…
NHTSA 14V363000
Exterior Lighting › Headlights
Date: 24/06/2014
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2006 Verona vehicles manufactured June 2003 to October 2005. In the affected vehicles, there may be heat generated within the DRL module located in the instrument panel, which could melt the DRL module.
NHTSA 14V363000
Exterior Lighting › Headlights
Date: 24/06/2014
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2006 Verona vehicles manufactured June 2003 to October 2005. In the affected vehicles, there may be heat generated within the DRL module located in the instrument panel, which could melt the DRL module.
NHTSA 14V363000
Exterior Lighting › Headlights
Date: 24/06/2014
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2006 Verona vehicles manufactured June 2003 to October 2005. In the affected vehicles, there may be heat generated within the DRL module located in the instrument panel, which could melt the DRL module.
NHTSA 04V396000
Fuel System, Gasoline › Delivery
Date: 13/08/2004
IN CERTAIN PASSENGER VEHICLES, A FAULT IN THE ADAPTIVE FUEL CONTROL LOGIC CAN CAUSE SOME VEHICLES TO USE AIR/FUEL RATIOS DURING DECELERATION THAT ARE LEAN ENOUGH TO CAUSE ENGINE STALLING.
NHTSA 03V333000
Seat Belts › Front › Buckle Assembly
Date: 08/09/2003
CERTAIN PASSENGER VEHICLES MAY HAVE A MISLOCATED SENSOR IN THE DRIVER'S SEAT BELT BUCKLE ASSEMBLY. THIS CONDITION CAN PREVENT THE DRIVER'S SEAT BELT TONGUE FROM BEING INSERTED INTO THE BUCKLE.
NHTSA 05V507000
Steering › Hydraulic Power Assist › Pump
Date: 03/11/2005
ON CERTAIN PASSENGER VEHICLES, THE POWER STEERING PUMP PULLEY MAY SEPARATE FROM THE POWER STEERING PUMP DUE TO INADEQUATE WALL THICKNESS OF THE PULLEY.
NHTSA 05V507000
Steering › Hydraulic Power Assist › Pump
Date: 03/11/2005
ON CERTAIN PASSENGER VEHICLES, THE POWER STEERING PUMP PULLEY MAY SEPARATE FROM THE POWER STEERING PUMP DUE TO INADEQUATE WALL THICKNESS OF THE PULLEY.
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P0455
powertrain
LOW⏱ 0.62h avgP0442
powertrain
LOW⏱ 0.62h avgP0440
powertrain
LOW⏱ 0.78h avgP0420
powertrain
MEDIUM⏱ 1.24h avgP0300
powertrain
HIGH⏱ 1.22h avgP0172
powertrain
MEDIUM⏱ 1.13h avgP0171
powertrain
MEDIUM⏱ 0.95h avgP0730
transmission
MEDIUM⏱ 1.25h avgP0700
transmission
HIGH⏱ 1.25h avgP0401
powertrain
MEDIUM⏱ 1.25h avgP0011
powertrain
MEDIUM⏱ 5.4h avgU0100
network
HIGHP0562
electrical
MEDIUM⏱ 0.58h avgP0128
powertrain
MEDIUM⏱ 0.88h avg
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
121 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Suzuki Verona across model years 2004–2006. These are real, verified reports submitted by vehicle owners.
6 crash reports 5 fires 8 injuries 1 death
Complaints by model year (most reported first)
Model year 200460
Model year 200553
Model year 20068
Most reported components (all years)
Engine And Engine Cooling30
Power Train22
Electrical System20
Air Bags14
Service Brakes13
Engine12
Sample reports
MY CAR'S CHECK ENGINE LIGHT CAME ON A MONTH AFTER I GOT THE CAR IN 2007. THE THROTTLE BODY HAD TO BE REPLACED ON IT. THE DEALERSHIP PAID FOR IT TO BE REPLACED. IN 2008 MY CAR DID THE SAME THING AND THE THROTTLE BODY HAD TO BE REPLACED… (MY 2005)
THE SEAT BELTS IN THE BACK SEAT WILL NOT WORK PROPERLY. I HAVE 2 OUT OF THE 3 TO LOCK UP AND NOT WORK. I HAVE A 4YR OLD AND NOW SHE MUST RIDE BY THE DOOR DUE TO THE MALFUNCTION OF THE OTHER TWO SEATBELTS. I HAVE HAD SO MUCH TROUBLE OUT O… (MY 2004)
SCOTT WAS TRAVELING ON A HIGHWAY AND ATTEMPTED TO EXIT THE HIGHWAY; HOWEVER, AS HE ATTEMPTED TO BRAKE, HE NOTICED H WAS NOT SLOWING DOWN, AND THAT IT APPEARED THAT HIS BRAKES HAS GIVEN OUT. HE WAS ABLE TO SAFELY SLOW DOWN THE VEHICLE AN… (MY 2005)
TL*THE CONTACT OWNS A 2004 SUZUKI VERONA. THE CONTACT BRAKE LIGHT WAS ILLUMINATED AFTER HE STEPPED OUT OF THE VEHICLE. THE CONTACT RETURNED TO THE VEHICLE AND APPLIED PRESSURE TO THE BRAKE PEDAL TO DEACTIVATE THE LIGHT. THE FAILURE OCCUR… (MY 2004)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 2004–2006.
Frequently Asked Questions
Does the Suzuki Verona have any safety recalls?
Yes — 9 official NHTSA recall campaign(s) affect this model, mainly: EXTERIOR LIGHTING:HEADLIGHTS, STEERING:HYDRAULIC POWER ASSIST:PUMP, AIR BAGS:FRONTAL. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Suzuki Verona?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Suzuki Verona?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Suzuki Verona?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are transmission problems common on the Suzuki Verona?
Yes — 26 of 119 real owner reports filed with NHTSA mention the transmission. One owner reported: “I SHOULD HAVE DONE MY HOMEWORK BEFORE PURCHASING THIS VEHICLE. I BOUGHT IT FROM DEALERSHIP, AND FEEL FINDING OUT MORE , WHY ARE THESE CARS ALOUD TO STILL BE SOLD. I HAVE HAD NOTHING BUT PROBLEMS SINC…” See the owner-reported complaints section below for more.
Are electrical problems common on the Suzuki Verona?
Yes — 57 of 119 real owner reports filed with NHTSA mention the electrical. One owner reported: “The contact's fiancé owns a 2004 Suzuki Verona. The contact stated that on multiple occasions after starting the vehicle, the engine was lagging and then revved inadvertently. The contact also stated …” See the owner-reported complaints section below for more.
Are engine problems common on the Suzuki Verona?
Yes — 58 of 119 real owner reports filed with NHTSA mention the engine. One owner reported: “The contact's fiancé owns a 2004 Suzuki Verona. The contact stated that on multiple occasions after starting the vehicle, the engine was lagging and then revved inadvertently. The contact also stated …” See the owner-reported complaints section below for more.
Which OBD2 fault codes are commonly documented for the Suzuki Verona (2004–2006)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Suzuki Verona (2004–2006) be serviced?
Routine maintenance for the Suzuki Verona (2004–2006) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
This spec sheet is updated with data verified from OEM sources and shop databases. If you spot an inaccuracy or have additional data on the Suzuki Verona (2004–2006), let us know — every correction improves quality for all users.