TroubleAtlas Score
TOYOTA ECHO (2000–2005) — Technical Guide, Fault Codes & Maintenance
Built 2000–2005 · all production years covered on this single page
1.5L I4 • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Toyota Echo (2000–2005) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost8.2
Parts & repairability4.5
Maintenance & durabilityn/a
Documentation & support8.2
Independent · Verified · Never for sale
Every figure on this Toyota Echo (2000–2005) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Toyota Echo (2000–2005) uses Toyota Genuine 5W-30 engine oil. Its battery is group 35 (BCI), rated at 425A cold-cranking amps. It is powered by a 1.5L I4 engine. Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Easy
0.8h
€56 – €72
Rear brake pads
Difficulty: Easy
0.9h
€63 – €81
Engine oil change
Difficulty: Easy
0.3h
€21 – €27
ABS Module
Difficulty: Medium
2.0h
€140 – €180
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.0h | € 90–€ 150 |
| ABS Pump | 2.5h | € 112–€ 187 |
| ABS Tone Ring | 1.5h | € 67–€ 112 |
| ABS Wheel Speed Sensor - Front | 0.8h | € 36–€ 60 |
| ABS Wheel Speed Sensor - Rear | 0.8h | € 36–€ 60 |
| Brake Bleed - All Four | 1.0h | € 45–€ 75 |
| Brake Booster | 2.5h | € 112–€ 187 |
| Brake Booster Check Valve | 0.3h | € 13–€ 22 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 1.5h | € 67–€ 112 |
| Coolant Flush | 1.0h | € 45–€ 75 |
| Coolant Reservoir | 0.5h | € 22–€ 37 |
| Coolant Temperature Sensor | 0.5h | € 22–€ 37 |
| Cooling Fan Assembly | 1.0h | € 45–€ 75 |
| Cooling Fan Motor | 1.5h | € 67–€ 112 |
| Cooling Fan Relay | 0.3h | € 13–€ 22 |
| Engine Oil Cooler | 2.0h | € 90–€ 150 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.0h | € 45–€ 75 |
| Airbag - Passenger | 1.5h | € 67–€ 112 |
| Airbag - Side | 2.0h | € 90–€ 150 |
| Airbag Module/Computer | 1.0h | € 45–€ 75 |
| Alternator | 1.5h | € 67–€ 112 |
| Alternator Belt | 0.5h | € 22–€ 37 |
| Amplifier | 1.5h | € 67–€ 112 |
| Antenna | 0.5h | € 22–€ 37 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Camshaft Position Sensor | 1.0h | € 45–€ 75 |
| Camshaft R&R | 8.0h | € 360–€ 600 |
| Connecting Rod Bearings | 15.0h | € 675–€ 1125 |
| Crankshaft Position Sensor | 1.0h | € 45–€ 75 |
| Crankshaft R&R | 20.0h | € 900–€ 1500 |
| Cylinder Head R&R | 6.0h | € 270–€ 450 |
| Cylinder Head Resurface | 8.0h | € 360–€ 600 |
| Engine Mount - Front | 1.5h | € 67–€ 112 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 0.8h | € 36–€ 60 |
| Catalytic Converter - California | 1.5h | € 67–€ 112 |
| Catalytic Converter - Direct Fit | 1.5h | € 67–€ 112 |
| Catalytic Converter - Universal | 2.0h | € 90–€ 150 |
| Downpipe | 2.0h | € 90–€ 150 |
| EGR Cooler | 3.0h | € 135–€ 225 |
| EGR Tube | 1.5h | € 67–€ 112 |
| EGR Valve | 1.0h | € 45–€ 75 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.0h | € 45–€ 75 |
| EVAP Purge Valve | 0.8h | € 36–€ 60 |
| EVAP Vent Valve | 0.8h | € 36–€ 60 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 1.5h | € 67–€ 112 |
| Fuel Filter | 0.5h | € 22–€ 37 |
| Fuel Filter - In-Tank | 2.0h | € 90–€ 150 |
| Fuel Injector - Single | 1.0h | € 45–€ 75 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 1.5h | € 67–€ 112 |
| AC Clutch Coil | 1.5h | € 67–€ 112 |
| AC Compressor | 2.5h | € 112–€ 187 |
| AC Compressor Clutch | 2.0h | € 90–€ 150 |
| AC Compressor Oil Add | 0.5h | € 22–€ 37 |
| AC Condenser | 2.5h | € 112–€ 187 |
| AC Evaporator | 6.0h | € 270–€ 450 |
| AC Expansion Valve (TXV) | 4.0h | € 180–€ 300 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 1.5h | € 67–€ 112 |
| Electric Power Steering Module | 1.5h | € 67–€ 112 |
| Electric Power Steering Motor | 2.5h | € 112–€ 187 |
| Idler Arm | 1.0h | € 45–€ 75 |
| Pitman Arm | 1.2h | € 54–€ 90 |
| Power Steering Fluid Flush | 0.5h | € 22–€ 37 |
| Power Steering Gear Box | 3.5h | € 157–€ 262 |
| Power Steering Hose - High Pressure | 1.0h | € 45–€ 75 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.0h | € 45–€ 75 |
| Air Spring/Air Bag | 1.5h | € 67–€ 112 |
| Air Suspension Compressor | 1.5h | € 67–€ 112 |
| Air Suspension Height Sensor | 1.0h | € 45–€ 75 |
| Air Suspension Valve Block | 2.0h | € 90–€ 150 |
| Ball Joint - Lower | 1.8h | € 81–€ 135 |
| Ball Joint - Upper | 1.5h | € 67–€ 112 |
| Ball Joints - Upper and Lower | 3.0h | € 135–€ 225 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Kickdown Cable | 0.8h | € 36–€ 60 |
| Neutral Safety Switch | 1.0h | € 45–€ 75 |
| Overdrive Solenoid | 2.0h | € 90–€ 150 |
| Shift Cable | 1.5h | € 67–€ 112 |
| Shift Linkage | 1.0h | € 45–€ 75 |
| Transmission Control Module | 1.0h | € 45–€ 75 |
| Transmission Cooler Lines | 1.0h | € 45–€ 75 |
| Transmission Filter | 1.0h | € 45–€ 75 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (5)
NHTSA 06V266000
Engine And Engine Cooling
Date: 19/07/2006
ON CERTAIN PASSENGER VEHICLES, DUE TO IMPROPER MOLDING OF THE RESIN BODY OF THE CRANKSHAFT POSITION SENOR INSTALLED ON THE ENGINE BLOCK, ENGINE OIL MAY PENETRATE THE SEAL AND ENTER THE SENSOR WIRING CONNECTOR. THE WIRE HARNESS CONNECTOR MAY NOT BE SUFFICIENTLY ATTACHED TO THE LO…
NHTSA 04V455000
Service Brakes, Hydraulic › Foundation Components › Master Cylinder
Date: 17/09/2004
CERTAIN PASSENGER VEHICLES HAVE THE POSSIBILITY THAT THE RECESS RETAINS A RUBBER SEAL RING, WHICH IS LOCATED AT THE END OF THE CYLINDER BODY, AND MAY BE CORRODED DUE TO AN IMPROPER WASHING PROCESS.
NHTSA 01V326000
Service Brakes, Hydraulic › Power Assist › Vacuum
Date: 10/10/2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION. DUE TO A UNIQUE COMBINATION OF CONDITIONS WHICH CONSIST OF COLD AMBIENT TEMPERATURES, LOAD APPLIED FROM AIR CONDITIONER AND OTHER ELECTRICAL DEVICES, AND IMMEDIATELY AFTER STARTING THE ENGINE, THE…
NHTSA 00V256000
Engine And Engine Cooling › Engine › Gasoline
Date: 07/09/2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, IDAHO, ILLINOIS, IOWA, KANSAS, MAINE, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND W…
NHTSA 02V268000
Service Brakes, Hydraulic › Foundation Components › Hoses, Lines/Piping, And Fittings
Date: 01/10/2002
ON CERTAIN PASSENGER VEHICLES, IF THE VEHICLE IS DRIVEN UNDER REPEATED START AND STOP OPERATION IN LOW AMBIENT TEMPERATURES AND IN DEEP SNOW, THERE IS A POSSIBILITY THAT SNOW COULD ACCUMULATE IN LARGE QUANTITIES INSIDE THE REAR WHEEL AND FREEZE. THE SNOW FROZEN INSIDE THE WHEEL …
COMMON OBD2 CODES TO CHECK
P0420
Catalyst System Efficiency Below Threshold Bank 1
Powertrain
P0171
System Too Lean Bank 1
Powertrain
P0300
Random/Multiple Cylinder Misfire Detected
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
Coolant Thermostat Below Regulating Temperature
Powertrain
P0455
EVAP System Leak Detected (Gross Leak)
Powertrain
P0700
Transmission Control System (MIL Request)
Powertrain
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1661
powertrain
MODERATEP1658
powertrain
HIGHP1656
powertrain
MODERATEP1652
powertrain
MODERATEP1604
powertrain
HIGHP1510
powertrain
HIGHP1330
powertrain
HIGHP1315
powertrain
HIGHP1310
powertrain
HIGHP1305
powertrain
HIGHP1200
powertrain
HIGHP1765
powertrain
HIGHP1630
powertrain
HIGHP1512
powertrain
CRITICALP1129
powertrain
HIGHP1780
powertrain
HIGHP1405
powertrain
MODERATEP1150
powertrain
MODERATEP1700
powertrain
HIGHP1565
powertrain
LOW
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
60 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
Master Warning (Toyota)Electrical
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
Pre-Collision System Off (Toyota)ADAS
Lane Departure Alert Off (Toyota)ADAS
Slip Indicator (Toyota)Chassis
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
READY Light (Toyota)Electrical
EV Mode Indicator (Toyota)Electrical
B-Ready (EV Brake) (Toyota)Brakes
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
194 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Toyota Echo across model years 2000–2005. These are real, verified reports submitted by vehicle owners.
66 crash reports 9 fires 55 injuries 1 death
Complaints by model year (most reported first)
Model year 200086
Model year 200150
Model year 200235
Model year 200317
Model year 20055
Model year 20041
Most reported components (all years)
Air Bags47
Service Brakes38
Hydraulic36
Vehicle Speed Control29
Power Train20
Engine And Engine Cooling19
Sample reports
THE HEADLIGHTS LOOK LIKE THE HIGH BEAM LIGHTS ARE ON WHILE DRIVING ANY SPEED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK (MY 2001)
2003 TOYOTA ECHO WITH MANUAL TRANSMISSION SHUTS OFF WHEN SLOWING OR STOPPING, ESPECIALLY ON DOWNGRADES WHEN CLUTCH IS DEPRESSED. I HAVE LEARNED TO LESSEN THESE OCCURRENCES BY NOT PUSHING IN THE CLUTCH UNTIL THE CAR IS ALMOST STOPPED, BY… (MY 2003)
WHEN DRIVING IN HEAVY RAIN THE VEHICLE DOES NOT MAINTAIN GEAR CAUSING THE VEHICLE TO LOOSE CONTROL AND SWERVE ALL OVER THE ROAD. NLM (MY 2000)
BRAKES FAILED TO STOP VEHICLE WHEN APPLIED, AND IT REAR ENDED ANOTHER VEHICLE. UPON IMPACT, AIR BAGS DID NOT DEPLOY. NO INJURIES REPORTED. VEHICLE WAS TOWED, AND TOTALED BY THE INSURANCE COMPANY. *AK (MY 2000)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 2000–2005.
Frequently Asked Questions
Does the Toyota Echo have any safety recalls?
Yes — 5 official NHTSA recall campaign(s) affect this model, mainly: ENGINE AND ENGINE COOLING:ENGINE:GASOLINE, SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM. Check the recalls section for your exact year/VIN.
What does fault code P0003 mean on the Toyota Echo?
Fuel Volume Regulator Control Circuit Low This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0002 mean on the Toyota Echo?
Fuel Volume Regulator Control Circuit Range/Performance This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0001 mean on the Toyota Echo?
Fuel Volume Regulator Control Circuit/Open This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are electrical problems common on the Toyota Echo?
Yes — 26 of 188 real owner reports filed with NHTSA mention the electrical. One owner reported: “TAKATA RECALL AIR BAG DASH LIGHT REMAINS 'ON' WHENEVER ENGINE IS RUNNING.…” See the owner-reported complaints section below for more.
Are airbags problems common on the Toyota Echo?
Yes — 51 of 188 real owner reports filed with NHTSA mention the airbags. One owner reported: “TL* TAKATA RECALL. THE CONTACT OWNED A 2000 TOYOTA ECHO. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT'S VEHICLE REAR ENDED ANOTHER VEHICLE THAT FAILED TO YIELD FROM THE LEFT. THE STEERING WHEEL AIR…” See the owner-reported complaints section below for more.
Are brakes problems common on the Toyota Echo?
Yes — 53 of 188 real owner reports filed with NHTSA mention the brakes. One owner reported: “TL* THE CONTACT OWNS A 2000 TOYOTA ECHO. WHILE DRIVING 40-50 MPH, THE VEHICLE ACCELERATED WITHOUT WARNING. THE BRAKE PEDAL WAS APPLIED, BUT THE VEHICLE FAILED TO STOP. THE CONTACT HAD TO PLACE THE VEH…” See the owner-reported complaints section below for more.
What tyres does the Toyota Echo (2000–2005) use?
The original OEM tyre size for the Toyota Echo (2000–2005) is 215/55 R16. Compatible alternative sizes: ["245/45R19", "185/60R15", "175/65R14"]. See the Tyres section on this page to compare offers from the main suppliers.
What is the right battery for the Toyota Echo (2000–2005)?
The battery specified for the Toyota Echo (2000–2005) is group 35 (BCI), with a cold cranking rating of 425A. See the Battery section on this page for the main cross-references between brands.
What engine oil should I use on the Toyota Echo (2000–2005)?
The engine oil specification for the Toyota Echo (2000–2005) is Toyota Genuine 5W-30. Always use the viscosity grade approved by the manufacturer: a different oil can reduce engine protection and void the warranty. Check the change interval in the Maintenance section.
Which OBD2 fault codes are commonly documented for the Toyota Echo (2000–2005)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Toyota Echo (2000–2005) be serviced?
Routine maintenance for the Toyota Echo (2000–2005) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Considering buying a Toyota Echo (2000–2005)? Use this guide to check expected maintenance costs, the most reported fault codes and parts availability on the market. Real data, zero commercial estimates.