TroubleAtlas Score
VOLKSWAGEN ATLAS-CROSS-SPORT (2020–2024) — Technical Guide, Fault Codes & Maintenance
Built 2020–2024 · all production years covered on this single page
3.6L V6 • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Volkswagen Atlas-Cross-Sport (2020–2024) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost3.2
Parts & repairability5.2
Maintenance & durabilityn/a
Documentation & supportn/a
Independent · Verified · Never for sale
Every figure on this Volkswagen Atlas-Cross-Sport (2020–2024) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Volkswagen Atlas-Cross-Sport (2020–2024) uses Castrol Edge 0W-20 engine oil. Its battery is group H7 (BCI), rated at 760A cold-cranking amps. It is powered by a 3.6L V6 engine. Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Medium
1.1h
€77 – €99
Rear brake pads
Difficulty: Medium
1.2h
€84 – €108
Engine oil change
Difficulty: Easy
0.4h
€28 – €36
ABS Module
Difficulty: Hard
2.7h
€189 – €243
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.7h | € 121–€ 202 |
| ABS Pump | 3.4h | € 153–€ 255 |
| ABS Tone Ring | 2.0h | € 90–€ 150 |
| ABS Wheel Speed Sensor - Front | 1.1h | € 49–€ 82 |
| ABS Wheel Speed Sensor - Rear | 1.1h | € 49–€ 82 |
| Brake Bleed - All Four | 1.4h | € 62–€ 105 |
| Brake Booster | 3.4h | € 153–€ 255 |
| Brake Booster Check Valve | 0.4h | € 18–€ 30 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 2.0h | € 90–€ 150 |
| Coolant Flush | 1.4h | € 62–€ 105 |
| Coolant Reservoir | 0.7h | € 31–€ 52 |
| Coolant Temperature Sensor | 0.7h | € 31–€ 52 |
| Cooling Fan Assembly | 1.4h | € 62–€ 105 |
| Cooling Fan Clutch | 1.4h | € 62–€ 105 |
| Cooling Fan Motor | 2.0h | € 90–€ 150 |
| Cooling Fan Relay | 0.4h | € 18–€ 30 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.4h | € 62–€ 105 |
| Airbag - Passenger | 2.0h | € 90–€ 150 |
| Airbag - Side | 2.7h | € 121–€ 202 |
| Airbag Module/Computer | 1.4h | € 62–€ 105 |
| Alternator | 2.0h | € 90–€ 150 |
| Alternator Belt | 0.7h | € 31–€ 52 |
| Amplifier | 2.0h | € 90–€ 150 |
| Antenna | 0.7h | € 31–€ 52 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Boost Pressure Sensor | 0.7h | € 31–€ 52 |
| Camshaft Position Sensor | 1.4h | € 62–€ 105 |
| Camshaft R&R | 10.8h | € 486–€ 810 |
| Connecting Rod Bearings | 20.2h | € 909–€ 1515 |
| Crankshaft Position Sensor | 1.4h | € 62–€ 105 |
| Crankshaft R&R | 27.0h | € 1215–€ 2025 |
| Cylinder Head R&R | 8.1h | € 364–€ 607 |
| Cylinder Head Resurface | 10.8h | € 486–€ 810 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 1.1h | € 49–€ 82 |
| Catalytic Converter - California | 2.0h | € 90–€ 150 |
| Catalytic Converter - Direct Fit | 2.0h | € 90–€ 150 |
| Catalytic Converter - Universal | 2.7h | € 121–€ 202 |
| Downpipe | 2.7h | € 121–€ 202 |
| EGR Cooler | 4.1h | € 184–€ 307 |
| EGR Tube | 2.0h | € 90–€ 150 |
| EGR Valve | 1.4h | € 62–€ 105 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.4h | € 62–€ 105 |
| EVAP Purge Valve | 1.1h | € 49–€ 82 |
| EVAP Vent Valve | 1.1h | € 49–€ 82 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 2.0h | € 90–€ 150 |
| Fuel Filter | 0.7h | € 31–€ 52 |
| Fuel Filter - In-Tank | 2.7h | € 121–€ 202 |
| Fuel Injector - Single | 1.4h | € 62–€ 105 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 2.0h | € 90–€ 150 |
| AC Clutch Coil | 2.0h | € 90–€ 150 |
| AC Compressor | 3.4h | € 153–€ 255 |
| AC Compressor Clutch | 2.7h | € 121–€ 202 |
| AC Compressor Oil Add | 0.7h | € 31–€ 52 |
| AC Condenser | 3.4h | € 153–€ 255 |
| AC Evaporator | 8.1h | € 364–€ 607 |
| AC Expansion Valve (TXV) | 5.4h | € 243–€ 405 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 2.0h | € 90–€ 150 |
| Electric Power Steering Module | 2.0h | € 90–€ 150 |
| Electric Power Steering Motor | 3.4h | € 153–€ 255 |
| Idler Arm | 1.4h | € 62–€ 105 |
| Pitman Arm | 1.6h | € 72–€ 120 |
| Power Steering Fluid Flush | 0.7h | € 31–€ 52 |
| Power Steering Gear Box | 4.7h | € 211–€ 352 |
| Power Steering Hose - High Pressure | 1.4h | € 62–€ 105 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.4h | € 62–€ 105 |
| Air Spring/Air Bag | 2.0h | € 90–€ 150 |
| Air Suspension Compressor | 2.0h | € 90–€ 150 |
| Air Suspension Height Sensor | 1.4h | € 62–€ 105 |
| Air Suspension Valve Block | 2.7h | € 121–€ 202 |
| Ball Joint - Lower | 2.4h | € 108–€ 180 |
| Ball Joint - Upper | 2.0h | € 90–€ 150 |
| Ball Joints - Upper and Lower | 4.1h | € 184–€ 307 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Kickdown Cable | 1.1h | € 49–€ 82 |
| Neutral Safety Switch | 1.4h | € 62–€ 105 |
| Overdrive Solenoid | 2.7h | € 121–€ 202 |
| Shift Cable | 2.0h | € 90–€ 150 |
| Shift Linkage | 1.4h | € 62–€ 105 |
| Shift Solenoid - Single | 4.1h | € 184–€ 307 |
| Shift Solenoids - All | 9.0h | € 405–€ 675 |
| Torque Converter | 6.9h | € 310–€ 517 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (0)
No official recall verified for this vehicle in the NHTSA database.
COMMON OBD2 CODES TO CHECK
P0420
Catalyst System Efficiency Below Threshold Bank 1
Powertrain
P0171
System Too Lean Bank 1
Powertrain
P0300
Random/Multiple Cylinder Misfire Detected
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
Coolant Thermostat Below Regulating Temperature
Powertrain
P0455
EVAP System Leak Detected (Gross Leak)
Powertrain
P0700
Transmission Control System (MIL Request)
Powertrain
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1425
powertrain
LOWP1420
powertrain
MODERATEP1177
powertrain
MODERATEP1176
powertrain
MODERATEP1141
powertrain
HIGHP1136
powertrain
MODERATEP1225
powertrain
HIGHP1214
powertrain
HIGHP1213
powertrain
HIGHP1388
powertrain
HIGHP1564
powertrain
MODERATEP1544
powertrain
HIGHP1543
powertrain
HIGHP1296
powertrain
MODERATEP1137
powertrain
MODERATEP1102
powertrain
MODERATEP1297
powertrain
HIGHP1105
powertrain
MODERATEP1410
powertrain
LOWP1340
powertrain
MODERATE
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
88 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
Doors OpenChassis
Hood Open DualChassis
Trunk Open DualChassis
Ignition MalfunctionEngine
WheelEngine
Lights Ignition Steering MalfunctionChassis
Dsg Transmission Too HotTransmission
Electronic Parking Brake EngagedBrakes
Brake System MalfunctionBrakes
Brake WearBrakes
Engine CoolantEngine
Engine Oil Pressure LowEngine
12V Alternator MalfunctionElectrical
Cruise Control MalfunctionADAS
Brake PedalBrakes
Front Assist Collision WarningADAS
Differential Lock MalfunctionEngine
AdblueFuel
Error In Hybrid SystemElectrical
Central Warning LightLighting
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
AdBlue Level Low (VW) (Volkswagen)Emissions
EPC — Engine Control (VW) (Volkswagen)Engine
Glow Plug Fault (VW) (Volkswagen)Engine
DSG Fault (Volkswagen)Transmission
TpmsTyres
Open Rear LidEngine
Ignition Switch Starter ButtonEngine
Electronic ImmobilizerEngine
Fuel Tank Almost EmptyFuel
Front Fog Lights Switched OnLighting
Parking Lights Switched OnBrakes
Driving Lights Burned OutLighting
Adaptive Front Lighting System MalfunctionLighting
Headlight Range Adjustment MalfunctionLighting
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
DPF Regeneration (VW) (Volkswagen)Emissions
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
417 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Volkswagen Atlas-Cross-Sport across model years 2020–2024. These are real, verified reports submitted by vehicle owners.
16 crash reports 4 fires 9 injuries
Complaints by model year (most reported first)
Model year 2021150
Model year 202097
Model year 202484
Model year 202270
Model year 202316
Most reported components (all years)
Electrical System115
Service Brakes79
Unknown Or Other75
Air Bags69
Engine68
Forward Collision Avoidance59
Sample reports
The warning light came on signaling an airbag problem. The dealer checked all the wires and connections and determined there must be a problem with vehemently airbag itself and they said it should be replaced. (MY 2020)
Upon breaking its a grinding at time with squeaking. I’ve taken concern 2-3 times now to dealership and they say there’s nothing wrong with breaks. They have given me no resolution in fixing. It happens on a daily. Depending how breaking… (MY 2022)
The contact owns a 2020 Volkswagen Atlas Cross Sport. The contact stated while driving at low speeds, the emergency brake engaged independently. The contact also stated that the front driver’s side door failed to lock. The contact stated… (MY 2020)
I was in a front end collision, no airbags were deployed. (MY 2021)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 2020–2024.
Frequently Asked Questions
What does fault code P0003 mean on the Volkswagen Atlas-cross-sport?
Fuel Volume Regulator Control Circuit Low This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0002 mean on the Volkswagen Atlas-cross-sport?
Fuel Volume Regulator Control Circuit Range/Performance This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0001 mean on the Volkswagen Atlas-cross-sport?
Fuel Volume Regulator Control Circuit/Open This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are engine problems common on the Volkswagen Atlas-cross-sport?
Yes — 89 of 407 real owner reports filed with NHTSA mention the engine. One owner reported: “February 2025, just outside the warranty period, the hood latch had become disconnected/broken under the hood. There is a point where the two piece cable is joined under the hood and the cable breaks…” See the owner-reported complaints section below for more.
Are brakes problems common on the Volkswagen Atlas-cross-sport?
Yes — 110 of 407 real owner reports filed with NHTSA mention the brakes. One owner reported: “While driving, the vehicle experiences intermittent electrical malfunctions affecting multiple systems. The door locks cycle repeatedly, windows roll down on their own, and when attempting to roll the…” See the owner-reported complaints section below for more.
Are electrical problems common on the Volkswagen Atlas-cross-sport?
Yes — 153 of 407 real owner reports filed with NHTSA mention the electrical. One owner reported: “Both day time running lights failed right after warranty expired. This repair requires over 2300$ repair because both entire headlights need to be replaced. This is a frequent problem that VW is aware…” See the owner-reported complaints section below for more.
What tyres does the Volkswagen Atlas-Cross-Sport (2020–2024) use?
The original OEM tyre size for the Volkswagen Atlas-Cross-Sport (2020–2024) is 215/55 R16. Compatible alternative sizes: ["265/45R21", "255/55R19", "245/60R18", "245/45R19", "255/50R20"]. See the Tyres section on this page to compare offers from the main suppliers.
What is the right battery for the Volkswagen Atlas-Cross-Sport (2020–2024)?
The battery specified for the Volkswagen Atlas-Cross-Sport (2020–2024) is group H7 (BCI), with a cold cranking rating of 760A. See the Battery section on this page for the main cross-references between brands.
What engine oil should I use on the Volkswagen Atlas-Cross-Sport (2020–2024)?
The engine oil specification for the Volkswagen Atlas-Cross-Sport (2020–2024) is Castrol Edge 0W-20. Always use the viscosity grade approved by the manufacturer: a different oil can reduce engine protection and void the warranty. Check the change interval in the Maintenance section.
Which OBD2 fault codes are commonly documented for the Volkswagen Atlas-Cross-Sport (2020–2024)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Volkswagen Atlas-Cross-Sport (2020–2024) be serviced?
Routine maintenance for the Volkswagen Atlas-Cross-Sport (2020–2024) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
This spec sheet is updated with data verified from OEM sources and shop databases. If you spot an inaccuracy or have additional data on the Volkswagen Atlas-Cross-Sport (2020–2024), let us know — every correction improves quality for all users.