VOLKSWAGEN BEETLE (1998–2019)
TroubleAtlas Score
VOLKSWAGEN BEETLE (1998–2019): Technical Data, DTC & Service Schedule
Built 1998–2019 · all production years covered on this single page
2.5L I5 • Gasoline
🚗 Volkswagen BEETLE 2019
TroubleAtlas Score
An independent value score for the Volkswagen Beetle (1998–2019) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost3.4
Parts & repairability4.4
Maintenance & durabilityn/a
Documentation & support8.8
Independent · Verified · Never for sale
Every figure on this Volkswagen Beetle (1998–2019) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Volkswagen Beetle (1998–2019) uses Castrol Edge 5W-30 engine oil. Its battery is group H6 (BCI), rated at 600A cold-cranking amps. It is powered by a 2.5L I5 engine. Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Engine overheatingFREQUENT
Engine temperature over limits — check coolant level, thermostat and radiator.
Related codes: P0217
Oil pressure sensor: low signalFREQUENT
ECU detects insufficient oil pressure — check oil level and sensor.
Related codes: P0522
Insufficient oil pressureFREQUENT
Oil pressure below critical threshold — stop the engine and check immediately.
Related codes: P0524
Engine control module (PCM) faultFREQUENT
Faulty ECU processor — requires specialist workshop diagnosis.
Related codes: P0606
Throttle actuatorFREQUENT
Throttle actuator motor circuit open — loss of throttle response.
Related codes: P2100
COMMON REPAIRS
Front brake pads
Difficulty: Medium
1.1h
€77 – €99
Rear brake pads
Difficulty: Medium
1.2h
€84 – €108
Engine oil change
Difficulty: Easy
0.4h
€28 – €36
ABS Module
Difficulty: Hard
2.7h
€189 – €243
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.7h | € 121–€ 202 |
| ABS Pump | 3.4h | € 153–€ 255 |
| ABS Tone Ring | 2.0h | € 90–€ 150 |
| ABS Wheel Speed Sensor - Front | 1.1h | € 49–€ 82 |
| ABS Wheel Speed Sensor - Rear | 1.1h | € 49–€ 82 |
| Brake Bleed - All Four | 1.4h | € 62–€ 105 |
| Brake Booster | 3.4h | € 153–€ 255 |
| Brake Booster Check Valve | 0.4h | € 18–€ 30 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 2.0h | € 90–€ 150 |
| Coolant Flush | 1.4h | € 62–€ 105 |
| Coolant Reservoir | 0.7h | € 31–€ 52 |
| Coolant Temperature Sensor | 0.7h | € 31–€ 52 |
| Cooling Fan Assembly | 1.4h | € 62–€ 105 |
| Cooling Fan Clutch | 1.4h | € 62–€ 105 |
| Cooling Fan Motor | 2.0h | € 90–€ 150 |
| Cooling Fan Relay | 0.4h | € 18–€ 30 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.4h | € 62–€ 105 |
| Airbag - Passenger | 2.0h | € 90–€ 150 |
| Airbag - Side | 2.7h | € 121–€ 202 |
| Airbag Module/Computer | 1.4h | € 62–€ 105 |
| Alternator | 2.0h | € 90–€ 150 |
| Alternator Belt | 0.7h | € 31–€ 52 |
| Amplifier | 2.0h | € 90–€ 150 |
| Antenna | 0.7h | € 31–€ 52 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Boost Pressure Sensor | 0.7h | € 31–€ 52 |
| Camshaft Position Sensor | 1.4h | € 62–€ 105 |
| Camshaft R&R | 10.8h | € 486–€ 810 |
| Connecting Rod Bearings | 20.2h | € 909–€ 1515 |
| Crankshaft Position Sensor | 1.4h | € 62–€ 105 |
| Crankshaft R&R | 27.0h | € 1215–€ 2025 |
| Cylinder Head R&R | 8.1h | € 364–€ 607 |
| Cylinder Head Resurface | 10.8h | € 486–€ 810 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 1.1h | € 49–€ 82 |
| Catalytic Converter - California | 2.0h | € 90–€ 150 |
| Catalytic Converter - Direct Fit | 2.0h | € 90–€ 150 |
| Catalytic Converter - Universal | 2.7h | € 121–€ 202 |
| Downpipe | 2.7h | € 121–€ 202 |
| EGR Cooler | 4.1h | € 184–€ 307 |
| EGR Tube | 2.0h | € 90–€ 150 |
| EGR Valve | 1.4h | € 62–€ 105 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.4h | € 62–€ 105 |
| EVAP Purge Valve | 1.1h | € 49–€ 82 |
| EVAP Vent Valve | 1.1h | € 49–€ 82 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 2.0h | € 90–€ 150 |
| Fuel Filter | 0.7h | € 31–€ 52 |
| Fuel Filter - In-Tank | 2.7h | € 121–€ 202 |
| Fuel Injector - Single | 1.4h | € 62–€ 105 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 2.0h | € 90–€ 150 |
| AC Clutch Coil | 2.0h | € 90–€ 150 |
| AC Compressor | 3.4h | € 153–€ 255 |
| AC Compressor Clutch | 2.7h | € 121–€ 202 |
| AC Compressor Oil Add | 0.7h | € 31–€ 52 |
| AC Condenser | 3.4h | € 153–€ 255 |
| AC Evaporator | 8.1h | € 364–€ 607 |
| AC Expansion Valve (TXV) | 5.4h | € 243–€ 405 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 2.0h | € 90–€ 150 |
| Electric Power Steering Module | 2.0h | € 90–€ 150 |
| Electric Power Steering Motor | 3.4h | € 153–€ 255 |
| Idler Arm | 1.4h | € 62–€ 105 |
| Pitman Arm | 1.6h | € 72–€ 120 |
| Power Steering Fluid Flush | 0.7h | € 31–€ 52 |
| Power Steering Gear Box | 4.7h | € 211–€ 352 |
| Power Steering Hose - High Pressure | 1.4h | € 62–€ 105 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.4h | € 62–€ 105 |
| Air Spring/Air Bag | 2.0h | € 90–€ 150 |
| Air Suspension Compressor | 2.0h | € 90–€ 150 |
| Air Suspension Height Sensor | 1.4h | € 62–€ 105 |
| Air Suspension Valve Block | 2.7h | € 121–€ 202 |
| Ball Joint - Lower | 2.4h | € 108–€ 180 |
| Ball Joint - Upper | 2.0h | € 90–€ 150 |
| Ball Joints - Upper and Lower | 4.1h | € 184–€ 307 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Kickdown Cable | 1.1h | € 49–€ 82 |
| Neutral Safety Switch | 1.4h | € 62–€ 105 |
| Overdrive Solenoid | 2.7h | € 121–€ 202 |
| Shift Cable | 2.0h | € 90–€ 150 |
| Shift Linkage | 1.4h | € 62–€ 105 |
| Shift Solenoid - Single | 4.1h | € 184–€ 307 |
| Shift Solenoids - All | 9.0h | € 405–€ 675 |
| Torque Converter | 6.9h | € 310–€ 517 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (32)
NHTSA 24V834000
Air Bags › Frontal › Driver Side › Inflator Module
Date: 30/10/2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Beetle, Beetle Convertible, 2012-2014 Passat, 2017 Passat Wagon, and 2006-2007 Passat Sedan vehicles. The driver's side frontal air bag inflator may explode due to propellant degradation occurring afte…
NHTSA 06E060000
Exterior Lighting
Date: 29/06/2006
CERTAIN AAI MOTORSPORTS COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LIST PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE …
NHTSA 07E023000
Service Brakes, Hydraulic › Foundation Components › Master Cylinder
Date: 29/03/2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MAS…
NHTSA 08V036000
Structure › Body › Roof And Pillars
Date: 28/01/2008
ON CERTAIN SPECIAL EDITION TRIPLE WHITE SEDAN VEHICLES, AN INCORRECT ADHESIVE MAY HAVE BEEN USED TO ATTACH THE ROOF SPOILER TO THE REAR GLASS OF THE VEHICLE. IF THE INCORRECT ADHESIVE WAS USED, THE SPOILER COULD BECOME LOOSE OR FALL FROM THE VEHICLE WITHOUT WARNING, EVEN THOUGH …
NHTSA 15V705000
Engine And Engine Cooling › Engine
Date: 26/10/2015
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Jetta, Beetle, Beetle Convertible, Passat, Golf and Golf SportWagen vehicles. In the affected vehicles, the camshaft lobe that drives the brake vacuum pump may shear off, resulting in a loss…
NHTSA 19V679000
Unknown Or Other
Date: 25/09/2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and B…
NHTSA 06E049000
Exterior Lighting
Date: 24/05/2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE …
NHTSA 06V183000
Exterior Lighting › Brake Lights › Switch
Date: 24/05/2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
NHTSA 20E064000
Service Brakes, Hydraulic › Foundation Components › Master Cylinder
Date: 23/09/2020
Tenneco Automotive (Tenneco) is recalling certain Beck/Arnley Master Cylinders, part number 072-9831, sold as aftermarket or replacement parts for 2004-2018 Volkswagen Jetta, and 2012-2019 Volkswagen Beetle vehicles. The fluid seal crimp on the master cylinder may be insufficien…
NHTSA 06E026000
Exterior Lighting
Date: 23/03/2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108,…
NHTSA 15V028000
Fuel System, Gasoline › Fuel Injection System › Fuel Rail
Date: 23/01/2015
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2014-2015 Jetta vehicles manufactured March 28, 2014, to November 24, 2014, 2014-2015 Passat vehicles manufactured April 7, 2014, to November 18, 2014, 2015 Golf and GTI vehicles manufactured July 1, 2…
NHTSA 19V615000
Electrical System › Ignition › Anti-Theft › Control Module
Date: 22/08/2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless e…
NHTSA 22V945000
Air Bags › Frontal › Driver Side › Inflator Module
Date: 21/12/2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2016 Beetle and Beetle Convertibles vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, an…
NHTSA 11V031000
Seats
Date: 21/01/2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2010 NEW BEETLE AND NEW BEETLE CONVERTIBLE MANUFACTURED FROM SEPTEMBER 1, 2010, THROUGH SEPTEMBER 22, 2010, FOR FAILING TO COMPLY WITH THE BARRIER TEST REQUIREMENTS OF FEDERAL MOTOR VEHICLES SAFETY STANDARDS NO. 208, "OCCUPANT CRASH PRO…
NHTSA 14V656000
Suspension › Rear
Date: 20/10/2014
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2011-2013 Jetta vehicles manufactured March 1, 2010, to November 30, 2012, and 2012-2013 Beetle vehicles manufactured March 1, 2011, to July 31, 2013. The durability of the rear trailing arms may be r…
NHTSA 14V658000
Visibility › Sun/Moon Roof Assembly
Date: 20/10/2014
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2013-2015 Beetle vehicles manufactured June 13, 2013, to July 3, 2014. The glass sunroofs in the affected vehicles may break when the vehicles are operated over a hard road surface or strike a pothole…
NHTSA 07V063000
Exterior Lighting › Brake Lights › Switch
Date: 20/02/2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
NHTSA 08V178000
Air Bags › Frontal › Sensor/Control Module-Inactive
Date: 17/04/2008
VOLKSWAGEN IS RECALLING 76,900 MY 2004-2005 NEW BEETLE AND MY 2003-2005 NEW BEETLE CONVERTIBLES EQUIPPED WITH AN ADVANCED (DUAL-STAGE) AIR BAG SYSTEM. THIS SYSTEM MAY HAVE AIR BAG FRONTAL CRASH SENSORS THAT CONTAIN A SOLDER JOINT ON THE CIRCUIT BOARD THAT MAY CRACK UNDER CERTAI…
NHTSA 20V785000
Air Bags › Frontal
Date: 16/12/2020
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2014 Volkswagen Beetle and Beetle Convertible vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temper…
NHTSA 12V331000
Tires
Date: 16/07/2012
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2012 BEETLE VEHICLES. SOME VEHICLES MAY BE EQUIPPED WITH SUMMER TIRES THAT FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARDS 110 "TIRE SELECTION AND RIMS" AND 139 "NEW PNEUMATIC TIRES FOR LIGHT VEHICLES."
NHTSA 04V586000
Fuel System, Diesel
Date: 15/12/2004
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
NHTSA 12V540000
Air Bags › Frontal › Sensor/Control Module-Inactive
Date: 15/11/2012
Volkswagen is recalling certain model year 2012-2013 Beetle vehicles, manufactured from February 2012, through August 2012, and equipped with leather sport seats. If the right front passenger seat gets wet, the occupant control module may not properly detect the presence of a ch…
NHTSA 14V182000
Power Train › Automatic Transmission › Cooling Unit And Lines
Date: 15/04/2014
Volkswagen of America, Inc. (Volkswagen) is recalling certain model year 2014 Jetta, Beetle, Beetle Convertible, and Passat vehicles equipped with a 1.8T engine and torque converter automatic transmission. In the affected vehicles, the O-ring seals between the oil cooler and the…
NHTSA 98V100000
Electrical System › Wiring › Front Underhood
Date: 13/05/1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ELECTRICAL WIRING LOCATED IN THE ENGINE COMPARTMENT WAS ROUTED TOO CLOSE TO THE ENDGE OF THE VEHICLE'S BATTERY TRAY. THE WIRING CAN BECOME DAMAGED OVER TIME BY CHAFING AND THE AIR-CONDITIONER COMPRESSOR AND/OR THE FUEL PUMP CAN MALF…
NHTSA 19V094000
Electrical System › Instrument Cluster/Panel
Date: 13/02/2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Beetle and Beetle Convertible vehicles. The instrument cluster may not provide a visual warning when a brake system failure is detected. As a result, the vehicles fail to comply with Federal Motor Vehicle …
NHTSA 08E050000
Exterior Lighting › Headlights
Date: 11/08/2008
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLE…
NHTSA 10V621000
Fuel System, Gasoline › Delivery › Hoses, Lines/Piping, And Fittings
Date: 10/12/2010
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOC…
NHTSA 06V043000
Equipment › Other › Labels
Date: 09/02/2006
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 17-INCH WHEELS AND A 2.5L ENGINE FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE PRODUCED WITH A TIRE INFORMATION LABEL THAT LISTS AN INCORRECT FRONT TIRE…
NHTSA 09E012000
Exterior Lighting
Date: 07/04/2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
NHTSA 14E007000
Engine And Engine Cooling › Engine
Date: 07/03/2014
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a bl…
NHTSA 17V136000
Equipment › Other › Labels
Date: 02/03/2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Beetle and Jetta GLI vehicles. The affected vehicles have incorrect information on the tire information label, possibly causing the operator to overload the vehicle. As such, these vehicles fail to comply …
NHTSA 18V369000
Service Brakes, Hydraulic › Foundation Components › Disc › Caliper
Date: 01/06/2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas, Passat, Beetle, Beetle Convertible, Golf, Golf SportWagen and GTI and Audi Q5 and SQ5 vehicles. The brake caliper pistons on these vehicles may have insufficient coating, potentially reduc…
COMMON OBD2 CODES TO CHECK
P0420
Catalyst System Efficiency Below Threshold Bank 1
Powertrain
P0171
System Too Lean Bank 1
Powertrain
P0300
Random/Multiple Cylinder Misfire Detected
Powertrain
P0441
EVAP Incorrect Purge Flow
Powertrain
P0128
Coolant Thermostat Below Regulating Temperature
Powertrain
P0455
EVAP System Leak Detected (Gross Leak)
Powertrain
P0700
Transmission Control System (MIL Request)
Powertrain
P0507
Idle Air Control System RPM Higher Than Expected
Powertrain
P0174
System Too Lean Bank 2
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P1425
powertrain
LOWP1420
powertrain
MODERATEP1177
powertrain
MODERATEP1176
powertrain
MODERATEP1141
powertrain
HIGHP1136
powertrain
MODERATEP1225
powertrain
HIGHP1214
powertrain
HIGHP1213
powertrain
HIGHP1388
powertrain
HIGHP1564
powertrain
MODERATEP1544
powertrain
HIGHP1543
powertrain
HIGHP1296
powertrain
MODERATEP1137
powertrain
MODERATEP1102
powertrain
MODERATEP1297
powertrain
HIGHP1105
powertrain
MODERATEP1410
powertrain
LOWP1340
powertrain
MODERATE
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
88 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
Doors OpenChassis
Hood Open DualChassis
Trunk Open DualChassis
Ignition MalfunctionEngine
WheelEngine
Lights Ignition Steering MalfunctionChassis
Dsg Transmission Too HotTransmission
Electronic Parking Brake EngagedBrakes
Brake System MalfunctionBrakes
Brake WearBrakes
Engine CoolantEngine
Engine Oil Pressure LowEngine
12V Alternator MalfunctionElectrical
Cruise Control MalfunctionADAS
Brake PedalBrakes
Front Assist Collision WarningADAS
Differential Lock MalfunctionEngine
AdblueFuel
Error In Hybrid SystemElectrical
Central Warning LightLighting
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
AdBlue Level Low (VW) (Volkswagen)Emissions
EPC — Engine Control (VW) (Volkswagen)Engine
Glow Plug Fault (VW) (Volkswagen)Engine
DSG Fault (Volkswagen)Transmission
TpmsTyres
Open Rear LidEngine
Ignition Switch Starter ButtonEngine
Electronic ImmobilizerEngine
Fuel Tank Almost EmptyFuel
Front Fog Lights Switched OnLighting
Parking Lights Switched OnBrakes
Driving Lights Burned OutLighting
Adaptive Front Lighting System MalfunctionLighting
Headlight Range Adjustment MalfunctionLighting
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
DPF Regeneration (VW) (Volkswagen)Emissions
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
650 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Volkswagen Beetle across model years 1998–2019. These are real, verified reports submitted by vehicle owners.
30 crash reports 18 fires 19 injuries
Complaints by model year (most reported first)
Model year 1998170
Model year 201599
Model year 201398
Model year 201265
Model year 201657
Model year 201454
Model year 200933
Model year 201030
Most reported components (all years)
Air Bags192
Electrical System134
Unknown Or Other62
Visibility57
Engine35
Exterior Lighting35
Sample reports
TL*THE CONTACT OWNS A 1998 VOLKSWAGEN BEETLE. THE CONTACT WAS NOT THE DRIVER AT THE TIME OF THE INCIDENT. WHILE DRIVING APPROXIMATELY 55 MPH ON A SNOW COVERED ROAD, THE DRIVER NOTICED AN 18-WHEELER HEADING TOWARDS THE VEHICLE. THE DRI… (MY 1998)
I WAS DRIVING MY 98 BUG WHEN THE ENTIRE SEAT FELL OFF THE TRACK, AND I FELL IN THE BACKSEAT, THE CAR STALLED WHILE ON A 45 MPH ROAD I WAS NOT INJURED.KEFFER VOLK RECURED THE SEAT BUT SAY I WILL COST $1000 FOR A NEW FLOOR TRACK. VOLKS S… (MY 1998)
ALL OF A SUDDEN YOU ARE DRIVING THE CAR AND IT STALLS, YOU TRY TO ACCELERATE IT AND IT DOESN'T MOVE AND TURNS OFF IN THE MIDDLE OF THE HIGHWAY. BIG SAFETY CONCERN. IT HAS HAPPENED SEVERAL TIMES AND HAS BEEN TO THE VW DEALER SERVICE DEPAR… (MY 2010)
TL* THE CONTACT OWNS A 2017 VOLKSWAGEN BEETLE. WHILE THE VEHICLE WAS PARKED, THE CONTACT WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. THE CONTACT HAD TO TURN THE STEERING WHEEL SEVERAL TIMES IN ORDER TO REMOVE THE KEY FROM THE IGNITIO… (MY 2017)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 1998–2019.
Frequently Asked Questions
Does the Volkswagen Beetle have any safety recalls?
Yes — 32 official NHTSA recall campaign(s) affect this model, mainly: ENGINE AND ENGINE COOLING:ENGINE, EXTERIOR LIGHTING, EXTERIOR LIGHTING:HEADLIGHTS. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Volkswagen Beetle?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Volkswagen Beetle?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Volkswagen Beetle?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are engine problems common on the Volkswagen Beetle?
Yes — 101 of 608 real owner reports filed with NHTSA mention the engine. One owner reported: “DAUGHTER WAS DRIVING TO SCHOOL, CAR STALLED, RESTARTED CAR THEN SAW SMOKE AND FIRE UNDER PASSENGER SIDE DASH. CAR BURNT COMPLETELY, TOTALED. HAVE BEFORE AND AFTER PICTURES. ..UPDATED 11/12/14 *BF…” See the owner-reported complaints section below for more.
Are electrical problems common on the Volkswagen Beetle?
Yes — 162 of 608 real owner reports filed with NHTSA mention the electrical. One owner reported: “The driver was driving the speed limit (55 mph) and tried to slow down as they approached a red light. The brakes failed to work, and the driver rear-ended the vehicle waiting at the stoplight. The ai…” See the owner-reported complaints section below for more.
Are airbags problems common on the Volkswagen Beetle?
Yes — 182 of 608 real owner reports filed with NHTSA mention the airbags. One owner reported: “The driver was driving the speed limit (55 mph) and tried to slow down as they approached a red light. The brakes failed to work, and the driver rear-ended the vehicle waiting at the stoplight. The ai…” See the owner-reported complaints section below for more.
What tyres does the Volkswagen Beetle (1998–2019) use?
The original OEM tyre size for the Volkswagen Beetle (1998–2019) is 215/55 R16. Compatible alternative sizes: ["215/55R17", "235/40R19", "215/60R16", "235/45R18", "245/45R19"]. See the Tyres section on this page to compare offers from the main suppliers.
What is the right battery for the Volkswagen Beetle (1998–2019)?
The battery specified for the Volkswagen Beetle (1998–2019) is group H6 (BCI), with a cold cranking rating of 600A. See the Battery section on this page for the main cross-references between brands.
What engine oil should I use on the Volkswagen Beetle (1998–2019)?
The engine oil specification for the Volkswagen Beetle (1998–2019) is Castrol Edge 5W-30. Always use the viscosity grade approved by the manufacturer: a different oil can reduce engine protection and void the warranty. Check the change interval in the Maintenance section.
Which OBD2 fault codes are commonly documented for the Volkswagen Beetle (1998–2019)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Volkswagen Beetle (1998–2019) be serviced?
Routine maintenance for the Volkswagen Beetle (1998–2019) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Bookmark this page to consult it at the workshop or when buying parts. TroubleAtlas updates its technical data continuously — check back for new information on the Volkswagen Beetle (1998–2019).