TroubleAtlas Score
VOLKSWAGEN RABBIT (2006–2009) Manual — Codes, Tyres & Parts
Built 2006–2009 · all production years covered on this single page
2.5L I5 • Gasoline
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Volkswagen Rabbit (2006–2009) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost3.5
Parts & repairability7.8
Maintenance & durabilityn/a
Documentation & support9.5
Independent · Verified · Never for sale
Every figure on this Volkswagen Rabbit (2006–2009) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Volkswagen Rabbit (2006–2009) uses Castrol Edge 5W-30 engine oil. Its battery is group H6 (BCI), rated at 600A cold-cranking amps. It is powered by a 2.5L I5 engine. Its OEM tyre size is 215/55 R16. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Related codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Related codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Related codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Related codes: P0562
P0011LOW
Check with an OBD2 scanner.
Related codes: P0011
COMMON REPAIRS
Front brake pads
Difficulty: Medium
1.1h
€77 – €99
Rear brake pads
Difficulty: Medium
1.2h
€84 – €108
Engine oil change
Difficulty: Easy
0.4h
€28 – €36
ABS Module
Difficulty: Hard
2.7h
€189 – €243
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
OFFICIAL LABOUR TIMES (OLP)
Standard labour hours from a database of 6.6M+ real shop operations, with an indicative labour-cost estimate for your country.
Brakes8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| ABS Module | 2.7h | € 121–€ 202 |
| ABS Pump | 3.4h | € 153–€ 255 |
| ABS Tone Ring | 2.0h | € 90–€ 150 |
| ABS Wheel Speed Sensor - Front | 1.1h | € 49–€ 82 |
| ABS Wheel Speed Sensor - Rear | 1.1h | € 49–€ 82 |
| Brake Bleed - All Four | 1.4h | € 62–€ 105 |
| Brake Booster | 3.4h | € 153–€ 255 |
| Brake Booster Check Valve | 0.4h | € 18–€ 30 |
Cooling8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Coolant Bypass Pipe | 2.0h | € 90–€ 150 |
| Coolant Flush | 1.4h | € 62–€ 105 |
| Coolant Reservoir | 0.7h | € 31–€ 52 |
| Coolant Temperature Sensor | 0.7h | € 31–€ 52 |
| Cooling Fan Assembly | 1.4h | € 62–€ 105 |
| Cooling Fan Motor | 2.0h | € 90–€ 150 |
| Cooling Fan Relay | 0.4h | € 18–€ 30 |
| Engine Oil Cooler | 2.7h | € 121–€ 202 |
Electrical8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Airbag - Driver | 1.4h | € 62–€ 105 |
| Airbag - Passenger | 2.0h | € 90–€ 150 |
| Airbag - Side | 2.7h | € 121–€ 202 |
| Airbag Module/Computer | 1.4h | € 62–€ 105 |
| Alternator | 2.0h | € 90–€ 150 |
| Alternator Belt | 0.7h | € 31–€ 52 |
| Amplifier | 2.0h | € 90–€ 150 |
| Antenna | 0.7h | € 31–€ 52 |
Engine8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Camshaft Position Sensor | 1.4h | € 62–€ 105 |
| Camshaft R&R | 10.8h | € 486–€ 810 |
| Connecting Rod Bearings | 20.2h | € 909–€ 1515 |
| Crankshaft Position Sensor | 1.4h | € 62–€ 105 |
| Crankshaft R&R | 27.0h | € 1215–€ 2025 |
| Cylinder Head R&R | 8.1h | € 364–€ 607 |
| Cylinder Head Resurface | 10.8h | € 486–€ 810 |
| Engine Mount - Front | 2.0h | € 90–€ 150 |
Exhaust8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Injection Check Valve | 1.1h | € 49–€ 82 |
| Catalytic Converter - California | 2.0h | € 90–€ 150 |
| Catalytic Converter - Direct Fit | 2.0h | € 90–€ 150 |
| Catalytic Converter - Universal | 2.7h | € 121–€ 202 |
| Downpipe | 2.7h | € 121–€ 202 |
| EGR Cooler | 4.1h | € 184–€ 307 |
| EGR Tube | 2.0h | € 90–€ 150 |
| EGR Valve | 1.4h | € 62–€ 105 |
Fuel system8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Charcoal Canister | 1.4h | € 62–€ 105 |
| EVAP Purge Valve | 1.1h | € 49–€ 82 |
| EVAP Vent Valve | 1.1h | € 49–€ 82 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 2.0h | € 90–€ 150 |
| Fuel Filter | 0.7h | € 31–€ 52 |
| Fuel Filter - In-Tank | 2.7h | € 121–€ 202 |
| Fuel Injector - Single | 1.4h | € 62–€ 105 |
HVAC8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| AC Accumulator | 2.0h | € 90–€ 150 |
| AC Clutch Coil | 2.0h | € 90–€ 150 |
| AC Compressor | 3.4h | € 153–€ 255 |
| AC Compressor Clutch | 2.7h | € 121–€ 202 |
| AC Compressor Oil Add | 0.7h | € 31–€ 52 |
| AC Condenser | 3.4h | € 153–€ 255 |
| AC Evaporator | 8.1h | € 364–€ 607 |
| AC Expansion Valve (TXV) | 5.4h | € 243–€ 405 |
Steering8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Center Link/Drag Link | 2.0h | € 90–€ 150 |
| Electric Power Steering Module | 2.0h | € 90–€ 150 |
| Electric Power Steering Motor | 3.4h | € 153–€ 255 |
| Idler Arm | 1.4h | € 62–€ 105 |
| Pitman Arm | 1.6h | € 72–€ 120 |
| Power Steering Fluid Flush | 0.7h | € 31–€ 52 |
| Power Steering Gear Box | 4.7h | € 211–€ 352 |
| Power Steering Hose - High Pressure | 1.4h | € 62–€ 105 |
Suspension8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Air Line | 1.4h | € 62–€ 105 |
| Air Spring/Air Bag | 2.0h | € 90–€ 150 |
| Air Suspension Compressor | 2.0h | € 90–€ 150 |
| Air Suspension Height Sensor | 1.4h | € 62–€ 105 |
| Air Suspension Valve Block | 2.7h | € 121–€ 202 |
| Ball Joint - Lower | 2.4h | € 108–€ 180 |
| Ball Joint - Upper | 2.0h | € 90–€ 150 |
| Ball Joints - Upper and Lower | 4.1h | € 184–€ 307 |
Transmission8 operations
| Operation | Labour hours (OLP) | Est. labour cost |
|---|---|---|
| Kickdown Cable | 1.1h | € 49–€ 82 |
| Neutral Safety Switch | 1.4h | € 62–€ 105 |
| Overdrive Solenoid | 2.7h | € 121–€ 202 |
| Shift Cable | 2.0h | € 90–€ 150 |
| Shift Linkage | 1.4h | € 62–€ 105 |
| Transmission Control Module | 1.4h | € 62–€ 105 |
| Transmission Cooler Lines | 1.4h | € 62–€ 105 |
| Transmission Filter | 1.4h | € 62–€ 105 |
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (3)
NHTSA 07V442000
Exterior Lighting › Headlights
Date: 24/09/2007
CERTAIN VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." SOME VEHICLES MAY NOT HAVE HAD A REQUIRED CAP INSTALLED WHICH DISABLES THE HEADLIGHT HORIZONTAL AIM AND SOME VEHICLES M…
NHTSA 16V913000
Service Brakes, Hydraulic › Antilock/Traction Control/Electronic Limited Slip
Date: 20/12/2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fai…
NHTSA 10V621000
Fuel System, Gasoline › Delivery › Hoses, Lines/Piping, And Fittings
Date: 10/12/2010
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOC…
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P0455
powertrain
LOW⏱ 0.62h avgP0442
powertrain
LOW⏱ 0.62h avgP0440
powertrain
LOW⏱ 0.78h avgP0420
powertrain
MEDIUM⏱ 1.24h avgP0300
powertrain
HIGH⏱ 1.22h avgP0172
powertrain
MEDIUM⏱ 1.13h avgP0171
powertrain
MEDIUM⏱ 0.95h avgP0730
transmission
MEDIUM⏱ 1.25h avgP0700
transmission
HIGH⏱ 1.25h avgP0401
powertrain
MEDIUM⏱ 1.25h avgP0011
powertrain
MEDIUM⏱ 5.4h avgU0100
network
HIGHP0562
electrical
MEDIUM⏱ 0.58h avgP0128
powertrain
MEDIUM⏱ 0.88h avg
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
88 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
Doors OpenChassis
Hood Open DualChassis
Trunk Open DualChassis
Ignition MalfunctionEngine
WheelEngine
Lights Ignition Steering MalfunctionChassis
Dsg Transmission Too HotTransmission
Electronic Parking Brake EngagedBrakes
Brake System MalfunctionBrakes
Brake WearBrakes
Engine CoolantEngine
Engine Oil Pressure LowEngine
12V Alternator MalfunctionElectrical
Cruise Control MalfunctionADAS
Brake PedalBrakes
Front Assist Collision WarningADAS
Differential Lock MalfunctionEngine
AdblueFuel
Error In Hybrid SystemElectrical
Central Warning LightLighting
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
AdBlue Level Low (VW) (Volkswagen)Emissions
EPC — Engine Control (VW) (Volkswagen)Engine
Glow Plug Fault (VW) (Volkswagen)Engine
DSG Fault (Volkswagen)Transmission
TpmsTyres
Open Rear LidEngine
Ignition Switch Starter ButtonEngine
Electronic ImmobilizerEngine
Fuel Tank Almost EmptyFuel
Front Fog Lights Switched OnLighting
Parking Lights Switched OnBrakes
Driving Lights Burned OutLighting
Adaptive Front Lighting System MalfunctionLighting
Headlight Range Adjustment MalfunctionLighting
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
DPF Regeneration (VW) (Volkswagen)Emissions
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
152 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Volkswagen Rabbit across model years 2006–2009. These are real, verified reports submitted by vehicle owners.
12 crash reports 10 fires 6 injuries 1 death
Complaints by model year (most reported first)
Model year 200962
Model year 200754
Model year 200823
Model year 200613
Most reported components (all years)
Service Brakes51
Electrical System28
Electronic Stability Control (Esc)26
Steering17
Air Bags16
Power Train15
Sample reports
REAR BRAKE PADS WORN QUICKER THAN NORMAL, AT 12,000 MILES THEY STARTED WEARING DOWN AND THE METALLIC SOUND STARTED TO OCCUR. *TR (MY 2007)
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN RABBIT. WHEN STARTING OFF FROM A STOPPED POSITION AND THE CONSUMER STEPS ON THE ACCELERATOR, THE VEHICLE MOVES FORWARD ABOUT TEN FEET AND THEN DIES NO RESPONSE FROM THE ACCELERATOR. IN THE SAME POSI… (MY 2006)
***NOTE: THIS WAS A VW RABBIT, NOT A VW GOLF, BUT RABBIT WAS NOT AN OPTION UNDER THE REQUIRED MODEL*** AT 12:30AM ON DECEMBER 23, 2006, I PARKED MY 2006 VW RABBIT IN MY DRIVEWAY. I THEN PLUGGED IN THE BLOCK HEATER, AS USUAL. AT 11AM THAT… (MY 2006)
PULLED CAR UP TO PROPANE DISPLAY OUTSIDE OF HEB GROCERY STORE. ONCE TANKS WERE EXCHANGED, NOTICED SMOKE BILLOWING FROM ENGINE. TURNED CARE OFF, GOT OUT AND NOTICED FIRE UNDERNEATH ENGINE. STORE EMPLOYEE GOT HOOD OPEN, DOUSED FIRE. CALLED… (MY 2008)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 2006–2009.
Frequently Asked Questions
Does the Volkswagen Rabbit have any safety recalls?
Yes — 3 official NHTSA recall campaign(s) affect this model, mainly: EXTERIOR LIGHTING:HEADLIGHTS, FUEL SYSTEM, GASOLINE:DELIVERY:HOSES. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Volkswagen Rabbit?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Volkswagen Rabbit?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Volkswagen Rabbit?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are engine problems common on the Volkswagen Rabbit?
Yes — 36 of 150 real owner reports filed with NHTSA mention the engine. One owner reported: “MY WIFE WAS DRIVING HER 2006 VOLKSWAGEN RABBIT ON US 98 PREPARING TO ENTER I-4 WHEN THE VEHICLE ENTERED LIMP HOME MODE (EPC LIGHT & CHECK ENGINE LIGHT ON) RPMS WENT TO OVER 3000 AND VEHICLE REFUSED TO…” See the owner-reported complaints section below for more.
Are electrical problems common on the Volkswagen Rabbit?
Yes — 53 of 150 real owner reports filed with NHTSA mention the electrical. One owner reported: “MY WIFE WAS DRIVING HER 2006 VOLKSWAGEN RABBIT ON US 98 PREPARING TO ENTER I-4 WHEN THE VEHICLE ENTERED LIMP HOME MODE (EPC LIGHT & CHECK ENGINE LIGHT ON) RPMS WENT TO OVER 3000 AND VEHICLE REFUSED TO…” See the owner-reported complaints section below for more.
Are brakes problems common on the Volkswagen Rabbit?
Yes — 65 of 150 real owner reports filed with NHTSA mention the brakes. One owner reported: “2006 VOLKSWAGEN RABBIT. HIGH MOUNT CENTER THIRD BRAKE LIGHT IS INACCESSIBLE. BULB IS BLOWN OUT AND I CANNOT ACCESS TO REPAIR IT. *TR…” See the owner-reported complaints section below for more.
What tyres does the Volkswagen Rabbit (2006–2009) use?
The original OEM tyre size for the Volkswagen Rabbit (2006–2009) is 215/55 R16. Compatible alternative sizes: ["245/45R19", "195/65R15", "205/55R16"]. See the Tyres section on this page to compare offers from the main suppliers.
What is the right battery for the Volkswagen Rabbit (2006–2009)?
The battery specified for the Volkswagen Rabbit (2006–2009) is group H6 (BCI), with a cold cranking rating of 600A. See the Battery section on this page for the main cross-references between brands.
What engine oil should I use on the Volkswagen Rabbit (2006–2009)?
The engine oil specification for the Volkswagen Rabbit (2006–2009) is Castrol Edge 5W-30. Always use the viscosity grade approved by the manufacturer: a different oil can reduce engine protection and void the warranty. Check the change interval in the Maintenance section.
Which OBD2 fault codes are commonly documented for the Volkswagen Rabbit (2006–2009)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Volkswagen Rabbit (2006–2009) be serviced?
Routine maintenance for the Volkswagen Rabbit (2006–2009) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Have a specific fault code on your Volkswagen Rabbit (2006–2009)? Search the code in the OBD2 section of this page or use the full TroubleAtlas DTC database. Need tyres? Compare prices and compatible sizes in the TroubleAtlas comparator.