VOLVO 760 (1982–1992) — Verified Specs, Fluids & OBD2
Built 1982–1992 · all production years covered on this single page
2.3L I4 Turbo • Gasoline
1992
© Wikimedia Commons CC BY-SA
Every figure on this Volvo 760 (1982–1992) page is aggregated and cross-checked against more than 6.6 million real workshop operations, NHTSA records and OEM technical sources — and updated continuously. No invented estimates.
The Volvo 760 (1982–1992) is powered by a 2.3L I4 Turbo engine. Use the sections below for verified fluids, battery, OEM tyres, the maintenance schedule, recommended parts and the most commonly reported OBD2 fault codes for this vehicle.
Common problems
Common repairs
Fluids & lubricants
Battery
Fault codes (OBD2)
Dashboard lights
Parts comparator
Accessories & tools
Tyres
Recalls & TSB
Complaints
Workshops nearby
COMMON PROBLEMS
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Related codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Related codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Related codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Related codes: P0562
P0011LOW
Check with an OBD2 scanner.
Related codes: P0011
AVERAGE INDICATIVE COSTS
Prices may vary by area and workshop.
Full service
€ 120 – € 200
Full brake service
€ 180 – € 300
Spark plug replacement
€ 80 – € 140
Electronic diagnosis
€ 40 – € 70
WORKSHOP LABOUR RATES BY COUNTRY
Average independent-workshop hourly labour rates, to estimate repair costs in your country.
🇩🇪Germany€95/h
🇪🇸Spain€55/h
🇫🇷France€75/h
🇮🇹Italy€45/h
🇬🇧UK£80/h
🇺🇸USA$120/h
Reference rate
€45/h
Source: Eurostat 2024
💧 FLUIDS & LUBRICANTS
📋 RECALLS & TSB (7)
NHTSA 87V195000
Exterior Lighting › Headlights › Switch
Date: 29/12/1987
HEADLIGHT SWITCH CONTAINS COMPONENTS WHICH MAY COME LOOSE UPON OPERATION AND CAUSE SHORT CIRCUITS IN THE SWITCH.
NHTSA 84V018000
Service Brakes, Hydraulic › Brake Fluid Low Warning › Lamp
Date: 22/02/1984
THE BRAKE WARNING SWITCH MAY HAVE COMPONENTS THAT HAVE BEEN IMPROPERLY MANUFACTURED. BRAKE FLUID MAY SEEP FROM THE SWITCH WITHOUT TRIGGERING THE BRAKE WARNING SWITCH.
NHTSA 87V064000
Electrical System › Wiring › Front Underhood
Date: 11/05/1987
ENGINE WIRING HARNESS COULD CHAFE AGAINST AN AIR CONDITIONING PIPE.
NHTSA 91V010000
Fuel System, Gasoline › Delivery › Fuel Pump
Date: 08/01/1991
IF CONDITIONS OF HIGH AMBIENT TEMPERATURE, OVERFILLING OF THE FUEL TANK, AND INSUFFICIENT TORQUE ON THE SENDING UNIT LOCK RING EXIST SIMULTANEOUSLY, FUEL SEEPAGE MAY OCCUR FROM THE TOP OF THE TANK.
NHTSA 91V075000
Seat Belts › Front › Anchorage
Date: 06/05/1991
SAFETY BELTS ARE DESIGNED TO BE ROUTED UNDER A DIAGONAL CROSS BRACE DURING FASTENING. THE INSTRUCTIONAL LABELS FOR THE BELT ROUTING ARE INADEQUATE, AND CAN RESULT IN INADVERTENT RELEASE OF THE BELT BUCKLE.
NHTSA 91V075000
Seat Belts › Front › Anchorage
Date: 06/05/1991
SAFETY BELTS ARE DESIGNED TO BE ROUTED UNDER A DIAGONAL CROSS BRACE DURING FASTENING. THE INSTRUCTIONAL LABELS FOR THE BELT ROUTING ARE INADEQUATE, AND CAN RESULT IN INADVERTENT RELEASE OF THE BELT BUCKLE.
NHTSA 91V075000
Seat Belts › Front › Anchorage
Date: 06/05/1991
SAFETY BELTS ARE DESIGNED TO BE ROUTED UNDER A DIAGONAL CROSS BRACE DURING FASTENING. THE INSTRUCTIONAL LABELS FOR THE BELT ROUTING ARE INADEQUATE, AND CAN RESULT IN INADVERTENT RELEASE OF THE BELT BUCKLE.
COMMON OBD2 CODES TO CHECK
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
All documented fault codes for this vehicle
The most documented diagnostic codes for this model, by system and severity. Tap a code for the full guide.
P0455
powertrain
LOW⏱ 0.62h avgP0442
powertrain
LOW⏱ 0.62h avgP0440
powertrain
LOW⏱ 0.78h avgP0420
powertrain
MEDIUM⏱ 1.24h avgP0300
powertrain
HIGH⏱ 1.22h avgP0172
powertrain
MEDIUM⏱ 1.13h avgP0171
powertrain
MEDIUM⏱ 0.95h avgP0730
transmission
MEDIUM⏱ 1.25h avgP0700
transmission
HIGH⏱ 1.25h avgP0401
powertrain
MEDIUM⏱ 1.25h avgP0011
powertrain
MEDIUM⏱ 5.4h avgU0100
network
HIGHP0562
electrical
MEDIUM⏱ 0.58h avgP0128
powertrain
MEDIUM⏱ 0.88h avg
DASHBOARD WARNING LIGHTS — UNIVERSAL GUIDE
53 warning lights classified by urgency. Appears on your vehicle? Check the urgency level.
Show all dashboard warning lights
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
REPORTED COMPLAINTS & PROBLEMS (NHTSA)
56 owner complaints filed with the U.S. National Highway Traffic Safety Administration (NHTSA) for the Volvo 760 across model years 1982–1992. These are real, verified reports submitted by vehicle owners.
17 crash reports 5 fires 14 injuries
Complaints by model year (most reported first)
Model year 199014
Model year 198914
Model year 198712
Model year 19889
Model year 19865
Model year 19852
Most reported components (all years)
Vehicle Speed Control14
Electrical System10
Air Bags7
Engine And Engine Cooling7
Power Train4
Fuel System4
Sample reports
REPLACED ENGINE DUE TO RADIATOR FAILURE (OTHER VEHICLE ON 479655). *AK (MY 1989)
RADIATOR FAILED/MANUFACTURER REFUSED TO REPLACE ENGINE (OTHER VEHICLE FROM 478327). *AK (MY 1988)
WHILE DRIVING ON THE STREET AT APPROXIMATELY 30 MPH, A FIRE DEVELOPED UNDER THE UNDER CARRIAGE NEAR THE FUEL TANK ASSEMBLY. DEALER/MANUFACTURER NOTIFIED. *AK (MY 1988)
NO DEPLOYMENT OF AIRBAG IN ACCIDENT. (MY 1988)
Source: NHTSA complaints database (U.S. data.gov). Figures cover production years 1982–1992.
Frequently Asked Questions
Does the Volvo 760 have any safety recalls?
Yes — 7 official NHTSA recall campaign(s) affect this model, mainly: FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP, SEAT BELTS:FRONT:ANCHORAGE. Check the recalls section for your exact year/VIN.
What does fault code P0300 mean on the Volvo 760?
Random/Multiple Cylinder Misfire Detected This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0128 mean on the Volvo 760?
Coolant temperature below thermostat regulating temperature — thermostat stuck open or faulty This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
What does fault code P0011 mean on the Volvo 760?
A Camshaft Position Timing Over-Advanced or System Performance (Bank 1) This code is among the most documented for this model — tap it in the OBD2 section for the full step-by-step guide.
Are electrical problems common on the Volvo 760?
Yes — 6 of 48 real owner reports filed with NHTSA mention the electrical. One owner reported: “RECALL 87 V 064 000/ELECTRICAL SYSTEM WIRING HARNESS, FRONT UNDERHOOD:ELECTRICAL SYSTEM HAVE VARIOUS SHORTAGES IN INSTRUMENT PANEL/ RADIO, ETC; DEALER WAS NOTIFIED, AND INFORMED CONSUMER THAT THIS V…” See the owner-reported complaints section below for more.
Are airbags problems common on the Volvo 760?
Yes — 7 of 48 real owner reports filed with NHTSA mention the airbags. One owner reported: “DRIVING VEHICLE, COMING OUT OF SIDE STREET, ANOTHER VEHICLE, W/OUT LIGHTS ON, APPEARED, VOLVO HIT VEHICLE BROADSIDE, AIR BAGS DID NOT DEPLOY AT ALL. *AK…” See the owner-reported complaints section below for more.
Are brakes problems common on the Volvo 760?
Yes — 10 of 48 real owner reports filed with NHTSA mention the brakes. One owner reported: “WHEN PUTTING THE CAR IN REVERSE AND THE FOOT ON THE BRAKE, THE CAR WENT OUT OF CONTROL AND HIT 4 OTHER CARS. PLEASE DESCRIBE. *AK…” See the owner-reported complaints section below for more.
Which OBD2 fault codes are commonly documented for the Volvo 760 (1982–1992)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Volvo 760 (1982–1992) be serviced?
Routine maintenance for the Volvo 760 (1982–1992) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Found what you were looking for? Explore other Volvo models in our database, compare tyre offers in your size, or search a specific fault code in the TroubleAtlas OBD2 database.