Saturn Ion (2003–2007) Technical Guide — DTC, Fluids & Parts | TroubleAtlas

🌐 ▾
Startseite› Fahrzeuge› Saturn› Ion› 2007
Saturn Ion (2003–2007)
Die TroubleAtlas App auf dem HandyTROUBLEATLAS APP · GRATISGRATIS-APPLaden Sie unsere kostenlose AppKostenlose App ladenUnser Einkaufszentrum in der Tasche: Dutzende Anbieter, die in Ihr Land liefern, im Vergleich, Abteilung für Abteilung.Dutzende Anbieter im Vergleich, in Ihrem Land. Gratis laden Gratis laden

SATURN ION (2003–2007) Manual — Codes, Tyres & Parts

By TroubleAtlas Technical Team · Updated 14 July 2026 · Cross-checked against 3 independent sources
Built 2003–2007 · all production years covered on this single page

2.2L I4 • Benzin

2007
Saturn Ion (2003–2007)

© Wikimedia Commons CC BY-SA

5 Häufige Probleme Details ansehen →
14 OBD2-Codes Details ansehen →
35 Rückrufe / Bulletins Details ansehen →

Alle Daten auf dieser Seite zu Saturn Ion (2003–2007) sind aus über 6,6 Millionen realen Werkstattvorgängen, NHTSA-Registern und technischen OEM-Quellen zusammengeführt und abgeglichen — und werden laufend aktualisiert. Keine erfundenen Schätzungen.

Angetrieben von einem 2.2L I4-Motor. Nutzen Sie die Abschnitte unten für verifizierte Betriebsstoffe, Batterie, OEM-Reifen, den Wartungsplan, die empfohlenen Ersatzteile und die am häufigsten gemeldeten OBD2-Fehlercodes für dieses Fahrzeug.

⚠️Häufige Probleme 🔧Häufige Reparaturen 💧Betriebsstoffe und Schmierstoffe 🔋Batterie 🔌Fehlercodes (OBD2) 🔴Kontrollleuchten 🛒Empfohlene Ersatzteile 🔧Zubehör und Werkzeuge 🛞Reifen 📋Rückrufe und Bulletins 📢Beschwerden 📍Werkstätten in der Nähe
⚠️ HÄUFIGE PROBLEME
Transmission fault signal (TCM)MODERATE

The transmission module detected a fault — check separate transmission codes.

Verwandte Codes: P0700

Misfire / Loss of cylinderMODERATE

Rough running, idle vibration, power loss.

Verwandte Codes: P0300

Thermostat: coolant temperature lowLOW

Thermostat stuck open — engine does not reach operating temperature.

Verwandte Codes: P0128

Battery/system voltage lowLOW

System voltage below 10V — check alternator, battery or wiring.

Verwandte Codes: P0562

P0011LOW

Check with an OBD2 scanner.

Verwandte Codes: P0011

💰 DURCHSCHNITTLICHE RICHTKOSTEN

Die Preise können je nach Region und Werkstatt variieren.

🔧
Komplette Wartung
€ 120 – € 200
🛑
Komplette Bremsen
€ 180 – € 300
⚡
Zündkerzenwechsel
€ 80 – € 140
📊
Elektronische Diagnose
€ 40 – € 70
💵 WERKSTATT-STUNDENSÄTZE NACH LAND

Durchschnittliche Stundensätze unabhängiger Werkstätten, zur Schätzung der Reparaturkosten in Ihrem Land.

🇩🇪Deutschland€95/h
🇪🇸Spanien€55/h
🇫🇷Frankreich€75/h
🇮🇹Italien€45/h
🇬🇧Vereinigtes Königreich£80/h
🇺🇸USA$120/h
Referenzsatz
€95/h
Quelle: Eurostat 2024
💧 BETRIEBSSTOFFE UND SCHMIERSTOFFE
📋 RÜCKRUFE UND BULLETINS (35)
NHTSA 14V153000
Steering › Electric Power Assist System
Date: 31/03/2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden los…
NHTSA 14V153000
Steering › Electric Power Assist System
Date: 31/03/2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden los…
NHTSA 14V153000
Steering › Electric Power Assist System
Date: 31/03/2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden los…
NHTSA 14V153000
Steering › Electric Power Assist System
Date: 31/03/2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden los…
NHTSA 14E021000
Electrical System › Ignition › Switch
Date: 30/04/2014
UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors m…
NHTSA 14E021000
Electrical System › Ignition › Switch
Date: 30/04/2014
UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors m…
NHTSA 14E021000
Electrical System › Ignition › Switch
Date: 30/04/2014
UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors m…
NHTSA 14E021000
Electrical System › Ignition › Switch
Date: 30/04/2014
UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors m…
NHTSA 14E021000
Electrical System › Ignition › Switch
Date: 30/04/2014
UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors m…
NHTSA 09V419000
Fuel System, Gasoline › Delivery › Fuel Pump
Date: 29/10/2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY RE…
NHTSA 09V419000
Fuel System, Gasoline › Delivery › Fuel Pump
Date: 29/10/2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY RE…
NHTSA 12V459000
Fuel System, Gasoline › Delivery › Fuel Pump
Date: 19/09/2012
General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or cur…
NHTSA 04V547000
Exterior Lighting › Turn Signal
Date: 16/11/2004
CERTAIN PASSENGER VEHICLES HAVE A CONDITION IN WHICH THE TURN SIGNAL LAMP AND DAYTIME RUNNING LAMP (DRL) ON EITHER FRONT SIDE CAN STOP WORKING BECAUSE OF LOSS OF CONTACT BETWEEN THE BULB AND SOCKET.
NHTSA 04V547000
Exterior Lighting › Turn Signal
Date: 16/11/2004
CERTAIN PASSENGER VEHICLES HAVE A CONDITION IN WHICH THE TURN SIGNAL LAMP AND DAYTIME RUNNING LAMP (DRL) ON EITHER FRONT SIDE CAN STOP WORKING BECAUSE OF LOSS OF CONTACT BETWEEN THE BULB AND SOCKET.
NHTSA 14V171000
Electrical System › Ignition
Date: 10/04/2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignit…
NHTSA 14V171000
Electrical System › Ignition
Date: 10/04/2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignit…
NHTSA 14V171000
Electrical System › Ignition
Date: 10/04/2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignit…
NHTSA 14V171000
Electrical System › Ignition
Date: 10/04/2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignit…
NHTSA 14V171000
Electrical System › Ignition
Date: 10/04/2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignit…
NHTSA 14V047000
Air Bags
Date: 10/02/2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM)…
NHTSA 14V047000
Air Bags
Date: 10/02/2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM)…
NHTSA 14V047000
Air Bags
Date: 10/02/2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM)…
NHTSA 14V047000
Air Bags
Date: 10/02/2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM)…
NHTSA 14V047000
Air Bags
Date: 10/02/2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM)…
NHTSA 04V281000
Fuel System, Other › Delivery › Fuel Pump
Date: 08/06/2004
CERTAIN VEHICLES EQUIPPED WITH SUPERCHARGED 2.0L 4-CYLINDER (LSJ) ENGINE WERE BUILT WITH A FUEL FEED PIPE THAT COULD CRACK AND LEAK FUEL NEAR THE FUEL RAIL. IF FUEL LEAKS FROM THE FUEL FEED PIPE, THERE WOULD BE A NOTICEABLE FUEL ODOR AROUND THE VEHICLE.
NHTSA 09E012000
Exterior Lighting
Date: 07/04/2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
NHTSA 09E012000
Exterior Lighting
Date: 07/04/2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
NHTSA 09E012000
Exterior Lighting
Date: 07/04/2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
NHTSA 09E012000
Exterior Lighting
Date: 07/04/2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
NHTSA 09E012000
Exterior Lighting
Date: 07/04/2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
NHTSA 04V002000
Structure › Body › Bumpers
Date: 06/01/2004
ON CERTAIN PASSENGER VEHICLES, SOME WELDS BETWEEN THE PASSENGER'S SIDE MOTOR RAIL AND THE FRONT BUMPER BRACKET DO NOT MEET ENGINEERING SPECIFICATIONS.
NHTSA 04V004000
Visibility › Power Window Devices And Controls
Date: 05/01/2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS AND/OR SUNROOF MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION…
NHTSA 04V003000
Fuel System, Gasoline
Date: 05/01/2004
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L 4-CYLINDER (L61) ENGINES WERE BUILT WITH A FUEL FILTER THAT COULD CORRODE PREMATURELY ON THE EXTERIOR SURFACE.
NHTSA 04V004000
Visibility › Power Window Devices And Controls
Date: 05/01/2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 118, "POWER-OPERATED WINDOW, PARTITION, AND ROOF PANEL SYSTEMS." THE POWER WINDOWS AND/OR SUNROOF MAY BE OPERABLE AFTER THE IGNITION HAS BEEN TURNED TO THE "OFF" POSITION…
NHTSA 04V003000
Fuel System, Gasoline
Date: 05/01/2004
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L 4-CYLINDER (L61) ENGINES WERE BUILT WITH A FUEL FILTER THAT COULD CORRODE PREMATURELY ON THE EXTERIOR SURFACE.
🔴 KONTROLLLEUCHTEN — UNIVERSELLER LEITFADEN

53 Kontrollleuchten nach Dringlichkeit sortiert. Erscheint sie in Ihrem Fahrzeug? Prüfen Sie die Dringlichkeitsstufe.

Alle Kontrollleuchten anzeigen
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
!BRAKE
Brake System WarningBrakes
K
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
+−
Battery / Charging SystemElectrical
Low Fuel WarningFuel
!BRAKE
ABS WarningBrakes
!BRAKE
Brake Pad Wear IndicatorBrakes
!BRAKE
Electronic Parking Brake (EPB)Brakes
!
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
S
Suspension Fault / Air SuspensionSuspension
N
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
!
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
?
4WD / AWD SystemDrivetrain
L
Bulb Failure WarningLighting
L
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
AC
A/C System FaultHvac
Clutch Wear WarningTransmission
A
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
L
Rear Fog Light IndicatorLighting
A
Lane Departure / LDWS WarningADAS
A
Forward Collision Warning (FCW/AEB)ADAS
A
Blind Spot Monitor FaultADAS
A
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
!
Door Open WarningBody
!
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
📢 GEMELDETE BESCHWERDEN & PROBLEME (NHTSA)

300 Beschwerden von Haltern bei der US-amerikanischen National Highway Traffic Safety Administration (NHTSA) für Saturn Ion über die Modelljahre 2003–2007. Es sind echte, verifizierte Meldungen von Fahrzeughaltern.

17 crash reports 2 fires 13 injuries
Beschwerden nach Modelljahr (die häufigsten zuerst)
Modelljahr 200360
Modelljahr 200460
Modelljahr 200560
Modelljahr 200660
Modelljahr 200760
Am häufigsten gemeldete Bauteile (alle Jahre)
Steering108
Electrical System86
Fuel/Propulsion System69
Unknown Or Other30
Engine19
Air Bags18
Beispiele für Meldungen
Power steering intermittently fails at random and steering wheel suddenly becomes immovable nearly causing serious accidents and endangerment to myself, my family, and others drivers on the roads. (MY 2005)
TL* THE CONTACT OWNS A 2004 SATURN ION. AFTER STARTING THE ENGINE, THE POWER STEERING SENSOR REMAINED ILLUMINATED AND THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE LOCAL DEALER (PELLAGR… (MY 2004)
TL* THE CONTACT OWNS A 2005 SATURN ION. THE CONTACT STATED THAT WHILE IN PARK, THE CONTACT NOTICED FUEL LEAKING FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL LINES WERE LEAKING… (MY 2005)
Headlights are to deem even on high beems.cant see anything coming or the on coming traffic can't see me coming. (MY 2005)

Quelle: NHTSA-Beschwerdedatenbank (U.S. data.gov). Die Daten decken die Produktionsjahre 2003–2007 ab.

Häufige Fragen

Which OBD2 fault codes are commonly documented for the Saturn Ion (2003–2007)?

Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.

How often should the Saturn Ion (2003–2007) be serviced?

Routine maintenance for the Saturn Ion (2003–2007) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.

Found what you were looking for? Explore other Saturn models in our database, compare tyre offers in your size, or search a specific fault code in the TroubleAtlas OBD2 database.

Weitere Saturn-ModelleReifen vergleichenOBD2-Code suchen
Scroll to Top