SATURN SL (1991–2002)
SATURN SL (1991–2002) Manual — Codes, Tyres & Parts
Built 1991–2002 · all production years covered on this single page
1.9L I4 • Benzin
2002
🚗 Saturn SL 2002
Alle Daten auf dieser Seite zu Saturn Sl (1991–2002) sind aus über 6,6 Millionen realen Werkstattvorgängen, NHTSA-Registern und technischen OEM-Quellen zusammengeführt und abgeglichen — und werden laufend aktualisiert. Keine erfundenen Schätzungen.
Angetrieben von einem 1.9L I4-Motor. Nutzen Sie die Abschnitte unten für verifizierte Betriebsstoffe, Batterie, OEM-Reifen, den Wartungsplan, die empfohlenen Ersatzteile und die am häufigsten gemeldeten OBD2-Fehlercodes für dieses Fahrzeug.
Häufige Probleme
Häufige Reparaturen
Betriebsstoffe und Schmierstoffe
Batterie
Fehlercodes (OBD2)
Kontrollleuchten
Empfohlene Ersatzteile
Zubehör und Werkzeuge
Reifen
Rückrufe und Bulletins
Beschwerden
Werkstätten in der Nähe
HÄUFIGE PROBLEME
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Verwandte Codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Verwandte Codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Verwandte Codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Verwandte Codes: P0562
P0011LOW
Check with an OBD2 scanner.
Verwandte Codes: P0011
DURCHSCHNITTLICHE RICHTKOSTEN
Die Preise können je nach Region und Werkstatt variieren.
Komplette Wartung
€ 120 – € 200
Komplette Bremsen
€ 180 – € 300
Zündkerzenwechsel
€ 80 – € 140
Elektronische Diagnose
€ 40 – € 70
WERKSTATT-STUNDENSÄTZE NACH LAND
Durchschnittliche Stundensätze unabhängiger Werkstätten, zur Schätzung der Reparaturkosten in Ihrem Land.
🇩🇪Deutschland€95/h
🇪🇸Spanien€55/h
🇫🇷Frankreich€75/h
🇮🇹Italien€45/h
🇬🇧Vereinigtes Königreich£80/h
🇺🇸USA$120/h
Referenzsatz
€95/h
Quelle: Eurostat 2024
💧 BETRIEBSSTOFFE UND SCHMIERSTOFFE
📋 RÜCKRUFE UND BULLETINS (29)
NHTSA 97V138000
Steering › Gear Box (Other Than Rack And Pinion)
Date: 29/08/1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL STEERING. THE PINION BEARING CAGE IN THE STEERING GEAR CAN SEPARATE UNDER HIGH STEERING SYSTEM LOAD CONDITIONS, SUCH AS PARKING LOT OR SIMILAR LOW SPEED MANEUVERS.
NHTSA 97V138000
Steering › Gear Box (Other Than Rack And Pinion)
Date: 29/08/1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL STEERING. THE PINION BEARING CAGE IN THE STEERING GEAR CAN SEPARATE UNDER HIGH STEERING SYSTEM LOAD CONDITIONS, SUCH AS PARKING LOT OR SIMILAR LOW SPEED MANEUVERS.
NHTSA 99V297000
Structure › Body
Date: 27/10/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A CONSOLE ARMREST FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACTS." THE ARMRESTS WERE PRODUCED WITH A LATCH THAT WILL NOT WITHSTAND THE VERTICAL FORCE REQUIREMENTS OF THE STANDARD…
NHTSA 93V094000
Electrical System › 12V/24V/48V Battery › Cables
Date: 25/05/1993
THE POSITIVE BATTERY CABLE TERMINAL AT THE STARTER SOLENOID MAY BE FORMED INCORRECTLY. INCORRECTLY FORMED TERMINALS CAN CONTACT THE STARTER SOLENOID HOUSING AND CAUSE AN ELECTRIC SHORT CIRCUIT.
NHTSA 99V231000
Service Brakes, Hydraulic › Foundation Components
Date: 24/08/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 135, "PASSENGER CAR BRAKE SYSTEMS." THESE VEHICLES WERE PRODUCED WITH BRAKE PIPE ATTACHMENT NUTS THAT MAY NOT BE TIGHTENED TO SPECIFICATIONS.
NHTSA 99V232000
Structure › Body › Bumpers
Date: 23/08/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 581, "BUMPER STANDARD." THESE VEHICLES WERE PRODUCED WITH REAR BUMPER FASTENERS THAT MAY BE LOOSE OR MISSING.
NHTSA 99V230000
Unknown Or Other
Date: 23/08/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES WERE MANUFACTURED WITH WELDS IN THE INSTRUMENT PANEL CARRIER ASSEMBLY THAT DO NOT MEET SATURN QUALITY STANDARDS.
NHTSA 99V280000
Seat Belts › Front › Anchorage
Date: 20/10/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." SOME OF THE VEHICLES WERE PRODUCED WITH SEAT BELT SHOULDER GUIDE ANCHOR BOLTS THAT WERE NOT ADEQUATELY TIGHTENED AT THE CENTER PILLAR AND …
NHTSA 99V280000
Seat Belts › Front › Anchorage
Date: 20/10/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." SOME OF THE VEHICLES WERE PRODUCED WITH SEAT BELT SHOULDER GUIDE ANCHOR BOLTS THAT WERE NOT ADEQUATELY TIGHTENED AT THE CENTER PILLAR AND …
NHTSA 94V170000
Steering › Gear Box (Other Than Rack And Pinion)
Date: 14/09/1994
THE STEERING GEAR PINION SHAFT WAS IMPROPERLY HEAT TREATED CAUSING THE SHAFT TO FRACTURE DURING VEHICLE OPERATION.
NHTSA 00V310000
Power Train › Automatic Transmission › Park/Neutral Start Interlock Switch
Date: 12/10/2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, EQUIPPED WITH AUTOMATIC TRANSAXLES, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." THESE VEHICLES WERE BUILT WITH AN IMPROPERLY ADJUSTED AUTOMATIC TRANSAXLE PARK LOCK CABLE ASSEMBLY. IF IMPROPERLY ADJ…
NHTSA 00V309000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 12/10/2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THESE VEHICLES WERE BUILT WITH AN INADEQUATE VENT VALVE WELD ON THE TOP PORTION OF THE FUEL TANK.
NHTSA 00V310000
Power Train › Automatic Transmission › Park/Neutral Start Interlock Switch
Date: 12/10/2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, EQUIPPED WITH AUTOMATIC TRANSAXLES, FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION." THESE VEHICLES WERE BUILT WITH AN IMPROPERLY ADJUSTED AUTOMATIC TRANSAXLE PARK LOCK CABLE ASSEMBLY. IF IMPROPERLY ADJ…
NHTSA 00V309000
Fuel System, Gasoline › Storage › Tank Assembly
Date: 12/10/2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THESE VEHICLES WERE BUILT WITH AN INADEQUATE VENT VALVE WELD ON THE TOP PORTION OF THE FUEL TANK.
NHTSA 97V155000
Seats
Date: 12/09/1997
VEHICLE DESCRIPTION: PASSSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH SUSPECT COLD WELDS ON THE RIGHT SIDE IN THE TUNNEL AREA OF THE FLOOR PAN. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ANCHORAGE."
NHTSA 99V045000
Seats
Date: 12/03/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME FRONT SEAT BACK RECLINER GEAR TEETH MAY WEAR EXCESSIVELY THROUGH REPEATED USE, AND COULD CAUSE THE SEAT BACK TO SLIP PARTIALLY REARWARD WHEN FORCE IS APPLIED.
NHTSA 99V045000
Seats
Date: 12/03/1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME FRONT SEAT BACK RECLINER GEAR TEETH MAY WEAR EXCESSIVELY THROUGH REPEATED USE, AND COULD CAUSE THE SEAT BACK TO SLIP PARTIALLY REARWARD WHEN FORCE IS APPLIED.
NHTSA 93V132000
Electrical System › Alternator/Generator/Regulator
Date: 10/08/1993
THE GENERATOR ELECTRICAL WIRING IS NOT PROTECTED AGAINST EXCESSIVE CURRENT FLOW WHICH MAY BE CAUSED BY AN ELECTRICAL SHORT CIRCUIT IN THE GENERATOR.
NHTSA 93V132000
Electrical System › Alternator/Generator/Regulator
Date: 10/08/1993
THE GENERATOR ELECTRICAL WIRING IS NOT PROTECTED AGAINST EXCESSIVE CURRENT FLOW WHICH MAY BE CAUSED BY AN ELECTRICAL SHORT CIRCUIT IN THE GENERATOR.
NHTSA 93V132000
Electrical System › Alternator/Generator/Regulator
Date: 10/08/1993
THE GENERATOR ELECTRICAL WIRING IS NOT PROTECTED AGAINST EXCESSIVE CURRENT FLOW WHICH MAY BE CAUSED BY AN ELECTRICAL SHORT CIRCUIT IN THE GENERATOR.
NHTSA 94V217000
Power Train › Clutch Assembly › Pedal/Hand Lever(Motorcycle)
Date: 08/11/1994
THE AUTOMATIC TRANSAXLE PARK LOCK CABLE ASSEMBLY WAS IMPROPERLY ADJUSTED MAKING IT POSSIBLE TO SHIFT FROM THE "PARK" POSITION WITH THE IGNITION KEY REMOVED, OR REMOVE THE IGNITION KEY WITH THE SHIFT LEVER IN A POSITION OTHER THAN "PARK." THIS DOES NOT MEET THE REQUIREMENTS OF FMV…
NHTSA 92V098000
Power Train
Date: 08/07/1992
THE TRANSAXLE VALVE ASSEMBLIES WERE IMPROPERLY MACHINED. VEHICLES MAY NOT PROPERLY ENGAGE IN NEUTRAL OR PARK, EVEN THOUGH THE GEAR SELECTOR INDICATES THE VEHICLE IS IN NEUTRAL OR PARK.
NHTSA 09E012000
Exterior Lighting
Date: 07/04/2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
NHTSA 09E012000
Exterior Lighting
Date: 07/04/2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
NHTSA 09E012000
Exterior Lighting
Date: 07/04/2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
NHTSA 09E012000
Exterior Lighting
Date: 07/04/2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
NHTSA 09E012000
Exterior Lighting
Date: 07/04/2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
NHTSA 09E012000
Exterior Lighting
Date: 07/04/2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
NHTSA 09E012000
Exterior Lighting
Date: 07/04/2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS…
HÄUFIGE ZU PRÜFENDE OBD2-CODES
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
Alle für dieses Fahrzeug dokumentierten Fehlercodes
Die am besten dokumentierten Diagnosecodes für dieses Modell, nach System und Schweregrad. Tippen Sie auf einen Code für die vollständige Anleitung.
P0455
powertrain
NIEDRIG⏱ 0.62h im SchnittP0442
powertrain
NIEDRIG⏱ 0.62h im SchnittP0440
powertrain
NIEDRIG⏱ 0.78h im SchnittP0420
powertrain
MEDIUM⏱ 1.24h im SchnittP0300
powertrain
HOCH⏱ 1.22h im SchnittP0172
powertrain
MEDIUM⏱ 1.13h im SchnittP0171
powertrain
MEDIUM⏱ 0.95h im SchnittP0730
transmission
MEDIUM⏱ 1.25h im SchnittP0700
transmission
HOCH⏱ 1.25h im SchnittP0401
powertrain
MEDIUM⏱ 1.25h im SchnittP0011
powertrain
MEDIUM⏱ 5.4h im SchnittU0100
network
HOCHP0562
electrical
MEDIUM⏱ 0.58h im SchnittP0128
powertrain
MEDIUM⏱ 0.88h im Schnitt
KONTROLLLEUCHTEN — UNIVERSELLER LEITFADEN
53 Kontrollleuchten nach Dringlichkeit sortiert. Erscheint sie in Ihrem Fahrzeug? Prüfen Sie die Dringlichkeitsstufe.
Alle Kontrollleuchten anzeigen
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
GEMELDETE BESCHWERDEN & PROBLEME (NHTSA)
682 Beschwerden von Haltern bei der US-amerikanischen National Highway Traffic Safety Administration (NHTSA) für Saturn Sl über die Modelljahre 1991–2002. Es sind echte, verifizierte Meldungen von Fahrzeughaltern.
83 crash reports 19 fires 85 injuries 7 deaths
Beschwerden nach Modelljahr (die häufigsten zuerst)
Modelljahr 199460
Modelljahr 199560
Modelljahr 199660
Modelljahr 199760
Modelljahr 199860
Modelljahr 199960
Modelljahr 200060
Modelljahr 200160
Am häufigsten gemeldete Bauteile (alle Jahre)
Electrical System141
Engine And Engine Cooling136
Power Train99
Seat Belts58
Air Bags54
Seats53
Beispiele für Meldungen
TL* - THE CONTACT WOULD LIKE TO MAKE A COMPLAINT CONCERNING THE BRAKES ON 1996 SATURN SL2. THE CONTACT STATED THAT SHE WAS DRIVING 35 MPH WHEN SHE WAS CUT OFF BY ANOTHER CAR. SHE THEN APPLIED THE BRAKE PEDAL WHICH GAVE NO RESISTANCE.… (MY 1996)
WHEN CHECKING THE COLOR OF MY OIL, THE DIP STICK WAS FOUND 3 TIMES BONE DRY. NO OIL LIGHT INDICATOR WOULD COME ON AND FINALLY ONE TIME IT WAS TOO LATE. ON CHRISTMAS EVE MY ENGINE BLEW DUE TO HEAT AND LACK OF OIL. I WOULD LOSE 5 QUARTS… (MY 2000)
CONSUMER COMPLAINED ABOUT A STEERING COLUMN PROBLEM. CONSUMER COULD TURN THE STEERING WHEEL COMPLETELY, BUT THE FRONT WHEELS DO NOT TURN. *AK (MY 1995)
LOUD ENGINE KNOCK. ENGINE CONSUMES OIL BUT NO LEAK. TOOK TO SATURN DEALER IN FAYETTEVILLE, AR AND TOLD IT NEEDS A NEW ENGINE. ENGINE HAS LESS THAN 85,000 MILES ON IT. TOLD THERE WAS A BULLETIN ABOUT THIS SOMETIME IN THE PAST. ALL RE… (MY 1995)
Quelle: NHTSA-Beschwerdedatenbank (U.S. data.gov). Die Daten decken die Produktionsjahre 1991–2002 ab.
Häufige Fragen
Which OBD2 fault codes are commonly documented for the Saturn Sl (1991–2002)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Saturn Sl (1991–2002) be serviced?
Routine maintenance for the Saturn Sl (1991–2002) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Have a specific fault code on your Saturn Sl (1991–2002)? Search the code in the OBD2 section of this page or use the full TroubleAtlas DTC database. Need tyres? Compare prices and compatible sizes in the TroubleAtlas comparator.