SMART FORTWO (1998–2019) — Technical Guide, Fault Codes & Maintenance
Built 1998–2019 · all production years covered on this single page
1.0 (71 PS) Automatik • Benzin
2019
© Wikimedia Commons CC BY-SA
Alle Daten auf dieser Seite zu Smart Fortwo (1998–2019) sind aus über 6,6 Millionen realen Werkstattvorgängen, NHTSA-Registern und technischen OEM-Quellen zusammengeführt und abgeglichen — und werden laufend aktualisiert. Keine erfundenen Schätzungen.
Angetrieben von einem 1.0 (71 Hp) Automatic-Motor. Nutzen Sie die Abschnitte unten für verifizierte Betriebsstoffe, Batterie, OEM-Reifen, den Wartungsplan, die empfohlenen Ersatzteile und die am häufigsten gemeldeten OBD2-Fehlercodes für dieses Fahrzeug.
Häufige Probleme
Häufige Reparaturen
Betriebsstoffe und Schmierstoffe
Batterie
Fehlercodes (OBD2)
Kontrollleuchten
Empfohlene Ersatzteile
Zubehör und Werkzeuge
Reifen
Rückrufe und Bulletins
Beschwerden
Werkstätten in der Nähe
HÄUFIGE PROBLEME
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Verwandte Codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Verwandte Codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Verwandte Codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Verwandte Codes: P0562
P0011LOW
Check with an OBD2 scanner.
Verwandte Codes: P0011
DURCHSCHNITTLICHE RICHTKOSTEN
Die Preise können je nach Region und Werkstatt variieren.
Komplette Wartung
€ 120 – € 200
Komplette Bremsen
€ 180 – € 300
Zündkerzenwechsel
€ 80 – € 140
Elektronische Diagnose
€ 40 – € 70
WERKSTATT-STUNDENSÄTZE NACH LAND
Durchschnittliche Stundensätze unabhängiger Werkstätten, zur Schätzung der Reparaturkosten in Ihrem Land.
🇩🇪Deutschland€95/h
🇪🇸Spanien€55/h
🇫🇷Frankreich€75/h
🇮🇹Italien€45/h
🇬🇧Vereinigtes Königreich£80/h
🇺🇸USA$120/h
Referenzsatz
€95/h
Quelle: Eurostat 2024
💧 BETRIEBSSTOFFE UND SCHMIERSTOFFE
📋 RÜCKRUFE UND BULLETINS (6)
NHTSA 18V273000
Engine And Engine Cooling › Exhaust System
Date: 27/04/2018
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2008-2009 smart fortwo cabrio and fortwo coupe vehicles. The rear insulation mat in the engine compartment may deform, deteriorate, and loosen over time, allowing the mat to contact hot exhaust system components.
NHTSA 18V273000
Engine And Engine Cooling › Exhaust System
Date: 27/04/2018
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2008-2009 smart fortwo cabrio and fortwo coupe vehicles. The rear insulation mat in the engine compartment may deform, deteriorate, and loosen over time, allowing the mat to contact hot exhaust system components.
NHTSA 20V107000
Electrical System › 12V/24V/48V Battery
Date: 24/02/2020
Mercedes-Benz USA, LLC. (MBUSA) is recalling one 2019 Smart Fortwo Electric Drive vehicle. A welded joint within the high-voltage battery main cell conductors may detach and interrupt electrical contact, resulting in sudden battery failure. The detached weld may also cause an e…
NHTSA 17V448000
Parking Brake
Date: 16/07/2017
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2016 smart fortwo vehicles. In these vehicles, the lock nut that secures the parking brake cable to the parking brake lever may loosen over time, resulting in increased parking brake lever travel before the parking brake engage…
NHTSA 17V447000
Steering
Date: 14/07/2017
Mercedes-Benz USA LLC. (MBUSA) is recalling certain 2017 smart fortwo and smart fortwo Cabriolet vehicles. Casting imperfections may result in the failure of the left front axle steering knuckle.
NHTSA 08V390000
Structure › Frame And Members
Date: 07/08/2008
SMART USA IS RECALLING 43 MY 2008 FORTWO 451 VEHICLES. A SINGLE BATCH OF PAINT SENT TO THE COMPANY DID NOT MEET SPECIFICATIONS. A RE-WORK WAS DONE IN THE PLANT USING DIFFERENT FORMULATIONS OF PAINTING MATERIALS. AFTER THE RE-WORK WAS COMPLETED, IT WAS DETERMINED THAT THE C…
HÄUFIGE ZU PRÜFENDE OBD2-CODES
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
Alle für dieses Fahrzeug dokumentierten Fehlercodes
Die am besten dokumentierten Diagnosecodes für dieses Modell, nach System und Schweregrad. Tippen Sie auf einen Code für die vollständige Anleitung.
P0455
powertrain
NIEDRIG⏱ 0.62h im SchnittP0442
powertrain
NIEDRIG⏱ 0.62h im SchnittP0440
powertrain
NIEDRIG⏱ 0.78h im SchnittP0420
powertrain
MEDIUM⏱ 1.24h im SchnittP0300
powertrain
HOCH⏱ 1.22h im SchnittP0172
powertrain
MEDIUM⏱ 1.13h im SchnittP0171
powertrain
MEDIUM⏱ 0.95h im SchnittP0730
transmission
MEDIUM⏱ 1.25h im SchnittP0700
transmission
HOCH⏱ 1.25h im SchnittP0401
powertrain
MEDIUM⏱ 1.25h im SchnittP0011
powertrain
MEDIUM⏱ 5.4h im SchnittU0100
network
HOCHP0562
electrical
MEDIUM⏱ 0.58h im SchnittP0128
powertrain
MEDIUM⏱ 0.88h im Schnitt
KONTROLLLEUCHTEN — UNIVERSELLER LEITFADEN
53 Kontrollleuchten nach Dringlichkeit sortiert. Erscheint sie in Ihrem Fahrzeug? Prüfen Sie die Dringlichkeitsstufe.
Alle Kontrollleuchten anzeigen
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
GEMELDETE BESCHWERDEN & PROBLEME (NHTSA)
162 Beschwerden von Haltern bei der US-amerikanischen National Highway Traffic Safety Administration (NHTSA) für Smart Fortwo über die Modelljahre 1998–2019. Es sind echte, verifizierte Meldungen von Fahrzeughaltern.
6 crash reports 30 fires 7 injuries 1 death
Beschwerden nach Modelljahr (die häufigsten zuerst)
Modelljahr 200860
Modelljahr 200960
Modelljahr 201116
Modelljahr 20179
Modelljahr 20128
Modelljahr 20106
Modelljahr 20052
Modelljahr 20191
Am häufigsten gemeldete Bauteile (alle Jahre)
Engine48
Electrical System25
Unknown Or Other24
Power Train24
Engine And Engine Cooling17
Fuel/Propulsion System14
Beispiele für Meldungen
TL* THE CONTACT OWNS A 2008 SMART FORTWO. AFTER THE VEHICLE WAS STARTED AND SHIFTED INTO REVERSE, IT FAILED TO RESPOND. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF ORLANDO (810 ORLANDO AVE, MAITLAND, FL 32751, (407) 680-0784) TO BE DIAGNOS… (MY 2008)
WITHIN THE SPACE OF THREE MONTHS, IN THE MIDDLE OF DRIVING MY SMARTCAR, MY DASH DISPLAY HAS GONE FROM SHOWING D (FOR DRIVE) TO N AND THEN FLASHING THREE VERTICAL BARS. I HAVE LOST ALL CONTROL OF DRIVING THE CAR AND LUCKILY THERE WAS SPAC… (MY 2009)
I AM ORIGINAL OWNER SINCE FEB 09 (MANF 12/08) AND ITS NOW 7 YRS OLD AND REQS NEW BATTERY. LIFTING UP FLOOR MAT TO REMOVE OLD BATTERY I NOTICED STICKY RED OILY SUBSTANCE (UNKOWN SOURCE BUT NOW SUSPECT BATTERY VAPOR CONDENSATION) AROUND TO… (MY 2009)
2008 Smart Fortwo Pure, currently with 85,036 miles, factory equipped with optional POWER STEERING - ELECTRIC, power steering had worked fine until Fall 2020 when cold temperatures caused steering lock-up, until car interior warmed enoug… (MY 2008)
Quelle: NHTSA-Beschwerdedatenbank (U.S. data.gov). Die Daten decken die Produktionsjahre 1998–2019 ab.
Häufige Fragen
Which OBD2 fault codes are commonly documented for the Smart Fortwo (1998–2019)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Smart Fortwo (1998–2019) be serviced?
Routine maintenance for the Smart Fortwo (1998–2019) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
Considering buying a Smart Fortwo (1998–2019)? Use this guide to check expected maintenance costs, the most reported fault codes and parts availability on the market. Real data, zero commercial estimates.