TroubleAtlas Score
VOLKSWAGEN ROUTAN (2009–2014): Technical Data, DTC & Service Schedule
Built 2009–2014 · all production years covered on this single page
3.6L V6 • Benzin
© Wikimedia Commons CC BY-SA
TroubleAtlas Score
An independent value score for the Volkswagen Routan (2009–2014) — reliability, safety, cost, parts, upkeep and documentation. Owing nothing to the manufacturer.
Scorecard · each voice 0–10
Reliabilityn/a
Safety & recallsn/a
Repair cost3.5
Parts & repairability8.0
Maintenance & durabilityn/a
Documentation & support8.9
Independent · Verified · Never for sale
Alle Daten auf dieser Seite zu Volkswagen Routan (2009–2014) sind aus über 6,6 Millionen realen Werkstattvorgängen, NHTSA-Registern und technischen OEM-Quellen zusammengeführt und abgeglichen — und werden laufend aktualisiert. Keine erfundenen Schätzungen.
Der Volkswagen Routan (2009–2014) verwendet Castrol Edge 5W-30 Motoröl. Seine Batterie hat die Baugröße H6 (BCI), mit 600A Ampere Kaltstartstrom. Angetrieben von einem 3.6L V6-Motor. Seine OEM-Reifengröße ist 215/55 R16. Nutzen Sie die Abschnitte unten für verifizierte Betriebsstoffe, Batterie, OEM-Reifen, den Wartungsplan, die empfohlenen Ersatzteile und die am häufigsten gemeldeten OBD2-Fehlercodes für dieses Fahrzeug.
Häufige Probleme
Häufige Reparaturen
Betriebsstoffe und Schmierstoffe
Batterie
Fehlercodes (OBD2)
Kontrollleuchten
Empfohlene Ersatzteile
Zubehör und Werkzeuge
Reifen
Rückrufe und Bulletins
Beschwerden
Werkstätten in der Nähe
HÄUFIGE PROBLEME
Transmission fault signal (TCM)MODERATE
The transmission module detected a fault — check separate transmission codes.
Verwandte Codes: P0700
Misfire / Loss of cylinderMODERATE
Rough running, idle vibration, power loss.
Verwandte Codes: P0300
Thermostat: coolant temperature lowLOW
Thermostat stuck open — engine does not reach operating temperature.
Verwandte Codes: P0128
Battery/system voltage lowLOW
System voltage below 10V — check alternator, battery or wiring.
Verwandte Codes: P0562
P0011LOW
Check with an OBD2 scanner.
Verwandte Codes: P0011
HÄUFIGE REPARATUREN
Vordere Bremsbeläge
Schwierigkeit: Mittel
1.1h
€77 – €99
Hintere Bremsbeläge
Schwierigkeit: Mittel
1.2h
€84 – €108
Motorölwechsel
Schwierigkeit: Einfach
0.4h
€28 – €36
ABS Module
Schwierigkeit: Schwer
2.7h
€189 – €243
DURCHSCHNITTLICHE RICHTKOSTEN
Die Preise können je nach Region und Werkstatt variieren.
Komplette Wartung
€ 120 – € 200
Komplette Bremsen
€ 180 – € 300
Zündkerzenwechsel
€ 80 – € 140
Elektronische Diagnose
€ 40 – € 70
OFFIZIELLE ARBEITSZEITEN (OLP)
Standard-Arbeitsstunden aus einer Datenbank mit über 6,6 Millionen realen Werkstattvorgängen, mit einer Richtschätzung der Arbeitskosten für Ihr Land.
Bremsen8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| ABS Module | 2.7h | € 121–€ 202 |
| ABS Pump | 3.4h | € 153–€ 255 |
| ABS Tone Ring | 2.0h | € 90–€ 150 |
| ABS Wheel Speed Sensor - Front | 1.1h | € 49–€ 82 |
| ABS Wheel Speed Sensor - Rear | 1.1h | € 49–€ 82 |
| Brake Bleed - All Four | 1.4h | € 62–€ 105 |
| Brake Booster | 3.4h | € 153–€ 255 |
| Brake Booster Check Valve | 0.4h | € 18–€ 30 |
Kühlung8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Coolant Bypass Pipe | 2.0h | € 90–€ 150 |
| Coolant Flush | 1.4h | € 62–€ 105 |
| Coolant Reservoir | 0.7h | € 31–€ 52 |
| Coolant Temperature Sensor | 0.7h | € 31–€ 52 |
| Cooling Fan Assembly | 1.4h | € 62–€ 105 |
| Cooling Fan Motor | 2.0h | € 90–€ 150 |
| Cooling Fan Relay | 0.4h | € 18–€ 30 |
| Engine Oil Cooler | 2.7h | € 121–€ 202 |
Elektrik8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Airbag - Driver | 1.4h | € 62–€ 105 |
| Airbag - Passenger | 2.0h | € 90–€ 150 |
| Airbag - Side | 2.7h | € 121–€ 202 |
| Airbag Module/Computer | 1.4h | € 62–€ 105 |
| Alternator | 2.0h | € 90–€ 150 |
| Alternator Belt | 0.7h | € 31–€ 52 |
| Amplifier | 2.0h | € 90–€ 150 |
| Antenna | 0.7h | € 31–€ 52 |
Motor8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Camshaft Position Sensor | 1.4h | € 62–€ 105 |
| Camshaft R&R | 10.8h | € 486–€ 810 |
| Connecting Rod Bearings | 20.2h | € 909–€ 1515 |
| Crankshaft Position Sensor | 1.4h | € 62–€ 105 |
| Crankshaft R&R | 27.0h | € 1215–€ 2025 |
| Cylinder Head R&R | 8.1h | € 364–€ 607 |
| Cylinder Head Resurface | 10.8h | € 486–€ 810 |
| Engine Mount - Front | 2.0h | € 90–€ 150 |
Abgasanlage8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Air Injection Check Valve | 1.1h | € 49–€ 82 |
| Catalytic Converter - California | 2.0h | € 90–€ 150 |
| Catalytic Converter - Direct Fit | 2.0h | € 90–€ 150 |
| Catalytic Converter - Universal | 2.7h | € 121–€ 202 |
| Downpipe | 2.7h | € 121–€ 202 |
| EGR Cooler | 4.1h | € 184–€ 307 |
| EGR Tube | 2.0h | € 90–€ 150 |
| EGR Valve | 1.4h | € 62–€ 105 |
Kraftstoffsystem8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Charcoal Canister | 1.4h | € 62–€ 105 |
| EVAP Purge Valve | 1.1h | € 49–€ 82 |
| EVAP Vent Valve | 1.1h | € 49–€ 82 |
| Fuel Cap | 0.1h | € 4–€ 7 |
| Fuel Filler Neck | 2.0h | € 90–€ 150 |
| Fuel Filter | 0.7h | € 31–€ 52 |
| Fuel Filter - In-Tank | 2.7h | € 121–€ 202 |
| Fuel Injector - Single | 1.4h | € 62–€ 105 |
Klimatechnik8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| AC Accumulator | 2.0h | € 90–€ 150 |
| AC Clutch Coil | 2.0h | € 90–€ 150 |
| AC Compressor | 3.4h | € 153–€ 255 |
| AC Compressor Clutch | 2.7h | € 121–€ 202 |
| AC Compressor Oil Add | 0.7h | € 31–€ 52 |
| AC Condenser | 3.4h | € 153–€ 255 |
| AC Evaporator | 8.1h | € 364–€ 607 |
| AC Expansion Valve (TXV) | 5.4h | € 243–€ 405 |
Lenkung8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Center Link/Drag Link | 2.0h | € 90–€ 150 |
| Electric Power Steering Module | 2.0h | € 90–€ 150 |
| Electric Power Steering Motor | 3.4h | € 153–€ 255 |
| Idler Arm | 1.4h | € 62–€ 105 |
| Pitman Arm | 1.6h | € 72–€ 120 |
| Power Steering Fluid Flush | 0.7h | € 31–€ 52 |
| Power Steering Gear Box | 4.7h | € 211–€ 352 |
| Power Steering Hose - High Pressure | 1.4h | € 62–€ 105 |
Fahrwerk8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Air Line | 1.4h | € 62–€ 105 |
| Air Spring/Air Bag | 2.0h | € 90–€ 150 |
| Air Suspension Compressor | 2.0h | € 90–€ 150 |
| Air Suspension Height Sensor | 1.4h | € 62–€ 105 |
| Air Suspension Valve Block | 2.7h | € 121–€ 202 |
| Ball Joint - Lower | 2.4h | € 108–€ 180 |
| Ball Joint - Upper | 2.0h | € 90–€ 150 |
| Ball Joints - Upper and Lower | 4.1h | € 184–€ 307 |
Getriebe8 Vorgänge
| Vorgang | Arbeitsstunden (OLP) | Gesch. Arbeitskosten |
|---|---|---|
| Kickdown Cable | 1.1h | € 49–€ 82 |
| Neutral Safety Switch | 1.4h | € 62–€ 105 |
| Overdrive Solenoid | 2.7h | € 121–€ 202 |
| Shift Cable | 2.0h | € 90–€ 150 |
| Shift Linkage | 1.4h | € 62–€ 105 |
| Transmission Control Module | 1.4h | € 62–€ 105 |
| Transmission Cooler Lines | 1.4h | € 62–€ 105 |
| Transmission Filter | 1.4h | € 62–€ 105 |
WERKSTATT-STUNDENSÄTZE NACH LAND
Durchschnittliche Stundensätze unabhängiger Werkstätten, zur Schätzung der Reparaturkosten in Ihrem Land.
🇩🇪Deutschland€95/h
🇪🇸Spanien€55/h
🇫🇷Frankreich€75/h
🇮🇹Italien€45/h
🇬🇧Vereinigtes Königreich£80/h
🇺🇸USA$120/h
Referenzsatz
€95/h
Quelle: Eurostat 2024
💧 BETRIEBSSTOFFE UND SCHMIERSTOFFE
📋 RÜCKRUFE UND BULLETINS (8)
NHTSA 16V083000
Air Bags › Frontal › Sensor/Control Module-Inactive
Date: 11/02/2016
Volkswagen Group of America, Inc. (VW) is recalling certain model year 2009 Volkswagen Routan vehicles manufactured February 7, 2008, to August 28, 2008. In the affected vehicles, the air bag control units may corrode and fail.
NHTSA 14V055000
Suspension › Rear › Axle › Non-Powered Axle Assembly
Date: 11/02/2014
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The L…
NHTSA 10V252000
Electrical System › Wiring
Date: 10/06/2010
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 ROUTAN VEHICLES MANUFACTURED FROM JUNE 2008 THROUGH JULY 2009. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR T…
NHTSA 12V147000
Suspension › Rear
Date: 05/04/2012
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2012 ROUTAN VEHICLES, MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.
NHTSA 14V396000
Electrical System › Ignition
Date: 01/07/2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring.
Volkswagen Group of Ame…
NHTSA 09V244000
Equipment › Other › Owners/Service/Other Manual
Date: 01/07/2009
VOLKSWAGEN IS RECALLING 18,500 MY 2009 ROUTAN VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE OWNER'S MANUAL WAS PRINTED WITHOUT THE FMVSS NO. 208 REQUIRED INFORMATION EXPLAINING THAT NO OBJE…
NHTSA 15V194000
Electrical System › Ignition › Switch
Date: 01/04/2015
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles manufactured June 25, 2008, to July 8, 2009, and 2010 Routan vehicles manufactured October 1, 2009, to August 11, 2010. This defect can affect the safe operation of the airbag sys…
NHTSA 11V151000
Electrical System › Ignition › Switch
Date: 01/03/2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2010 ROUTAN VEHICLES MANUFACTURED FROM OCTOBER 2009 THROUGH JUNE 2010. SOME VEHICLES MAY EXPERIENCE INADVERTENT IGNITION KEY DISPLACEMENT FROM THE RUN TO ACCESSORY POSITION WHILE DRIVING CAUSING THE ENGINE TO SHUT OFF.
HÄUFIGE ZU PRÜFENDE OBD2-CODES
P0420
P0420
Powertrain
P0171
P0171
Powertrain
P0300
P0300
Powertrain
P0128
P0128
Powertrain
P0455
P0455
Powertrain
P0700
P0700
Transmission
P0442
P0442
Powertrain
P0172
P0172
Powertrain
P0401
P0401
Powertrain
Alle für dieses Fahrzeug dokumentierten Fehlercodes
Die am besten dokumentierten Diagnosecodes für dieses Modell, nach System und Schweregrad. Tippen Sie auf einen Code für die vollständige Anleitung.
P0455
powertrain
NIEDRIG⏱ 0.62h im SchnittP0442
powertrain
NIEDRIG⏱ 0.62h im SchnittP0440
powertrain
NIEDRIG⏱ 0.78h im SchnittP0420
powertrain
MEDIUM⏱ 1.24h im SchnittP0300
powertrain
HOCH⏱ 1.22h im SchnittP0172
powertrain
MEDIUM⏱ 1.13h im SchnittP0171
powertrain
MEDIUM⏱ 0.95h im SchnittP0730
transmission
MEDIUM⏱ 1.25h im SchnittP0700
transmission
HOCH⏱ 1.25h im SchnittP0401
powertrain
MEDIUM⏱ 1.25h im SchnittP0011
powertrain
MEDIUM⏱ 5.4h im SchnittU0100
network
HOCHP0562
electrical
MEDIUM⏱ 0.58h im SchnittP0128
powertrain
MEDIUM⏱ 0.88h im Schnitt
KONTROLLLEUCHTEN — UNIVERSELLER LEITFADEN
88 Kontrollleuchten nach Dringlichkeit sortiert. Erscheint sie in Ihrem Fahrzeug? Prüfen Sie die Dringlichkeitsstufe.
Alle Kontrollleuchten anzeigen
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
Brake System WarningBrakes
Immobilizer / Key FaultSecurity
Doors OpenChassis
Hood Open DualChassis
Trunk Open DualChassis
Ignition MalfunctionEngine
WheelEngine
Lights Ignition Steering MalfunctionChassis
Dsg Transmission Too HotTransmission
Electronic Parking Brake EngagedBrakes
Brake System MalfunctionBrakes
Brake WearBrakes
Engine CoolantEngine
Engine Oil Pressure LowEngine
12V Alternator MalfunctionElectrical
Cruise Control MalfunctionADAS
Brake PedalBrakes
Front Assist Collision WarningADAS
Differential Lock MalfunctionEngine
AdblueFuel
Error In Hybrid SystemElectrical
Central Warning LightLighting
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
Battery / Charging SystemElectrical
Low Fuel WarningFuel
ABS WarningBrakes
Brake Pad Wear IndicatorBrakes
Electronic Parking Brake (EPB)Brakes
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
Suspension Fault / Air SuspensionSuspension
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
AdBlue Level Low (VW) (Volkswagen)Emissions
EPC — Engine Control (VW) (Volkswagen)Engine
Glow Plug Fault (VW) (Volkswagen)Engine
DSG Fault (Volkswagen)Transmission
TpmsTyres
Open Rear LidEngine
Ignition Switch Starter ButtonEngine
Electronic ImmobilizerEngine
Fuel Tank Almost EmptyFuel
Front Fog Lights Switched OnLighting
Parking Lights Switched OnBrakes
Driving Lights Burned OutLighting
Adaptive Front Lighting System MalfunctionLighting
Headlight Range Adjustment MalfunctionLighting
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
4WD / AWD SystemDrivetrain
Bulb Failure WarningLighting
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
A/C System FaultHvac
Clutch Wear WarningTransmission
Cruise Control / ACC FaultADAS
DPF Regeneration (VW) (Volkswagen)Emissions
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
Rear Fog Light IndicatorLighting
Lane Departure / LDWS WarningADAS
Forward Collision Warning (FCW/AEB)ADAS
Blind Spot Monitor FaultADAS
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
Door Open WarningBody
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
GEMELDETE BESCHWERDEN & PROBLEME (NHTSA)
780 Beschwerden von Haltern bei der US-amerikanischen National Highway Traffic Safety Administration (NHTSA) für Volkswagen Routan über die Modelljahre 2009–2014. Es sind echte, verifizierte Meldungen von Fahrzeughaltern.
16 crash reports 8 fires 47 injuries
Beschwerden nach Modelljahr (die häufigsten zuerst)
Modelljahr 2009293
Modelljahr 2010240
Modelljahr 2011175
Modelljahr 201263
Modelljahr 20137
Modelljahr 20142
Am häufigsten gemeldete Bauteile (alle Jahre)
Electrical System430
Engine183
Service Brakes95
Steering70
Power Train66
Unknown Or Other54
Beispiele für Meldungen
WE HAVE HAD SEVERAL OCCASIONS WHERE THE VAN COMPLETELY SHUTS OFF EVEN WHILE RUNNING. REPORTED IT TO OUR LOCAL VW DEALER AND HAVE BEEN TOLD THAT IT MIGHT BE AN IGNITION PROBLEM WHICH IS PART OF A RECALL. WAS INFORMED THAT AT THIS TIME THE… (MY 2009)
MY 2012 VOLKSWAGEN ROUTAN HAS ONLY 87K MILES AND THE CAR WILL CRANK BUT WILL NOT START, AND OR WHILE DRIVING THE CAR'S IDLE BECOMES ROUGH AND DROPS TO THE POINT OF SHUTTING OFF WHILE DRIVING. MY WIFE DRIVES THIS CAR WITH MY DAUGHTER AND… (MY 2012)
MY 2009 VOLKSWAGEN ROUTAN DIES WHILE DRIVING. I'VE ON THE VEHICLE FOR TWO YEARS AND THIS HAS BEEN HAPPENING THE WHOLE TIME. THAT USUALLY HAPPENS AT LOWER SPEEDS (UNDER 35MPH). IT HAPPENS WHEN I'M GOING STRAIGHT AND WHEN I'M TURNING C… (MY 2009)
REPLACED FUEL PUMP AFTER ISSUES WITH ENGINE REFUSING TO TURN OVER. NEXT DAY AFTER REPAIR THE VEHICLE REFUSED TO START; TOWED TO GARAGE FOR DIAGNOSIS. ONE MECHANIC WAS ABLE TO START IT AND ANOTHER NOT. COMPUTER DIAGNOSIS CAN'T FIND THE IS… (MY 2011)
Quelle: NHTSA-Beschwerdedatenbank (U.S. data.gov). Die Daten decken die Produktionsjahre 2009–2014 ab.
Häufige Fragen
What tyres does the Volkswagen Routan (2009–2014) use?
The original OEM tyre size for the Volkswagen Routan (2009–2014) is 215/55 R16. Compatible alternative sizes: ["245/45R19", "225/65R17", "225/65R16"]. See the Tyres section on this page to compare offers from the main suppliers.
What is the right battery for the Volkswagen Routan (2009–2014)?
The battery specified for the Volkswagen Routan (2009–2014) is group H6 (BCI), with a cold cranking rating of 600A. See the Battery section on this page for the main cross-references between brands.
What engine oil should I use on the Volkswagen Routan (2009–2014)?
The engine oil specification for the Volkswagen Routan (2009–2014) is Castrol Edge 5W-30. Always use the viscosity grade approved by the manufacturer: a different oil can reduce engine protection and void the warranty. Check the change interval in the Maintenance section.
Which OBD2 fault codes are commonly documented for the Volkswagen Routan (2009–2014)?
Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.
How often should the Volkswagen Routan (2009–2014) be serviced?
Routine maintenance for the Volkswagen Routan (2009–2014) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.
This spec sheet is updated with data verified from OEM sources and shop databases. If you spot an inaccuracy or have additional data on the Volkswagen Routan (2009–2014), let us know — every correction improves quality for all users.