Volvo S40 (2000–2011) — Specifications, Fluids & Diagnosis | TroubleAtlas

🌐 ▾
Startseite› Fahrzeuge› Volvo› S40› 2011
Volvo S40 (2000–2011)
Die TroubleAtlas App auf dem HandyTROUBLEATLAS APP · GRATISGRATIS-APPLaden Sie unsere kostenlose AppKostenlose App ladenUnser Einkaufszentrum in der Tasche: Dutzende Anbieter, die in Ihr Land liefern, im Vergleich, Abteilung für Abteilung.Dutzende Anbieter im Vergleich, in Ihrem Land. Gratis laden Gratis laden

VOLVO S40 (2000–2011) Manual — Codes, Tyres & Parts

By TroubleAtlas Technical Team · Updated 14 July 2026 · Cross-checked against 3 independent sources
Built 2000–2011 · all production years covered on this single page

2.5L I5 Turbo • Benzin

2011
Volvo S40 (2000–2011)

© Wikimedia Commons CC BY-SA

5 Häufige Probleme Details ansehen →
14 OBD2-Codes Details ansehen →
29 Rückrufe / Bulletins Details ansehen →

Alle Daten auf dieser Seite zu Volvo S40 (2000–2011) sind aus über 6,6 Millionen realen Werkstattvorgängen, NHTSA-Registern und technischen OEM-Quellen zusammengeführt und abgeglichen — und werden laufend aktualisiert. Keine erfundenen Schätzungen.

Angetrieben von einem 2.5L I5 Turbo-Motor. Nutzen Sie die Abschnitte unten für verifizierte Betriebsstoffe, Batterie, OEM-Reifen, den Wartungsplan, die empfohlenen Ersatzteile und die am häufigsten gemeldeten OBD2-Fehlercodes für dieses Fahrzeug.

⚠️Häufige Probleme 🔧Häufige Reparaturen 💧Betriebsstoffe und Schmierstoffe 🔋Batterie 🔌Fehlercodes (OBD2) 🔴Kontrollleuchten 🛒Empfohlene Ersatzteile 🔧Zubehör und Werkzeuge 🛞Reifen 📋Rückrufe und Bulletins 📢Beschwerden 📍Werkstätten in der Nähe
⚠️ HÄUFIGE PROBLEME
Transmission fault signal (TCM)MODERATE

The transmission module detected a fault — check separate transmission codes.

Verwandte Codes: P0700

Misfire / Loss of cylinderMODERATE

Rough running, idle vibration, power loss.

Verwandte Codes: P0300

Thermostat: coolant temperature lowLOW

Thermostat stuck open — engine does not reach operating temperature.

Verwandte Codes: P0128

Battery/system voltage lowLOW

System voltage below 10V — check alternator, battery or wiring.

Verwandte Codes: P0562

P0011LOW

Check with an OBD2 scanner.

Verwandte Codes: P0011

💰 DURCHSCHNITTLICHE RICHTKOSTEN

Die Preise können je nach Region und Werkstatt variieren.

🔧
Komplette Wartung
€ 120 – € 200
🛑
Komplette Bremsen
€ 180 – € 300
⚡
Zündkerzenwechsel
€ 80 – € 140
📊
Elektronische Diagnose
€ 40 – € 70
💵 WERKSTATT-STUNDENSÄTZE NACH LAND

Durchschnittliche Stundensätze unabhängiger Werkstätten, zur Schätzung der Reparaturkosten in Ihrem Land.

🇩🇪Deutschland€95/h
🇪🇸Spanien€55/h
🇫🇷Frankreich€75/h
🇮🇹Italien€45/h
🇬🇧Vereinigtes Königreich£80/h
🇺🇸USA$120/h
Referenzsatz
€95/h
Quelle: Eurostat 2024
💧 BETRIEBSSTOFFE UND SCHMIERSTOFFE
📋 RÜCKRUFE UND BULLETINS (29)
NHTSA 08V033000
Fuel System, Gasoline › Delivery › Fuel Pump
Date: 28/01/2008
ON CERTAIN VEHICLES SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCO…
NHTSA 08V033000
Fuel System, Gasoline › Delivery › Fuel Pump
Date: 28/01/2008
ON CERTAIN VEHICLES SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCO…
NHTSA 08V033000
Fuel System, Gasoline › Delivery › Fuel Pump
Date: 28/01/2008
ON CERTAIN VEHICLES SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCO…
NHTSA 03V424000
Fuel System, Gasoline
Date: 24/10/2003
ON CERTAIN SEDANS AND STATION WAGONS, THERE MAY BE A FUEL LEAK FROM THE FUEL RAIL DUE TO INADEQUATE WELDING.
NHTSA 03V424000
Fuel System, Gasoline
Date: 24/10/2003
ON CERTAIN SEDANS AND STATION WAGONS, THERE MAY BE A FUEL LEAK FROM THE FUEL RAIL DUE TO INADEQUATE WELDING.
NHTSA 06V137000
Fuel System, Gasoline
Date: 24/04/2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH T5 TURBO ENGINES, THE POLYAMIDE TUBE IN THE FUEL LINE IS SENSITIVE TO THE EXTREME TEMPERATURES THAT MAY OCCUR IN THE AREA WHERE THE TURBO/EXHAUST MANIFOLD IS LOCATED.
NHTSA 06V137000
Fuel System, Gasoline
Date: 24/04/2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH T5 TURBO ENGINES, THE POLYAMIDE TUBE IN THE FUEL LINE IS SENSITIVE TO THE EXTREME TEMPERATURES THAT MAY OCCUR IN THE AREA WHERE THE TURBO/EXHAUST MANIFOLD IS LOCATED.
NHTSA 06V137000
Fuel System, Gasoline
Date: 24/04/2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH T5 TURBO ENGINES, THE POLYAMIDE TUBE IN THE FUEL LINE IS SENSITIVE TO THE EXTREME TEMPERATURES THAT MAY OCCUR IN THE AREA WHERE THE TURBO/EXHAUST MANIFOLD IS LOCATED.
NHTSA 08V329000
Steering › Hydraulic Power Assist › Hose, Piping, And Connections
Date: 23/07/2008
VOLVO IS RECALLING MY 2008-2009 VEHICLES. A SECTION OF THE POWER STEERING RETURN LINE HOSE WAS NOT PROPERLY VULCANIZED (CURED) AND DOES NOT MEET SPECIFICATIONS. IF THE POWER STEERING RETURN HOSE FAILS, A SUDDEN RUPTURE OF THE HOSE CAN OCCUR.
NHTSA 08V329000
Steering › Hydraulic Power Assist › Hose, Piping, And Connections
Date: 23/07/2008
VOLVO IS RECALLING MY 2008-2009 VEHICLES. A SECTION OF THE POWER STEERING RETURN LINE HOSE WAS NOT PROPERLY VULCANIZED (CURED) AND DOES NOT MEET SPECIFICATIONS. IF THE POWER STEERING RETURN HOSE FAILS, A SUDDEN RUPTURE OF THE HOSE CAN OCCUR.
NHTSA 10V591000
Seats
Date: 22/11/2010
VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.
NHTSA 10V591000
Seats
Date: 22/11/2010
VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.
NHTSA 10V591000
Seats
Date: 22/11/2010
VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.
NHTSA 01V169000
Equipment › Appliance › Air Conditioner
Date: 21/05/2001
VEHICLE DESCRIPTION: SEDAN AND WAGON PASSENGER VEHICLES. A DIODE IN THE ELECTRONIC CLIMATE CONTROL SYSTEM MAY HAVE A REDUCED SERVICE LIFE.
NHTSA 11V186000
Structure › Frame And Members
Date: 18/03/2011
VOLVO IS RECALLING CERTAIN MODEL YEAR 2011 S40 PASSENGER VEHICLES. A CRACK ON THE TOP SIDE OF THE PASSENGER SIDE SUPPORT MEMBER IN THE ENGINE COMPARTMENT MAY HAVE DEVELOPED DURING THE FORMING PROCESS IN COMPONENT PRODUCTION.
NHTSA 03V474000
Service Brakes, Hydraulic › Power Assist › Vacuum
Date: 17/11/2003
ON CERTAIN PASSENGER VEHICLES, WATER CAN ENTER THE ELECTRICAL BRAKE VACUUM PUMP, CAUSING THE PUMP TO FAIL.
NHTSA 04V493000
Service Brakes, Hydraulic › Power Assist › Vacuum › Hoses, Lines/Piping, And Fittings
Date: 14/10/2004
ON CERTAIN PASSENGER VEHICLES, THE NON-RETURN VALVE MAY CRACK DUE TO A POOR WELD CAUSING A VACUUM LEAK.
NHTSA 10V566000
Equipment › Electrical › Navigational System(Global Positioning System)
Date: 08/11/2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
NHTSA 10V566000
Equipment › Electrical › Navigational System(Global Positioning System)
Date: 08/11/2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
NHTSA 10V566000
Equipment › Electrical › Navigational System(Global Positioning System)
Date: 08/11/2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
NHTSA 10V566000
Equipment › Electrical › Navigational System(Global Positioning System)
Date: 08/11/2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
NHTSA 10V566000
Equipment › Electrical › Navigational System(Global Positioning System)
Date: 08/11/2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
NHTSA 10V566000
Equipment › Electrical › Navigational System(Global Positioning System)
Date: 08/11/2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
NHTSA 10V566000
Equipment › Electrical › Navigational System(Global Positioning System)
Date: 08/11/2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
NHTSA 08V101000
Service Brakes, Hydraulic › Foundation Components › Master Cylinder
Date: 05/03/2008
VOLVO IS RECALLING 1,114 MY 2007 C30, C70, S40, AND V50 PASSENGER VEHICLES. A SOFT ANODIZED LAYER IN THE MASTER CYLINDER MAY TRIGGER EARLY WEAR ON A RUBBER SEAL THAT CAN RESULT IN INTERNAL LEAKAGE OF BRAKE FLUID. IF AFFECTED, THE DRIVER MAY EXPERIENCE REDUCED BRAKE PERFORMANCE …
NHTSA 03V284000
Equipment › Other › Labels
Date: 01/08/2003
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRE…
NHTSA 03V284000
Equipment › Other › Labels
Date: 01/08/2003
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRE…
NHTSA 03V284000
Equipment › Other › Labels
Date: 01/08/2003
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRE…
NHTSA 03V284000
Equipment › Other › Labels
Date: 01/08/2003
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRE…
🔴 KONTROLLLEUCHTEN — UNIVERSELLER LEITFADEN

53 Kontrollleuchten nach Dringlichkeit sortiert. Erscheint sie in Ihrem Fahrzeug? Prüfen Sie die Dringlichkeitsstufe.

Alle Kontrollleuchten anzeigen
🔴 IMMEDIATE STOP — pull over
Oil Pressure WarningEngine
Engine Temperature WarningCooling
!BRAKE
Brake System WarningBrakes
K
Immobilizer / Key FaultSecurity
🟠 WARNING — check soon
Malfunction Indicator Light (MIL) / Check EngineEngine
Diesel Particulate Filter (DPF)Emissions
+−
Battery / Charging SystemElectrical
Low Fuel WarningFuel
!BRAKE
ABS WarningBrakes
!BRAKE
Brake Pad Wear IndicatorBrakes
!BRAKE
Electronic Parking Brake (EPB)Brakes
!
Power Steering WarningSteering
ESC / Stability Control FaultChassis
Tire Pressure Warning (TPMS)Chassis
Transmission Temperature WarningTransmission
Transmission / Gearbox FaultTransmission
Airbag / SRS WarningActive safety
EGR / Exhaust Gas Recirculation FaultEmissions
Catalytic Converter / Emissions FaultEmissions
AdBlue / DEF Level LowEmissions
Coolant Level LowCooling
Hybrid / EV System WarningHybrid
EV Charge System FaultHybrid
12V Battery (Hybrid/EV Auxiliary)Hybrid
S
Suspension Fault / Air SuspensionSuspension
N
CAN Bus / Network Communication FaultNetwork
Water in Fuel FilterFuel
Diesel Injector FaultFuel
!
Steering Angle Sensor FaultSteering
Turbo / Boost Pressure FaultEngine
Regenerative Braking Fault (Hybrid/EV)Hybrid
🟡 MONITOR
Fuel Cap / Evap SystemEmissions
?
4WD / AWD SystemDrivetrain
L
Bulb Failure WarningLighting
L
Headlight Range / Leveling FaultLighting
Service / Maintenance DueMaintenance
AC
A/C System FaultHvac
Clutch Wear WarningTransmission
A
Cruise Control / ACC FaultADAS
🔵 INFORMATION
Engine Temperature Low (Blue)Cooling
Glow Plug / Diesel PreheatEngine
Traction Control / ESC OffChassis
Seatbelt ReminderActive safety
L
Rear Fog Light IndicatorLighting
A
Lane Departure / LDWS WarningADAS
A
Forward Collision Warning (FCW/AEB)ADAS
A
Blind Spot Monitor FaultADAS
A
Rear Parking Sensor / Camera FaultADAS
Windshield Washer Fluid LowMaintenance
!
Door Open WarningBody
!
Hood / Trunk Open WarningBody
Gear Shift Indicator (Manual)Transmission
Sport / Performance Mode ActiveTransmission
📢 GEMELDETE BESCHWERDEN & PROBLEME (NHTSA)

399 Beschwerden von Haltern bei der US-amerikanischen National Highway Traffic Safety Administration (NHTSA) für Volvo S40 über die Modelljahre 2000–2011. Es sind echte, verifizierte Meldungen von Fahrzeughaltern.

35 crash reports 11 fires 22 injuries
Beschwerden nach Modelljahr (die häufigsten zuerst)
Modelljahr 200060
Modelljahr 200160
Modelljahr 200560
Modelljahr 200659
Modelljahr 200450
Modelljahr 200227
Modelljahr 200725
Modelljahr 200318
Am häufigsten gemeldete Bauteile (alle Jahre)
Electrical System87
Service Brakes73
Hydraulic58
Engine And Engine Cooling45
Vehicle Speed Control38
Air Bags34
Beispiele für Meldungen
TL* THE CONTACT OWNS A 2005 VOLVO S40. WHILE DRIVING VARIOUS SPEEDS ON SEVERAL OCCASIONS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP E… (MY 2005)
TL*THE CONTACT OWNS A 2004 VOLVO S40. WHILE DRIVING 30 MPH, THE VEHICLE RAPIDLY ACCELERATED AUTOMATICALLY. THE VEHICLE WOULD NOT SLOW DOWN WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT HAD A DIFFICULT TIME PULLING THE VEHICLE OVER T… (MY 2004)
TL* THE CONTACT OWNS A 2001 VOLVO S40. THE CONTACT STATED THAT THE HEATER FAN STOPPED OPERATING AND THE DEFROSTER FUNCTION WAS AFFECTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 01V169… (MY 2001)
TL* THE CONTACT OWNS A 2006 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE ENGINE STALLED WHILE THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAI… (MY 2006)

Quelle: NHTSA-Beschwerdedatenbank (U.S. data.gov). Die Daten decken die Produktionsjahre 2000–2011 ab.

Häufige Fragen

Which OBD2 fault codes are commonly documented for the Volvo S40 (2000–2011)?

Commonly documented OBD2 codes across many vehicles include: P0420, P0300, P0171. Find the full description, likely causes and estimated repair costs in the OBD2 Codes section on this page.

How often should the Volvo S40 (2000–2011) be serviced?

Routine maintenance for the Volvo S40 (2000–2011) typically includes an oil change every 6,000–9,000 miles (10,000–15,000 km), an air filter every 12,000–18,000 miles (20,000–30,000 km) and a brake inspection every 12,000 miles (20,000 km). Check the full plan with specific intervals in the Scheduled Maintenance section on this page.

Found what you were looking for? Explore other Volvo models in our database, compare tyre offers in your size, or search a specific fault code in the TroubleAtlas OBD2 database.

Weitere Volvo-ModelleReifen vergleichenOBD2-Code suchen
Scroll to Top